Cornelius ENDURO 250 Operator's Manual
Ice/beverage dispenser
Hide thumbs
Also See for ENDURO 250:
- Operator's manual (20 pages) ,
- Service manual (12 pages) ,
- Technical specifications (2 pages)
Table of Contents
Advertisement
Quick Links
Download this manual
See also:
Service Manual
Advertisement
Table of Contents
Related Manuals for Cornelius ENDURO 250
Summary of Contents for Cornelius ENDURO 250
- Page 1 OPERATOR’S MANUAL ICE/BEVERAGE DISPENSER MODEL: ENDURO 200/250 Release Date: March 2, 2004 Publication Number: 92108OPR Revision Date: August 3, 2010 Revision: C Visit the IMI Cornelius web site at www.cornelius.com for all your Literature needs.
-
Page 2: Contact Information
Commercial Warranty. Cornelius will not be responsible for any repair, replacement or other service required by or loss or damage resulting from any of the following occurrences, including but not limited to, (1) other than normal and proper use and normal... -
Page 3: Table Of Contents
TABLE OF CONTENTS Safety Instructions ............. 1 Read And Follow All Safety Instructions . -
Page 4: Safety Instructions
Only trained and certified electrical, plumbing and refrigeration technicians should service this unit. ALL WIRING AND PLUMBING MUST CONFORM TO NATIONAL AND LOCAL CODES. FAILURE TO COMPLY COULD RESULT IN SERIOUS INJURY, DEATH OR EQUIPMENT DAMAGE. Publication Number: 92108OPR AFETY NSTRUCTIONS Recognize Safety Alerts - 1 - © 2004-2010, IMI Cornelius Inc. -
Page 5: Safety Precautions
NOTE: Many units incorporate the use of additional equipment such as icemakers. When any addition equipment is used you must check with the equipment manufacturer to determine the additional weight the counter will need to support to ensure a safe installation. © 204-2010, IMI Cornelius Inc. Ice/Beverage Dispenser Operators Manual ARNING... -
Page 6: Start-Up And Operating Instructions
Publication Number: 92108OPR F. This could cause damage to the unit. - 3 - F. Do not allow the unit © 2004-2010, IMI Cornelius Inc. -
Page 7: Cleaning And Maintenance Instructions
CLEANING AND MAINTENANCE INSTRUCTIONS These instructions are used on all Cornelius ice drink dispensers. Some models may have additional cleaning requirements. Those models will have addition procedures listed later in the manual. WARNING: Disconnect power to the unit before cleaning or servicing following all lock out / tag out procedures established by the user. -
Page 8: Monthly Cleaning: (In Addition To Daily And Weekly Procedures)
6. Install and properly position the access covers on the cold plate. 7. Install the splash panel in the reverse order it was removed. 8. Rinse cold plate surface by pouring potable water through hopper openings. Publication Number: 92108OPR - 5 - © 2004-2010, IMI Cornelius Inc. -
Page 9: Dispensing Valves: ( Daily Cleaning)
9. Remove the sanitizing fittings from the B–I–B disconnects and connect the disconnects to the appropriate B–I–B container. Operate the valves until all sanitizer has been flushed from the system and syrup is flow- ing freely. © 204-2010, IMI Cornelius Inc. Ice/Beverage Dispenser Operators Manual system. -
Page 10: Replenishing Co2 Supply (As Required)
- 7 - cylinder”) portion of the dial, CO pressure to escape, then remove the cylinder with a safety chain to prevent it regulator can cause serious © 2004-2010, IMI Cornelius Inc. cylin-... -
Page 11: Troubleshooting
BEVERAGES DO NOT DISPENSE. BEVERAGES TOO SWEET. BEVERAGE NOT SWEET ENOUGH. BEVERAGES NOT COLD (UNITS WITH BUILT--IN COLD PLATE). © 204-2010, IMI Cornelius Inc. Ice/Beverage Dispenser Operators Manual TROUBLESHOOTING A. Short circuit in wiring. B Defective gate solenoid. C Defective agitator motor. -
Page 12: Flavor Syrups Do Not Dispense
A. Dip switch settings on control board incorrect. B. PC board defective. C. Defective flow control. A. Dip switch settings on control board incorrect. B. Flow control incorrectly set. C. PC board defective. D. Defective flow control. - 9 - © 2004-2010, IMI Cornelius Inc. - Page 14 IMI Cornelius Inc. www.cornelius.com...