Summary of Contents for Charmglow CHARMGLOW GRILL 720-0230
Page 1
STAINLESS STEEL GAS GRILL USE AND CARE GUIDE MODEL NO.: 720-0230 ® ® FOR OUTDOOR USE ONLY PLEASE CONTACT 1-800-913-8999 FOR ASSISTANCE DO NOT RETURN TO PLACE OF PURCHASE.
Screw description………………………4 Assembly Instructions……………… 5-11 How to install a gas tank………………12 Propane tank assembly……………… ..13 Installation instruction of Clamp ..…….14 Your gas grill is ready to use…………..15 Gas hook up……………………………16 Leak testing……………………….. 16-17 Installer final checklist………………. . 17 Operating Instructions………………. 18 Lighting Instructions……………….
* * * WARNING * * * FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid 4. If odor continues, immediately call your gas supplier or your fire department. FOR YOUR SAFETY 1.
SAFETY PRACTICES TO AVOID PERSONAL INJURY When properly cared for, your 720-0230(Charmglow) Grill will give safe, reliable service for many years. However, extreme care must be used since the grill produces intense heat and that can increase accident potential.
DO NOT USE BRIQUETTES OF ANY KIND IN THE GRILL. The 720-0230 (Charmglow) Grill is designed for optimum performance without the use of briquettes. Do not place briquettes on the radiant as this will block off the area for the grill burners to vent.
ASSEMBLY INSTRUCTIONS PLEASE READ THE INSTRUCTIONS CAREFULLY AND FOLLOW STEP BY STEP. Attention: Please lock the caster during the process of installation of the grill. TOOLS REQUIRED: Philips head screwdriver(not provide), Crescent wrench(not provide) Step 1:Assemble two regular casters to the right side panels and caster with brakes on the left side panel as shown figure below.
Page 8
Step 3: Assemble the back panel to the two sides panel. with four (4) 5/32 x 10mm screws as shown figure below. Assemble the door handle to the door with the screw which packaged in the condiment rack Step 4:...
Page 9
Insert both doors’ hinge pins through the holes on the bottom of the bottom panel. Make sure the Step 5: washers are in place. Then assembly the header frame on top of both doors by inserting the door hinge pins through the pre-drilled holes on the frame’s bottom side. Push the door and frame unit into the cart and fasten the frame on both sides with four (4) 1/4x38mm screws.
Page 10
: 1.Place flame tamers (3) on to the fire box as show figure below. Step 7 2.Place the cooking grids(2) on. 3. Place the warming rack on. Use four (4)1/4 x 15mm screws to install the rear panel as show below. Step 8...
Page 11
Assemble side burner with (8) 1/4 x 15mm screws as figure show below. Step9 Connect the condiment tray and side shelf with two screws. The two screws have been fitted in side shelf.
Side burner valve assembly: Step 1: Insert valve assembly through side panel (Side panel, right #18B) Step 3: Insert valve stem assembly into burner venturi Valve Stem Valve Step 5: Replace “U” brackets with 4(four) Screws( DO NOT TIGHTEN) Step 7; Tight all 4(four) screws on the “U” brackets on the burner, then connect the ignition wire on to valve.
Page 13
:Assemble the condiment rack inside of the left door. Step 10 Step11: Screw in the tank retention screw as the picture shown below.
How to install a gas tank Opening the front door and place gas tank into the gas tank holes. Secure the gas tank by turning the retention screw at the back of the grill clockwise until it is tight. Complete.
PROPANE TANK ASSEMBLY ● With hand attach propane gas tank to regulator inlet fitting by turning the regulator clockwise until tight as shown in figure below. CAUTION! DO NOT USE TOOLS TO ATTACH REGULATOR / HOSE ASSEMBLY TO PREOPANE TANK...
INSTALLATION INSTRUCTION MODEL 720-0230 GAS HOSE RETENTION KIT Package should include (4 pcs): Regulator ring clamp with wing bolt 1 Hex Nut and washer Hose Clamp Installation 1a. Insert “threaded end” mounting bolt through top middle vent Mounting bolt with ring slot 1b.
This is a propane configured grill. Do not attempt to use a natural gas supply unless the grill has been reconfigured for natural gas use. Total gas consumption (per hour) of the 720-0230 (Charmglow) Grill with all burners on “HI”: Main burners 36,000 Btu/hr. Side burner 12,000 Btu/hr.
