Scag Power Equipment TurfTiger II STTII-52V-25CH-LP-EFI Operator's Manual page 67

Section 8
Ref.
Part No. Description
No.
1 427106 Cover, Rear
2 04003-07 Bolt, Carriage 1/4-20 x 1/2"
3 04003-02 Bolt, Carriage 1/4-20 x 3/4"
4 425214 Bracket, Idler Stop
5 04019-02 Nut, Serrated Flange 1/4-20
6 04041-11 Flatwasher, 3/8-.406 x 1.50 x 7 Gauge
7 04021-09 Nut, Elastic Stop 3/8-16
8 482744 Pulley, 5.75 O.D. (Gas & LP Engines)
482745 Pulley, 6.35 O.D. (Diesel Engine)
9 485909 Belt, STTII Pump Drive (Gas & LP Engines)
485928 Belt, STTII Pump Drive (Diesel Engine)
10 04063-27 Key, 5mm x 5mm x 30mm
11 481884 Tapered Hub, 17mm Bore
12 483675 Pulley, 5.67 O.D. (Kawasaki & Kohler Only)
485867 Pulley, 5.67 O.D. (31BV,35BV & 37BV-EFI
Only)
483829 Pulley, 5.67 O.D (Kubota Diesel Only)
13 04021-05 Nut, Center Lock 3/8-16
14 04043-04 Flatwasher, 3/8-.391 x .938 x .105 HD
15 483214 Pulley, Idler 4"
16 48224 Bearing
17 462989 Idler Arm Assy. (incl. #16 & #73)
18 04019-06 Nut, Serrated Flange 1/2-13
19 04001-185 Bolt, Hex Head 1/2-13 x 2" Grade 8
20 04001-172 Bolt, Hex Head 1/4-20 x 1" Grade 8
21 482949 Pulley, 6.70 O.D.
22 43651 Stud, Anti-Rotation
23 04069-01 Pin, Rue Cotter
24 482845 Rod Assembly
25 04040-12 Flatwasher, 3/8-.438 x 1.00 x .083
26 04001-32 Bolt, Hex Head 3/8-16 x 1-1/4"
27 461661 Clutch Assembly, GT3.5
462011 Clutch Assembly, GT3.5 (Diesel Engine)
461826 Clutch Assembly, GT5 (31BV,35BV &
37BV-EFI)
28 04041-28 Flatwasher, 7/16-.469 x 1.50 x .1793
29 04030-05 Lockwasher, 7/16"
30 04102-04 Bolt, Hex Head 7/16-20 x 2-1/2" (Kohler)
04102-03 Bolt, Hex Head 7/16-20 x 2-1/4"
(31BV,35BV & 37 BV-EFI)
04102-03 Bolt, Hex Head 7/16-20 x 2-1/4" (Kubota)
04103-02 Bolt, Hex Head M10-1.5 x 50 (Kawasaki)
31 04063-23 Key, 1/4 x 1/4 x 3-1/4"
32 04001-170 Bolt, Hex Head 3/8-16 x 2-1/2" Grade 8
33 481536 Tapered Hub, 1" Bore
34 04001-109 Bolt, Hex Head 1/4-20 x 1.375 Full Thread
35 04030-02 Lockwasher, 1/4"
36 48181 Pulley, Idler
37 482876 Belt, Deck Drive
38 04019-04 Nut, Serrated Flange 3/8-16
39 04021-05 Nut, Center Lock 3/8-16
40 484754 Spring, PTO (Gas & LP Engines)
483430 Spring, PTO (Diesel Engine)
41 04001-136 Bolt, Hex Head 3/8-16 x 1-1/2" Grade 8
42 04001-171 Bolt, Hex Head 3/8-16 x 4-1/2"
43 461609 Idler Arm Assy., PTO Drive (incl. #16)
44 43632 Pivot, Idler - PTO
45 481284 Bumper, Rubber
STTII DECK DRIVE COMPONENTS
61
Ref.
Part No. Description
No.
46 04019-03 Nut, Serrated Flange 5/16-18
47 04001-19 Bolt, Hex Head 3/8-16 x 1"
48 04063-06 Key, 1/4 x 1/4 x 1-1/2"
49 04001-176 Bolt, Hex Head 5/16-18 x 1-3/4" Grade 8
50 461697 Spindle Assy., PTO
51 43534 Shaft, Deck Drive
52 481024 Seal
53 481022 Bearing Assembly, Tapered
54 43644 Spindle Housing
55 48677 Relief Fitting
56 48114-04 Grease Fitting, 1/4-28
57 43296 Spacer, Inside
58 43312 Spacer, Outside
59 481025 Seal, 2" O.D. x 1.625 Bore
60 43297 Spindle Bushing, Bottom
61 481035 Nut, 1.06 - 18
62 482424 Driveshaft
63 04063-20 Key, 1/4 x 1/4 x 1"
64 04001-21 Bolt, Hex Head 3/8-16 x 1-3/4"
65 04021-05 Nut, Center Lock 3/8-16
66 04012-06 Set Screw, 3/8-16 x 1/2" Internal Hex
67 452864 Pump Mounting Plate Weldment
452886 Pump Mounting Plate Weldment (Diesel)
68 481309 Latch, Hood
69 04011-11 Screw, #10-32 x .563 Shakeproof
70 04001-20 Bolt, Hex Head 3/8-16 x 1-1/2"
71 431051 Spacer, Spring Anchor
72 431049 Spacer, Controls
73 431050 Spacer, Bearing
74 04030-03 Lockwasher, 5/16"
75 04021-22 Nut, Elastic Stop 5/16-18 Grade 8
76 04040-15 Flatwasher, 5/16-.375 x .875 x .083
77 481531 Hinge, Belt Cover
78 484754 Spring Pump Drive
79 04001-22 Bolt, Hex Head 3/8-16 x 2-3/4"
R
(Gas & LP)