Table of Contents
Advertisement
16
BRAKE SYSTEM
Checking the rear brake linings
Warning
Danger of accidents
-
Ensure that worn-out brake linings are replaced immediately.
Changing the rear brake linings
Warning
Danger of accidents
-
Ensure that service work and repairs are performed professionally.
A
Warning
Skin irritation
Brake fluid causes skin irritation.
-
Keep brake fluid out of the reach of children.
-
Wear suitable protective clothing and safety glasses.
-
Do not allow brake fluid to come into contact with the skin, the eyes or clothing.
-
Consult a doctor immediately if brake fluid has been swallowed.
-
Rinse the affected area with plenty of water in the event of contact with the skin.
-
Rinse eyes thoroughly with water immediately and consult a doctor if brake fluid comes into contact with the eyes.
-
If brake fluid spills on to your clothing, change the clothing.
A
Warning
Danger of accidents
-
Make sure that brake fluid for the front and rear brake is changed in accordance with the service schedule.
Warning
Environmental hazard
-
Dispose of oils, grease, filters, fuel, cleaning agents, brake fluid, etc., correctly and in compliance with the applicable
regulations.
Info
Never use DOT 5 brake fluid. It is silicone-based and purple in color. Oil seals and brake lines are not designed for DOT 5
brake fluid.
Avoid contact between brake fluid and painted parts. Brake fluid attacks paint.
Only use clean brake fluid from a sealed container.
-
Check the hand brake lever for a firm pressure point.
Worn-out brake linings reduce the braking effect.
-
Check the brake linings for minimum thickness 6) .
I
Minimum thickness 6)
If the minimum thickness is less than specified:
-
Change the rear brake linings.
-
Check the brake linings for damage and cracking.
If damage or cracking is visible:
-
Change the rear brake linings.
Incorrect maintenance will cause the brake system to fail.
Old brake fluid reduces the braking effect.
Hazardous substances cause environmental damage.
-
Stand the vehicle upright.
-
Remove screw cap
I ;::
1 mm (<:: 0.04 in)
(!!l
p. 116)
(!!l
p. 116)
O
8
with membrane
and the O-ring.
116
Advertisement
Table of Contents
