Safety Alert; California Proposition - Craftsman INCREDI-PULL 316.794711 Operator's Manual

TABLE OF CONTENTS
Rules for Safe Operation ................................................................................. 2
Warranty .......................................................................................................... 4
Know Your Unit ............................................................................................... 4
Assembly Instructions ..................................................................................... 4
Oil and Fuel Information .................................................................................. 5
Starting/Stopping Instructions ........................................................................ 5
Operating Instructions .................................................................................... 6
Maintenance and Repair Instruchons ............................................................. 6
Cleaning and Storage ..................................................................................... 8
Speed Start
TM
Accessory ................................................................................ 8
Troubleshooting Chart ..................................................................................... 9
Specifications ............................................................................................... 10
Parts List ....................................................................................................... 22
Service Numbers ........................................................................... Back Cover
All information, illustrations, and specifications in this manual are based on the
latest product information available at the time of printing. We reserve the right
to make changes at any time without notice.
SPARK ARRESTOR NOTE
NOTE: For users on U.S. Forest Land and in the states of California, Maine,
Oregon and Washington. All U.S. Forest Land and the state of California
(Public Resources Codes 4442 and 4443), Oregon and Washington require, by
law that certain internal combustion engines operated on forest brush and/or
grass-covered areas be equipped w_th a spark arrestor, maintained _neffectwe
working order, or the engine be constructed, equipped and maintained for the
prevenhon of fire. Check w_th your state or local authorities for regulahons
pertaining to these requirements. Failure to follow these requirements could
subject you to liability or a fine. This unit is factory equipped with a spark
arrestor. If it requires replacement, ask your LOCAL SERVICE DEALER to
install the Accessory Part #753-05900 Muffler Assembly
The purpose of safety symbols is to attract your attention to possible dangers. I
The safety symbols, and their explanations, deserve your careful attention I
and understanding. The safety warnings do not by themselves eliminate any
danger. The instructions or warnings they give are not substitutes for proper
accident prevention measures.
SYMBOL MEANING
_, SAFETY ALERT:
Indicates danger, warning or caution.
Attention is required in order to avoid serious personal injury.
May be used in conjunction with other symbols or plctographs.
NOTE: Advises of information or instructions vital to the operation or
maintenance of the equipment.
_, DANGER:
Failure to obey a safety warning will result in serious
injury to yourself or to others. Always follow the safety precautions
to reduce the risk of fire, electric shock and personal injury.
_, ARNING:
Failure to obey a safety warning can result in injury
to yourself and others. Always follow the safety precautions to
reduce the risk of fire, electric shock and personal injury.
,_ CAUTION:
Failure to obey a safety warning may result in
property damage or personal injury to yourself or to others.
Always follow the safety precautions to reduce the risk of fire,
electric shock and personal injury.
Read the Operator's Manual and follow all warnings and safety
instructions. Failure to do so can result in serious injury to the operator
and/or bystanders. FOR QUESTIONS, CALL 1-800-4-MY-HOME®
A
READ ALL INSTRUCTIONS BEFORE OPERATING
• IMPORTANT SAFETY INSTRUCTIONS •
CALIFORNIA PROPOSITION 65
WARNING: Engine exhaust, some of its constituents and
certain fln_shed components contain or emit chemicals known to
the State of California to cause cancer and birth defects or other
reproductive harm. Wash hands after handling.
,_ WARNING:
When using the unit, all safety rules must be
followed. Please read these _nstruct_ons before operating the unit
_norder to ensure the safety of the operator and any bystanders.
Please keep these instructions for later use.
• Read the instructions carefully. Be familiar with the controls and proper use
of the unit.
• Do not operate this unit when tired, ill, or under the influence of alcohol,
drugs, or medication.
• Children and teens under the age of 15 must not use the unit, except for
teens guided by an adult.
• All guards and safety attachments must be installed properly before
operating the unit.
• Inspect the unit before use. Replace damaged parts. Check for fuel leaks.
Make sure all fasteners are in place and secure. Replace parts that are
cracked, chipped, or damaged in any way. Do not operate the unit with
loose or damaged parts.