BEFORE TESTING Make sure that all packing material is removed from the grill including the burner tie-down straps. DO NOT SMOKE WHILE LEAK TESTING. NEVER PERFORM LEAK TEST WITH AN OPEN FLAME. Make a soap solution of one part liquid detergent and one part water.
4. Turn the control knob(s) to “HI” and preheat the 5. Place the food on the grill and cook to the desired NOTE: The CHARMGLOW grill is designed to grill efficiently without the use of lava rocks or briquettes of any kind.
Page 21
TO MANUALLY LIGHT THE GRILL If the burner will not light after several attempts then the burner can be match lit. If you’ve just attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. Keep your face and hands as far away from the grill as possible.
WARNING: IMPORTANT! USING THE SIDE BURNER: Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cuts, wear or abrasion, it must be replaced prior to use. Do not use the side burner if the odor of gas is present. WARNING: Always keep your face and body as far away from the burner as possible when lighting.
CARE & MAINTENANCE OF SIDE BURNER BURNER CLEANING: Clean the exterior of the burner with a wire brush. Clear any clogged burner ports with a straightened paper clip. Never enlarge the burner ports. Never use a wooden toothpick as it may break off the clog the port. STAINLESS STEEL: There are many different stainless steel cleaners available.
MODEL 720-0230 PARTS LIST PART (DESCRIPTION) Lid, Front Heat indicator Heat insulating spacer Handle assembly, post Handle assembly, lid Name plate Grease tray Bowl assembly Rear baffle Front baffle Gas valve, main burner Gas Valve manifold Control panel Zinc alloy control knob Bezel, main &...
The doneness of meat, whether rare, medium, or well done, is affected to a large degree by the thickness of the cut. Expert chefs say it is impossible to have a rare doneness with a thin cut of meat. The cooking time is affected by the kind of meat, the size and shape of the cut, the temperature of the meat when cooking begins, and the degree of doneness desired.
GRILL COOKING CHART WEIGHT OR FOOD THICKNESS VEGETABLES Fresh Beets Carrots Turnips Onion 1/2 inch slices Potatoes Sweet Whole White 6 to 8 ounces Frozen Asparagus Broccoli Brussels Sprouts Green beans Peas French fries MEATS Beef Hamburgers 1/2 to 3/4 inch Steaks Rib eye, APPROXIMATE...
Page 28
WEIGHT OR FOOD THICKNESS Tenderloin, Porterhouse, T-Bone, Sirloin Rare 1 inch 1-1/2 inch Medium 1 inch 1-1/2 inch Well-done 1 inch 1-1/2 inches Lamb Chops & Steaks Rare 1 inch 1-1/2 inch Medium 1 inch 1-1/2 inch Well-done 1 inch Pork Chops 1 inch...
Page 29
WEIGHT OR FOOD THICKNESS FISH AND SEAFOOD Steaks Halibut 3/4 to 1 inch Salmon Swordfish Whole Catfish 4 to 8 ounces Rainbow trout APPROXIMATE FLAME SIZE TIME Medium to 8 to 15 minutes High Medium to 12 to 20 minutes High SPECIAL INSTRUCTIONS AND TIPS...
GRILL RECIPE SUGGESTIONS BBQ SALMON 2 large salmon steaks 2 tbs. Oil Salt & pepper 2 oz. thin bacon slices 2 tbs. Butter 1 tbs. Lemon juice Spring of parsley Lemon wedges Preheat the BBQ. Brush the steaks with oil and season with salt and pepper.
Page 31
Refrigerate overnight or at least 6 to 8 hours. Wrap tortillas in foil. Remove meat from marinade. Cook on a pre-heated gas grill for 5 to 8 minutes on each side. While meat is cooking, heat tortillas on grill. Slice meat across grain in thin slices.
Page 32
accordion pleated. Fasten the second meat hook into the rack. Turn your rotis burner on high. Rotis for 50 minutes or until done. PORK ROAST Apple cider vinegar basting sauce: 1 c. apple cider vinegar 6 oz. water ½ stick butter Salt, pepper, parsley and garlic seasoning 2 oz.
STAINLESS STEEL OUTDOOR GAS GRILL Nexgrill Industries Inc. warrants to the original consumer purchaser of each Outdoor Gas Grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below. This warranty excludes grills used in rental or commercial applications.