Table Of Contents - Quadra-Fire TREKKERI-MBK TREKKERI-CSB TREKKERI-PMH Installation Manual

TREKKER INSERT
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Indicates practices which may cause damage to the appliance or to property.
Important Safety Information ............. 3
1
A. Appliance Certification. . . . . . . . . . . . . . . . . . . . . . . .3
B. BTU & Efficiency Specification . . . . . . . . . . . . . . . . .3
C. Glass Specifications . . . . . . . . . . . . . . . . . . . . . . . . .4
D. Electrical Rating . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
E. Mobile Home Approved . . . . . . . . . . . . . . . . . . . . . . .4
F. Non-Combustible Materials . . . . . . . . . . . . . . . . . . . .4
G. Combustible Materials . . . . . . . . . . . . . . . . . . . . . . .4
H. Sleeping Room . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
I. California - Prop65 . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Getting Started .................................... 5
2
A. Design, Installation & Location Considerations . . . . .5
B. Tools And Supplies Needed . . . . . . . . . . . . . . . . . . .6
C. Inspect Appliance and Components . . . . . . . . . . . . .6
D. Install Checklist . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Dimensions and Clearances .............. 8
3
A. Appliance Dimensions . . . . . . . . . . . . . . . . . . . . . . . .8
B. Clearance to Combustibles, US & CAN . . . . . . . . . .9
C. Minimum Opening for Masonry & ZC Fireplaces . .10
D. Hearth Extension. . . . . . . . . . . . . . . . . . . . . . . . . . .10
E. Floor Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
F. Installation into a Factory-Built Fireplace . . . . . . . . . 11
G. Installation into a Masonry Fireplace . . . . . . . . . . .12
H. Prefabricated Metal Chimney . . . . . . . . . . . . . . . . .12
Vent Information ................................ 13
4
A. Venting Termination Minimum Requirements . . . . .13
B. Avoiding Smoke and Odors . . . . . . . . . . . . . . . . . . .14
C. Negative Pressure. . . . . . . . . . . . . . . . . . . . . . . . . .15
D. Draft . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15
E. Chimney and Exhaust Connection . . . . . . . . . . . . .15
F. Equivalent Feet of Pipe . . . . . . . . . . . . . . . . . . . . . .16
G. Pipe Selection Chart . . . . . . . . . . . . . . . . . . . . . . .16
2

TABLE OF CONTENTS

Quadra-Fire is a registered trademark of Hearth & Home Technologies.
Safety Alert Key:
Venting Systems ............................... 17
5
A. Full Reline wit Outside Air - Horizontal . . . . . . . . . .17
B. Full Reline with Outside Air - Vertical . . . . . . . . . . .18
Appliance Set-Up .............................. 19
6
A. Leveling System . . . . . . . . . . . . . . . . . . . . . . . . . . .19
B. Outside Air Kit Instructions . . . . . . . . . . . . . . . . . . .19
C. Hearth Support . . . . . . . . . . . . . . . . . . . . . . . . . . . .19
D. Removal of Cast Sides . . . . . . . . . . . . . . . . . . . . . .20
E. Surround & Cast Trim Set . . . . . . . . . . . . . . . . . . . .20
F. Surround & Basic Trim Set. . . . . . . . . . . . . . . . . . . .21
G. Optional Log Set Instructions . . . . . . . . . . . . . . . . .21
H. Installation of Bluetooth Key . . . . . . . . . . . . . . . . . .22
I. Power to Appliance and User Interface . . . . . . . . . .22
J. Location & Mounting of User Interface. . . . . . . . . . .22
Mobile Home Installation .................. 23
7
Reference Materials .......................... 24
8
A. Service & Maintenance Log . . . . . . . . . . . . . . . . . .24
B. Accessory List . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27
7082-153D September 27, 2018