Hoshizaki DCM-60KE-HC Instruction Manual page 15

[a] Exterior
Wipe the exterior at least once per week with a clean, soft cloth. Use a damp cloth containing a neutral cleaner to wipe off
grease or dirt.
[b] Front Panel, Spout, Push Lever, Ice Dispensing Outlet Cleaning/Sanitisation (Daily)
1) Remove the front cover by holding the notches on
both sides and pulling it toward you. See "II. 3. FRONT
COVER".
2) Loosen the band to disconnect the water pipe (A).
3) Hold the hooks on both sides of the spout, and pull it
toward you.
4) Either mix 1 litre of water with 4 ml of 5.25% sodium
hypochlorite solution in a suitable container, or the
recommended Hoshizaki sanitiser as directed.
5) Soak a clean cloth with the solution, and wipe the front
cover.
6) Soak the spout in the solution for more than 3 minutes.
Use the accessory brush to clean the water pipe (B).
Rinse thoroughly, and shake to remove surplus liquid.
Note: Using a cloth to dry may re-contaminate.
7) Soak a clean cloth with the solution, and wipe the parts
around the ice dispensing outlet and the push lever.
8) Replace the spout by holding the hooks on both sides
and inserting them into the holes.
9) Use the band to reconnect the water pipe (A) to the
spout.
10) Replace the front cover by holding both sides, inserting the hooks into the holes, and securely attaching it to the magnet
catch. See "II. 3. FRONT COVER".
11) The remaining solution can be used to sanitise utensils.
Note: Do not wipe dry or rinse after sanitising, but allow to air dry.
[c] Grille, Drain Pan Cleaning/Sanitisation (Daily)
1) Either mix 1 litre of water with 4 ml of 5.25% sodium
hypochlorite solution in a suitable container, or the
recommended Hoshizaki sanitiser as directed.
2) Lift the grille off the drain pan.
3) Soak the grille in the solution for more than 3 minutes.
Rinse thoroughly, and shake to remove surplus liquid.
Note: Using a cloth to dry may re-contaminate.
4) Use the accessory brush to clean the three drain holes in the drain pan.
5) Place the grille in its correct position and direction.
Water Pipe (A)
Band
Front Cover
Water Pipe (B)
Brush
Spout
Hole (both
sides)
Spout
1
Hook
(both sides)
Lift
off
Grille
Drain Pan Top
11
ENGLISH
Spout
Hook
(both sides)
Ice Dispensing
Push Lever
Outlet
Water Pipe (A)
Band
DCM-60/120KE-HC DCM-60/120KE-P-HC
Grille must be lower Grille must be level
than the top of drain with the top of drain
pan. pan.
2