Attention Installer - Empire Comfort Systems DVL36BP30 Series Installation Instructions Manual

Direct-vent gas fireplace heater

Hide thumbs

Table Of Contents

Table of Contents

Use this checklist in conjunction with the instructions in this manual.

Customer: _____________________________________

Lot/Address: ___________________________________

_______________________________________________

Model: ________________________________________

Serial #: ________________________________________

FIREPLACE INSTALLATION

Verified clearances to combustibles (pgs. 19 and 20) .........................................................

Fireplace is leveled and secured ..........................................................................................

VENTING/CHIMNEY/PowerFlow™ HEAT DISTRIBUTION

Venting configuration complies to vent diagrams (pgs. 33 - 37) ..........................................

Venting installed, locked, secured in place with correct clearance .......................................

Firestops installed.................................................................................................................

Exterior wall/roof flashing installed and sealed.....................................................................

Terminations installed and sealed ........................................................................................

Light unit and test venting before enclosing the fireplace ....................................................

ELECTRICAL (pgs. 25 and 26)

Unswitched power (110-120 VAC) provided to the fireplace ................................................

GAS (pgs. 23 and 24)

Proper appliance for fuel type...............................................................................................

Was a conversion performed? ..............................................................................................

Leak check performed and inlet pressure verified ................................................................

FINISHING

Verified all clearances meet installation manual requirements .............................................

Mantels and wall projections meet requirements (pgs. 19 and 21) .....................................

Granite or Clean Face finishing complies with clearance requirements screen ...................

Barrier for glass front properly installed ................................................................................

FIREPLACE SETUP

All packaging and protective materials removed (inside & outside of fireplace) ..................

Media installed correctly .......................................................................................................

Firebox glass door cleaned, installed, and secured .............................................................

Accessories installed properly ..............................................................................................

Started Fireplace and checked for gas leaks .......................................................................

Manual envelope and all contents removed from the fireplace and given to homeowner ....

Empire recommends the following:

•

Keep this checklist visible on the fireplace until the installation is complete.

•

Photograph the installation and copy this completed checklist for your file.

Comments:

Further description of any issues, who is responsible (Installer/Builder/Other, etc) and corrective action needed:

___________________________________________________________________________________________________________

Comments communicated to responsible party _____________________by _____________________ on ______________________

Page 8