Table of Contents
Advertisement
•
If for any reason any part of the mast hangs up or winch cable develops slack while raising or lowering
the mast, STOP immediately and contact an authorized service representative.
•
NEVER remove safety pin or pull mast locking pin while the mast is up.
•
NEVER use the unit if insulation on electrical cord is cut or worn through.
•
NEVER operate the lights without protective lens cover in place or with a lens cover that is cracked
or damaged.
•
Only use mild soap and water to clean the lens covers. Other chemicals may have an adverse effect
on the glass.
•
NEVER operate a unit while tired, distracted, or under the influence of drugs or alcohol.
•
NEVER use water in the supply tank for human consumption.
•
ALWAYS keep the water tank cover in place. Stay out of tank.
•
DO NOT drive over the hoses while they are pressurized or while the pump is running.
•
NEVER leave the unit unattended while the pump is running.
ENGINE SAFETY
Internal combustion engines present special hazards during operation and fueling. Failure to follow the
safety guidelines described below could result in severe injury or death. Read and follow all safety warnings
described in the engine operator's manual. A copy of this manual was supplied with the unit when it was
shipped from the factory.
•
DO NOT run engine indoors or in an area with poor ventilation unless exhaust hoses are used. Diesel
engine exhaust contains carbon monoxide, a deadly, odorless and colorless gas which, if inhaled,
can cause nausea, fainting or death. Make sure engine exhaust cannot seep into closed rooms or
ventilation equipment.
•
DO NOT operate the unit on a combustible surface.
•
DO NOT fill fuel tank near an open flame, while smoking, or while engine is running. DO NOT fill tank
in an enclosed area with poor ventilation.
•
DO NOT operate with the fuel tank cap loose or missing.
•
DO NOT touch or lean against hot exhaust pipes or engine cylinders.
•
DO NOT clean air filter with gasoline or other types of low flash point solvents.
•
DO NOT remove engine coolant cap while engine is hot.
•
DO NOT operate the unit without a functional exhaust system. Prolonged exposure to sound levels
in excess of 85 dB(A) can cause permanent hearing loss. Wear hearing protection when working
around a running engine.
•
Keep area around exhaust pipes and air ducts free of debris to reduce the chance of an accidental fire.
•
Batteries contain sulfuric acid which can cause severe injury or death. Sulfuric acid can cause eye
damage, burn flesh or eat holes in clothing. Protective eye wear and clothing are necessary when
working on or around the battery. Always disconnect the negative (-) battery cable from the
corresponding terminal before performing any service on the engine or other components.
•
Shut the engine down if any of the following conditions exist during operation:
1.
Noticeable change in engine speed.
2.
Loss of electrical output and/or pumping output.
3.
Equipment connected to the generator overheats.
4.
Sparking occurs.
5.
Engine misfires or there is excessive engine/generator vibration.
6.
Protective covers are loose or missing.
7.
If the ambient air temperature is above 120°F (49°C).
6
Advertisement
Table of Contents
Troubleshooting