• Carefully inspect the area before starting the unit. Remove all debris and
hard or sharp objects such as glass, wire, etc.
• Clear the area of children, bystanders, and pets. At a minimum, keep all
children, bystanders, and pets outside a 50 feet (15 m) radius; there still
may be a risk to bystanders from thrown objects. Bystanders should be
encouraged to wear eye protection. If you are approached, stop the unit
immediately.
• Squeeze the throttle control and check that _treturns automatically to the
idle position. Make all adjustments or repairs before using unit.
SAFETY WARNINGS FOR GAS UNITS
_, WARNING:
Gasoline is highly flammable and its vapors can
explode if ignited. Take the following precautions:
• Store fuel only in containers specifically designed and approved for the
storage of such materials.
• Always stop the engine and allow it to cool before filling the tank. Never
remove the fuel tank cap or add fuel when the engine is hot. Always loosen
the fuel tank cap slowly to relieve any pressure in the tank before fueling.
DO NOT smoke.
• Always add fuel in a clean, well-ventilated outdoor area where there are no
sparks or flames. DO NOT smoke.
• Never operate the unit without the fuel cap securely in place.
• Avoid creating a source of ignition for spilled fuel. Wipe up any spilled fuel
from the unit immediately, before starting the unit. Move the unit at least 30
ft. (9.1 m) from the fueling source and site before starting the engine. DO
NOT smoke.
• Never start or run the unit ins_dea closed room or bu_ldng Breathing exhaust
fumes can k_ll Operate th_s unit only _na well ventilated outdoor area
WHILE OPERATING
• Wear safety glasses or goggles that are marked as meeting ANSI Z87.1-
1989 standards and are marked as such.
• Never run the unit w_thout the proper equipment attached. Do not operate
the unit w_thout the blower tubes attached.
• To reduce the risk of hearing loss associated with sound level(s), always
wear ear/heanng protection when operating th_s unit.
• Wear heaw long pants, boots, gloves, and a long sleeve shirt. Do not wear
loose clothing, jewelry, short pants, sandals or go barefoot. Secure hair
above shoulder level.
• Use the unit only in daylight or good artificial light.
• Keep outside surfaces free from oil and fuel.
• Avoid accidental starting. Be in the starting position whenever pulling
the starter rope. The operator and unit must be _na stable pos_t_on while
starting. Refer to Starting/Stopping Instructions.
• Do not set unit on any surface except a clean, hard area while engine is
running. Debris such as gravel, sand, dust, grass, etc. could be picked up
by the air intake and thrown out by the discharge opening, damaging unit,
property, or causing serious injury to bystanders or operator.
• Use the right tool. Only use this tool for its intended purpose.
• Do not force unit. It will do the job better and with less likelihood of injury
at a rate for which it was designed.
• Do not overreach or use from unstable surfaces such as ladders, trees,
steep slopes, rooftops, etc. Always keep proper footing and balance.
• Always hold the unit with a firm grip when operating.
• Keep hands, face, and feet away from all moving parts Do not touch or try to
stop the impeller when it is rotating Do not operate without guards in place
• Do not put any object into openings. Do not use with any opening blocked;
keep free of dirt, debris, and anything that may reduce the air flow.
• Do not touch the engine or muffler. These parts get extremely hot from
operation, even after the unit is turned off.
• Do not operate the engine faster than the speed needed to do the job. Do
not run the engine at high speed when not in use.
• Always stop the engine when operation is delayed or when walking from
one location to another.
• Stop the engine for maintenance, repair, to install or remove the blower
tubes. The unit must be stopped and the impeller no longer turning to
avoid contact with the rotating blades.
• If you strike or come into contact with a foreign object, stop the engine
immediately and check for damage. Do not operate before repairing
damage. Do not operate the unit with loose or damaged parts.
• Use only genuine factory replacement parts and accessories for this
unit. These are available from your authorized service dealer. Use of any
unauthorized parts or accessories could lead to serious injury to the user
or damage to the unit, and void your warranty.
