Digital Outputs; Connector Pin Descriptions; Digital/Analogs - Generac Power Systems Power Zone 410 Technical Manual

Input/Output and Connector Information

Digital Outputs

Default Signal Name
Engine Preheat (Diesel)
Fuel On Relay
Start On Relay
Low Fuel Level
High Fuel Level
Audible Alarm
Alarm On Relay
Spare Digital Output
Engine Control Unit Relay
Utility Transfer Relay
Generator Transfer Relay
Throttle Drive (PWM signal)
Throttle Enable
Automatic Voltage Regula-
tion (PWM1)
Automatic Voltage Regula-
tion (PWM2)

Connector Pin Descriptions

DIGITAL/ANALOGS

J5 24 Pin Signal
1 Ruptured Tank
2 2-wire (ret)
3 2-wire Start(1)
4 2-wire Start(2)
5 Xfer Position1
6 Xfer Position2
7 Theft
8 Extern Charger
9 TriclopsYEL
10 TriclopsGRN
11 TriclopsRED
12 Triclops+5V
13 DualFuel1/Low Fuel Lvl
20
Range/Level Connection
Relay Contacts J10-9
(30 V, 5 A max)
Relay Contacts J10-8
(30 V, 5 A max)
Relay Contacts J10-7
(30 V, 5 A max)
Open Drain (+VBATT, J5-13
1.7 A device limited)
Open Drain (+VBATT, J5-14
1.7 A device limited)
Open Drain (+VBATT, J9-6
1.7 A device limited)
Relay Contacts J10-5
(30 V, 5 A max) J10-6
Open Drain (+VBATT, J10-13
1.7 A device limited)
Relay Contacts J10-12
(30 V, 5 A max)
Relay Contacts J10-16
(30 V, 5 A max)
Relay Contacts J10-14
(30 V, 5 A max) J10-15
Open Drain (+VBATT, J2-6
1.7 A device limited)
Open Drain (+VBATT, J2-7
1.7 A device limited)
Field+ J1-4
Field- J1-2
Board Connection Description
5 V pullup
GND
5 V pullup (NO)
5 V pullup (NC)
5 V pullup (GEN)
5 V pullup (UTILITY)
5 V pullup (door closed pulled to GND)
5 V pullup (ext charger pulled to GND)
Open collector with 240 Ω resistor
Open collector with 240 Ω resistor
Open collector with 240 Ω resistor
+5 V for Triclops with 50 mA fuse
NG/LO_FUEL (open drain)
Wire #
567
0
183
183A
525
524
A1
BC1
819
817
818
820
502
Technical Manual Power Zone 410 Controller