Getting Other Information And Publications - Bard Q36A4DA Installation Instructions Manual

Table 14 10K OHM NTC Sensor: Temperature/
Resistance ............................................44
Table 15 Dehumidification Relay Logic Board .........49
FIGURES
Figure 1 Air Seal Under Q-TEC Unit ........................5
Figure 2 Removal of Q-TEC Unit from Skid ..............5
Figure 3 Fan Assembly Removal .............................6
Figure 4 Q-TEC Unit on Appliance Cart ...................6
Figure 5 Installation with Duct-Free Plenum ............7
Figure 6 Ducted Application ..................................7
Figure 7 Supply Duct Connections ..........................8
Figure 8 Filter Location .........................................8
Figure 9 Filter Tabs in Up Position ..........................9
Figure 10 Bend FIlter Tabs Down .............................9
Figure 11 Fresh Air Damper Assembly ......................9
Figure 12 Remove Compressor Shipping Brackets ....11
Figure 13A Unit Mounting - Method 1 ......................12
Figure 13B Unit Mounting - Method 2 ......................12
Figure 14 Remove Locking Screws from Wheels .......13
Figure 15 Optional Side Drain (Side View) ...............13
Figure 16 Standard Rear Drain ...............................13
Figure 17 Rear Drain (Top View) .............................14
Figure 18A ............................................................15
Figure 18B ............................................................15
Figure 18C ............................................................16
Figure 18D ............................................................17
Figure 19 Unit Dimensions ....................................19

GETTING OTHER INFORMATION AND PUBLICATIONS

These publications can help when installing the air
conditioner. They can usually be found at the local
library or purchased directly from the publisher. Be
sure to consult the current edition of each standard.
National Electrical Code ......................ANSI/NFPA 70
Standard for the Installation of Air Conditioning and
Ventilating Systems
.......................................................ANSI/NFPA 90A
Standard for Warm Air Heating and Air Conditioning
Systems
.......................................................ANSI/NFPA 90B
Load Calculation for Winter and Summer Air
Conditioning
....................................... ACCA Manual J Residential
Duct Design for Residential Winter and Summer Air
Conditioning and Equipment Selection
....................................................... ACCA Manual D
Figure 20 High Voltage Connections .......................20
Figure 21 Thermostat Connections .........................23
Figure 22 Thermostat Connections .........................24
Figure 23 Compressor Logic Control Board ..............27
Figure 24 CCM LED Fault Illumination .................... 28
Figure 25 Control Disassembly ...............................33
Figure 26 Winding Test ..........................................33
Figure 27 Drip Loop ..............................................33
Figure 28 Control Connector Motor Half ..................34
Figure 29 Fan Blade Setting ..................................35
FIgure 30 Fan Shroud Removal ..............................35
Figure 31 Electronic Expansion Valve (EEV) and
Service Tool ...........................................42
Figure 32 High Side Connection .............................42
Figure 33 Voltage to Pressure: Suction Pressure
Transducer ............................................43
GRAPHS
Graph 1 Q36A4D FAD Ventilation Delivery ........ 39
Graph 2 Q42A4D FAD Ventilation Delivery ........ 39
Graph 3 Q48A4D FAD Ventilation Delivery ........ 40
For more information, contact these publishers:
ACCA Air Conditioning Contractors of America
1712 New Hampshire Ave. N.W.
Washington, DC 20009
Telephone: (202) 483-9370
Fax: (202) 234-4721
ANSI American National Standards Institute
11 West Street, 13th Floor
New York, NY 10036
Telephone: (212) 642-4900
Fax: (212) 302-1286
ASHRAE American Society of Heating, Refrigeration
and Air Conditioning Engineers, Inc.
1791 Tullie Circle, N.E.
Atlanta, GA 30329-2305
Telephone: (404) 636-8400
Fax: (404) 321-5478
NFPA National Fire Protection Association
Batterymarch Park
P.O. Box 9101
Quincy, MA 02269-9901
Telephone: (800) 344-3555
Fax: (617) 984-7057
Manual 2100-752B
Page 3 of 49