Table Of Contents - USSC Wondercoal 2927 Owner's Manual

LOCATING THE HEATER
AS A LOCATION IS SELECTED,
KEEP THE FOLLOWING IN MIND:
1. The chimney connection should be as
possible. The heater must have its own chim-
ney. Do not connect this unit to a chimney flue,
serving another appliance. If there is no chim-
ney near where you wish to place the heater,
you can use a UL 103HT Residential Type and
Building Heating Appliance Chimney (Fig. 5
&6).
2. Place the heater on solid masonry or solid
concrete. When the heater is used on a com-
bustible floor protector of one layer of 3/8"
millboard having a thermal conductivity of
K=0.84 BTU in./ft. 2 hr. Deg. F with 28-gauge
sheet metal or a UL Listed floor protector. Have
the floor protector extend 16" beyond the door
side of the heater and under the connector pipe
in the back.
3. Check Figures 2, 3, and 4. Be sure you have
the clearances shown from the heater and the
connector pipe to combustible surfaces. If you
have a solid brick or stone wall behind your
heater, you can place the heater as close as
you wish to the wall. If the wall is only faced with
brick or stone, treat it as a combustible wall.
8"
Fig. 2
52 1/4"
Fig. 4
32 1/4"
8"
FLOOR PROTECTOR
SIDEWALL
(TOP VIEW)
NOTE: BEFORE FIRING
HEATER
Slide firebricks toward the rear
so no gaps remain between
them.
CAUTION:
Keep furnishings and other
combustible materials away
from the heater.
26"
Fig. 3
20"
16"
NON-COMBUSTIBLE
CONSTRUCTION IN
20"
ACCORDANCE WITH
NFPA 211
44"
19 1/4"
NOTE: DASHED LINES SHOW
STRAIGHT UP AND THROUGH
THE WALL INSTALLATION
4 3/4"
16"
4
REPAIR PARTS LIST - MODEL 2927 (SEE PAGE 18)
AUTOMATIC COAL BURNING CIRCULATOR
Key No. Description
1 Shaker
2 Ash Pan
3 Base
4 Draft Damper Hinge Pin
5 Draft Damper Frame
6 Draft Control Plate
7 Clip
8 Glass Brass Trim (LH/RH)
9 Glass Brass Trim (TOP/BOTTOM)
10 Glass Frame
11 Glass Gasket
12 Glass (20 1/2"x12 1/2")
13 Front Half Brick
14 Front Coal Grate
15 Flue Collar
16 Fire Box Weldment
17 Firebrick Retainer
18 Firebrick
19 Door Hinge Pin
20 Feed Door
21 Feed Door Rope Gasket
22 Machine Screw (1/4-20x1)
23 Draft Wheel
24 Door Handle
25 Flat Washer
26 Hex Nut (1/4-20)
27 Latch
28 Ash Door Rope Gasket
29 Ash Door
30 Hex Nut (1/4-20)
31 Front Liner
32 Coal Grate Frame
33 Coal Grate
34 Rear Half Brick
35 Back Brick Retainer
36 Flue Baffle
37 Flue Collar Gasket
38 Air Wash Deflector
* Grate Support
* Corner Key (Brass Trim)
* Blank Key (Brass Trim)
39 Wood Handle (Optional)
40 Door Hinge Pin
41 Two Step Latch
42 Latch Spacer
43 Smoke Curtain
* Smoke Curtain Bracket
* NOT SHOWN
Qty. Part No.
1 40045
1 68574
1 67859
1 17200
1 40075
1 68583
2 83818
2 89382
2 89381
1 68452
66" 88047
1 89409
1 23782
1 40283
1 40287
1 68655
1 40132
7 89066
1 83114
1 68605
44" 88033
1 53227
1 40056
2 40091
1 83045
2 83250
1 22108
29" 88033
1 67781
1 83250
1 40100
1 40102
1 40101
1 23785
1 23145
1 23249
1 88032
1 23547
2 22536
10 89419
10 89420
2 89523
1 23441
1 22434
1 21467
1 22090
2 22171
17