Polaris RANGER 570 2017 Owner's Manual For Maintenance And Safety page 65

Periodic Maintenance Chart
Item
Cooling system (if applicable)
► Oil lines, fasteners
► Engine oil and filter change
► Front Gearcase oil (if equipped)
► Middle Gearcase oil (if equipped)
► Rear gearcase oil (if equipped)
► Transmission oil
D Fuel system
► Radiator (if applicable)
► Cooling Hoses
► Engine mounts
Exhaust muffler/pipe
► Spark plug
D Ignition timing
► Wiring
D Clutches
►
D Front wheel bearings
D Brake fluid
Spark arrester
► Coolant
Valve clearance
Idle speed
D Toe adjustment
D Auxiliary brake (if equipped)
►
Headlight aim
Lubrication Recommendations
Check and lubricate all components at the intervals outlined in the Periodic Maintenance
Chart beginning on page 61, or more often under severe use, such as wet or dusty conditions.
Items not listed in the chart should be lubricated at the general lubrication interval.
Item
Engine Oil
Brake Fluid
Main Gearcase Oil
(Transmission)
Front Gearcase Oil
Front Prop Shaft Yoke
Maintenance Interval
(whichever comes first)
Hours Calendar
50 H 6 M
50 H 6 M
100 H 6 M
100 H 6 M
100 H 6 M
100 H 6 M
100 H 12 M
100 H 12 M
100 H 12 M
100 H 12 M
100 H 12 M
100 H 12 M
100 H 12 M
100 H 12 M
100 H 12 M
100 H 12 M
100 H 12 M
200 H 24 M
300 H 36 M
- 60 M
500 H -
Lube
PS-4 5W-50 4-Cycle Oil
DOT 4 Brake Fluid
AGL Gearcase Lubricant & Transmission
Fluid
Demand Drive Fluid
U-Joint Grease
km (Miles)
- Inspect coolant strength seasonally;
pressure test system yearly
- Inspect for leaks and loose fittings
1600 (1000) Change oil and filter; (perform a break-
in oil change at one month)
- Inspect level; change yearly
- Inspect level; change yearly
- Inspect level; change yearly
1600 (1000) Change fluid
1600 (1000) Cycle key to pressurize fuel pump;
check for leaks at fill cap, fuel lines/rail
and fuel pump; replace lines every two
years
- Inspect; clean external surfaces
- Inspect for leaks
- Inspect
- Inspect
1600 (1000) Inspect; replace as needed
- Inspect
- Inspect for wear, routing, security; apply
dielectric grease to connectors sub-
jected to water, mud, etc.
1600 (1000) Inspect; clean; replace worn parts
- Inspect; replace as needed
- Change every two years
- Clean out
- Replace coolant
8000 (5000) Inspect; adjust as needed
- Adjust as needed
- Inspect periodically; adjust when parts
are replaced
- Inspect daily; adjust as needed
- Adjust as needed
See page 64
See page 76.
See page 66.
See page 67.
Locate fittings and grease (3 pumps
maximum).
MAINTENANCE
Remarks
Method
63