Cassette Compartment Removal/Installation - Sony BETACAM SX DNW-A30 Maintenance Manual

2-5. Cassette Compartment Removal/Installation

2-5. Cassette Compartment Removal/
Installation
m
. Turn off the power and unplug the power cord before
starting the removal/installation.
. The cassette compartment cannot be removed with the
cassette tape inserted. Press the EJECT button with the
power turned on and eject the cassette tape.
If the cassette compartment does not move due to an
electric trouble, take out the cassette tape manually.
(Refer to "2-12. How to Take Out the Cassette when the
Tape is Slacking".)
Removal
1. Remove the upper lid.
(Refer to section 2-3-1. Upper Lid, Side Panels, and
Bottom Plate Removal/Installation.)
2. Remove the plate MD assembly.
(Refer to section 2-4. Plate MD Assembly Removal/
Installation)
3. Loosen two screws, then remove the cassette compart-
ment bracket assembly.
4. Disconnect the harness from the connector (CN930)
on CL-29 board, and set the harness so that it does not
put between chassis.
B3 x 6
(with stopper)
2-6
Cassette compartment
bracket assembly
B3 x 6
(with stopper)
Harness
CN930
5. Hold the cassette compartment at the portions A and
lift up the cassette compartment slightly (by 1 cm).
When the four cassette compartment positioning legs
come off from the four positioning holes on a mechan-
ical deck, shift the cassette compartment backward (by
1 cm) to the position where the cassette door can be
completely seen when viewed from just above.
6. Hold the cassette compartment at the portion B and
rais it slowly upward, then remove it.
m
. Raise it slowly while sliding the cassette compart-
ment slightly back-and-forth so that the gear on the
right side of the cassette compartment does not
touch the chassis.
. Never move the cassette compartment to right and
left. If unnecessary force is applied to right and left,
the gear or parts may come off.
. Place the cassette compartment with the cassette
door up or with cassette compartment positioning
legs down.
(If it is placed on the cassette lid down, the flexible
card wire might be damaged.)
Cassette compartment
A
B
A
DNW-A30/A30P
DNW-30/30P