Door Gasket; Fiber Board - England's Stove Works 50-SNC13 Installation & Operation Manual

The following steps should be followed for replacement of the door gasket:
Ensure the appliance is not in operation and is thoroughly cooled.
1.
Remove the old door gasket and clean the gasket channel.
2.
Using an approved high-temperature gasket cement, apply a thin coat in the bottom of the
3.
channel.
Starting at the hinge side of the door, work into the channel around the door unit, trim to length
4.
and butt the ends together.
Close the door and allow three to four hours for the cement to set before restarting any fire.
5.
THIS WOOD HEATER UTILIZES NEW TECHNOLOGY, WHICH INCLUDES A
CERAMIC FIBER BOARD THAT IS LOCATED IN THE FIREBOX,
AND RESTS ON TOP OF THREE (3) STAINLESS STEEL TUBES.
ALSO PLEASE NOTE: THE CERAMIC FIBER BOARD MAY BECOME LOOSE DURING INITIAL
SHIPPING. BE SURE IT IS LYING FLAT, ON TOP OF THE THREE STAINLESS STEEL TUBES,
AND PUSHED ALL THE WAY TO THE BACK OF THE UNIT, WITH NO GAPS BETWEEN IT AND
MAINTENACE: This unit is equipped with a ceramic Fiber Board ceiling baffle. After extensive use,
the board should be removed and cleaned.
The following steps should be followed for cleaning or replacement:
Ensure the appliance is not in operation and is completely cooled down.
1.
There is one screw in each stainless steel tube holder, located in the fire box ceiling. Remove
2.
the screws from the front and middle tube holders.
Shift the tube to the right, so that one end comes completely out of the socket. Drop the end
3.
down and pull it out by pulling it back to the left.
Drop the board down and push the left corner to the top left. Bring the right corner down to the
4.
bottom right of your door opening, and pull the right side out first.
Vacuum the board off and blow the carbon out of the tubes, if there is any build-up.
5.
Re-install the board and tubes, reversing the same method they were removed.
6.
FIBER BOARD: CARE & MAINTENANCE
DO NOT REMOVE THIS CERAMIC FIBER BOARD!!!
IT IS A NECESSARY COMPONENT OF THE FIREBOX.
THE BACK WALL.
Call (800) 245-6489 if questions.
19