Troubleshooting; Blown Fuse Or Circuit Breaker; Gate Does Not Open. Agitator Does Not Turn; Gate Does Not Open Or Is Sluggish Agitator Turns - Cornelius ENDURO 250 Operator's Manual

IMPORTANT: Only qualified personnel should service internal components or electrical wiring.
!
WARNING:
If repairs are to be made to a product system, remove quick disconnects from the applicable product tank, then
relieve the system pressure before proceeding. If repairs are to be made to the CO2 system, stop dispensing, shut
off the CO2 supply, then relieve the system pressure before proceeding. If repairs are to be made to the refrigeration
system, make sure electrical power is disconnected from the unit.
Should your unit fail to operate properly, check that there is power to the unit and that the hopper contains ice. If the
unit does not dispense, check the following chart under the appropriate symptoms to aid in locating the defect.
Trouble

BLOWN FUSE OR CIRCUIT BREAKER.

GATE DOES NOT OPEN. AGITATOR DOES
NOT TURN.
GATE DOES NOT OPEN OR IS SLUGGISH.
AGITATOR TURNS.

ICE DISPENSES CONTINUOUSLY.

SLUSHY ICE. WATER IN HOPPER.

BEVERAGES DO NOT DISPENSE.

BEVERAGES TOO SWEET.

BEVERAGE NOT SWEET ENOUGH.

BEVERAGES NOT COLD (UNITS WITH
BUILT--IN COLD PLATE).
© 204-2010, IMI Cornelius Inc.

TROUBLESHOOTING

A. Short circuit in wiring.
B Defective gate solenoid.
C Defective agitator motor.
A. No power.
B. Bent depressor plate (does not actuate switch).
C. Defective dispensing switch.
A. Defective gate solenoid.
B. Excessive pressure against gate slide.
C. Defective Rectifier.
A. Stuck or bent depressor plate (does not release switch).
B. Defective dispensing switch.
C. Improper switch installation.
A. Blocked drain.
B. Unit not level.
C. Poor ice quality due to water quality or icemaker prob-
lems.
D. Improper use of flaked ice.
A. No 24 volt power to faucets.
B. No CO2 pressure.
A. Carbonator not working.
B. No CO2 pressure in carbonator.
C. Faucet brix requires adjusting.
A. Empty syrup tank.
B. Faucet brix requires adjusting.
A. Unit standing with no ice in hopper -- no ice in cold plate
cabinet.
- 8 -
Ice/Beverage Dispenser Operators Manual
Probable Cause
Publication Number: 92108OPR