Table Of Contents - Maytag Amana NDE2330AYW Service Manual

Table of Contents

Important Information ................................................... 2
Important Safety Information ........................................ 4
Introduction
Model Identification ................................................... 5
Electrical Service Information ................................... 5
About Ground Wires ................................................. 5
General Information
Dryer Operation ......................................................... 6
Component Testing Information ................................... 7
Burner System Operation .................................... 10
Ignition System Features ........................................ 10
Electric Circuit to Ignition System ............................ 10
Temperature Settings .............................................. 10
Internal Motor Diagram and Schematic ....................... 11
Troubleshooting Procedures
1. Motor does not operate. ..................................... 13
2. Dryer stops in middle of cycle, quits after a
couple loads, has a burning smell or cycles on
motor thermal protector. ..................................... 13
3. Motor operates but cylinder does not turn. ......... 14
4. Motor does not stop. .......................................... 14
5. Ignitor does not glow. ......................................... 14
6. Heating assembly does not heat or burner does
not ignite. ............................................................ 15
7. Burner ignites and goes out repeatedly. ............. 15
8. Ignitor glows but burner does not ignite. ............ 16
9. Heater assembly or burner shuts off prematurely.16
10.Heater assembly or burner repeatedly cycles
off on limit thermostat. ........................................ 16
11.Heater assembly or burner does not shut off. .... 17
12.Clothes do not dry.. ............................................ 17
13.Signal does not operate correctly. ...................... 17
14.Timer does not advance in AUTOMATIC cycle. . 18
15.Clothing is too hot when removing from dryer. ... 18
Disassembly Procedures
Control Hood Assembly ........................................... 19
Control Hood End Panels ........................................ 19
Electronic Control .................................................... 19
Timer ....................................................................... 19
Signal Switch ........................................................... 20
Selector Switch ....................................................... 20
Rocker Switch ......................................................... 21
Graphic Panel ......................................................... 21
Loading Door and Door Hinges ............................... 21
Door Pull ................................................................. 21
Door Strike and Door Seal ...................................... 21
Door Switch ............................................................. 21
Door Catch .............................................................. 21
Door Reversal ......................................................... 22
Service Access Panel ............................................. 23
Front Panel ............................................................. 23
Front Panel Seal ..................................................... 23
©2004 Maytag Services
Hold-Down Clips and Locators ................................ 23
Cabinet Top ............................................................. 23
Front Bulkhead Assembly ....................................... 24
Front Air Duct .......................................................... 24
Moisture Sensor ...................................................... 24
Cylinder Light .......................................................... 24
Cylinder Light Receptacle ....................................... 25
Cylinder Belt ............................................................ 25
Cylinder Assembly ................................................... 25
Cylinder Rollers ....................................................... 26
Rear Seal ................................................................ 26
Rear Bulkhead and Heater Box .............................. 26
Heating System ....................................................... 27
Limit Thermostat (Gas Models) ............................... 28
Heating Element (Electric Models) .......................... 28
Limit Thermostat and Thermal Fuse
(Electric Models) .................................................. 29
Cabinet .................................................................... 29
Base ........................................................................ 30
Thermistor or Thermostat and Heater ..................... 30
Motor and Exhaust Assembly .................................. 31
Terminal Block ........................................................ 32
Terminal Block Terminals ........................................ 32
Power Cord ............................................................. 32
Appendix A
Installation Instructions........................................... A-2
16023020 3