Before Operation; Before Operation Safety; Checking The Engine-Oil Level; Checking The Cooling System - Toro Groundsmaster 4500-D Operator's Manual

Operation
Note:
Determine the left and right sides of the
machine from the normal operating position.

Before Operation

Before Operation Safety

General Safety
•
Never allow children or untrained people to
operate or service the machine. Local regulations
may restrict the age of the operator. The owner
is responsible for training all operators and
mechanics.
•
Become familiar with the safe operation of the
equipment, operator controls, and safety signs.
•
Shut off the engine, remove the key, and wait
for all movement to stop before you leave the
operator's position. Allow the machine to cool
before adjusting, servicing, cleaning, or storing it.
•
Know how to stop the machine and shut off the
engine quickly.
•
Check that operator-presence controls, safety
switches, and guards are attached and functioning
properly. Do not operate the machine unless they
are functioning properly.
•
Before mowing, always inspect the machine to
ensure that the blades, blade bolts, and cutting
assemblies are in good working condition.
Replace worn or damaged blades and bolts in sets
to preserve balance.
•
Inspect the area where you will use the machine
and remove all objects that the machine could
throw.
Fuel Safety
•
Use extreme care in handling fuel. It is flammable
and its vapors are explosive.
•
Extinguish all cigarettes, cigars, pipes, and other
sources of ignition.
•
Use only an approved fuel container.
•
Do not remove the fuel cap or fill the fuel tank
while the engine is running or hot.
•
Do not add or drain fuel in an enclosed space.
•
Do not store the machine or fuel container where
there is an open flame, spark, or pilot light, such
as on a water heater or other appliance.
•
If you spill fuel, do not attempt to start the engine;
avoid creating any source of ignition until the fuel
vapors have dissipated.
Checking the Engine-Oil
Level
Before you start the engine and use the machine,
check the oil level in the engine crankcase; refer to
Checking the Engine-Oil Level (page
Checking the Cooling
System
Before you start the engine and use the machine,
check the cooling system; refer to
Cooling System (page
Checking the Hydraulic
System
Before you start the engine and use the machine,
check the hydraulic system; refer to
Hydraulic-Fluid Level (page
Draining the Water
Separator
Drain water or other contaminants from the water
separator; refer to Draining Water from the Fuel/Water
Separator (page 52).
Checking the Rear Axle and
Gearbox for Leaks
Check the rear axle and rear-axle gearbox for leaks;
refer to Checking the Rear Axle and Gearbox for
Leaks (page 59).

Filling the Fuel Tank

Fuel Tank Capacity
Fuel tank capacity: 83 L (22 US gallons)
Fuel Specification
Important:
Use low sulphur diesel fuel.
Failure to observe the following cautions may
damage the engine.
•
Never use kerosene or gasoline instead of diesel
fuel.
•
Never mix kerosene or used engine oil with the
diesel fuel.
21
50).
Checking the
61).
Checking the
65).