• To reduce fire hazard, replace faulty muffler and spark arrestor. Keep the
engine and muffler free from grass, leaves, excessive grease or carbon
build up.
• Never use this unit for spreading chemicals, fertilizers or other substances
which may contain toxic materials.
• Never point the blower in the direction of bystanders, animals, windows or
automobiles.
OTHER SAFETY WARNINGS
• Never store the unit, with fuel in the tank, inside a building where fumes
may reach an open flame (pilot lights, etc.) or sparks (switches, electrical
motors, etc.).
• Allow the engine to cool before storing or transporting. Be sure to secure
the unit while transporting.
• Store the unit in a dry place, either locked up or up high to prevent
unauthorized use or damage. Keep out of the reach of children.
• Never douse or squirt the unit with water or any other liquid. Keep handles
dry, clean, and free from debris. Clean after each use, see Cleaning and
Storage instructions.
• Keep these instructions. Refer to them often and use them to instruct other
users. If you loan this unit to others, also loan these instructions to them.
SPECIAL NOTE: Exposure to vibrations through prolonged use of gasoline
powered hand tools could cause blood vessel or nerve damage in the
fingers, hands, and joints of people prone to circulation disorders or
abnormal swelling. Prolonged use in cold weather has been linked to blood
vessel damage in otherwise healthy people. If symptoms occur such as
numbness, pain, loss of strength, change in skin color or texture, or loss of
feeling in the fingers, hands or joints, discontinue use of this tool and seek
medical attention. An anti-vibration system does not guarantee avoidance
of these problems. Users who operate power tools on a regular basis must
closely monitor their physical condition and the condition of this tool.
SAVE THESE INSTRUCTIONS
• SAFETY & INTERNATIONAL SYMBOLS •
This operator's manual describes safety and international symbols and plctographs that may appear on this product. Read the operator's manual for complete
safety, assembly, operating and maintenance and repair information.
SYMBOL MEANING
• SAFETY ALERT SYMBOL
Indicates danger, warning or caution. May be used in
conjunction with other symbols or plctographs.
[_ • READ OPERATOR'S MANUAL
WARNING:
Read the operator's manual(s) and follow
all warnings and safety instructions. Failure to do so can
result =nserious injury to the operator and/or bystanders.
• WEAR EYE AND HEARING PROTECTION
@
I "
O "
WARNING:
Thrown objects and loud noise can cause
severe eye injury and heanng loss Wear eye protection
meeting ANSI Z87.1-1989 standards and ear protection when
operating th=sunnt. Use a full face sh=eld when needed.
• UNLEADED FUEL
Always use clean, fresh unleaded fuel
OIL
Refer to operator's manual for the proper type of oil.
DO NOT USE E85 FUEL IN THIS UNIT
WARNING:
It has been proven that fuel containing
greater than 10% ethanol wdl hkely damage th_s engine
and void the warranty.
ON/OFF CONTROL
ON / START / RUN
ON/OFF CONTROL
OFF or STOP
SYMBOL
I-4 Iqlfl
A
rain. 50 ft
MEANING
• PRIMER BULB
Push primer bulb, fully and slowly, 10 times.
• CHOKE CONTROL
1. • FULL choke position
2. • PARTIAL choke position
3. • RUN choke pos_t_on
• THROWN OBJECTS AND ROTATING CUTTER CAN
CAUSE SEVERE INJURY
WARNING:
Small objects can be propelled at high
speed, causing Inlury. Keep away from the rotating rotor.
• KEEP BYSTANDERS AWAY
WARNING:
Keep all bystanders, especially children
and pets, at least 50 feet (15 m) from the operating area.
HOT SURFACE
WARNING: Do not touch any metal engine
components. The engine gets extremely hot from
operation and may cause severe burns. Allow the unntto
completely cool prior to any maintenance or servicing.
BLOWERS - ROTATING IMPELLER BLADES CAN
CAUSE SEVERE INJURY
WARNING:
Stop the engine and allow the impeller
to stop before installing or changing tubes, or before
cleaning or performing any maintenance.
2 3