Transporting - Exmark NAVIGATOR Operator's Manual

Operation
7. Install springs onto the spring anchor pins under
the left and right consoles and secure with a
washer and hairpin (see Figure 12).
8. Un-latch deck from raised position, slowly lower
deck to ground and lock deck locking pins on
each side Lowering the Deck to the Operation
Position section in Operation.
Emptying Hopper
1. A full hopper is indicated by a buzzer located
behind the operator in the hopper. Empty hopper
when buzzer sounds to prevent clogging of the
blower or deck.
2. Disengage PTO, move speed control to neutral,
set park brake and dismount unit to dump hopper.
3. Make sure unit is on a dry level surface.
4. Lift the rear door up and allow it to rest on top
of hopper.
5. Turn the key to the "ON" position and press the
hopper switch to raise the hopper to dump the
contents; press the switch to lower the hopper.
6. Turn the key "OFF" and lower the rear door.
Clearing Hopper Screen
Screen may be removed by firmly lifting screen
handles (see Figure 16).
Pull screen towards the back to remove. Gently tap
debris from the screen as needed.
Excessive build-up on the screen can cause the
blower to plug.
Note: In conditions where the screen clogs quickly,
the front removable screen panel can be turned and
reinstalled under the primary screen to allow free air
flow from the hopper.
1. Front removable screen
can be rotated and
stored for wet conditions
2. Front removable screen

Transporting

Transporting a Unit
Use a heavy-duty trailer or truck to transport the
machine. Lock brake and block wheels. Securely
fasten the machine to the trailer or truck with straps,
chains, cable, or ropes. If possible, both front and
rear straps should be directed down and outward
from the machine. Be sure that the trailer or truck
has all necessary lighting and marking as required by
law. Secure a trailer with a safety chain.
CAUTION
This unit does not have proper turn signals,
lights, reflective markings, or a slow moving
vehicle emblem. Driving on a street or roadway
without such equipment is dangerous and
can lead to accidents causing personal injury.
Driving on a street or roadway without such
equipment may also be a violation of State laws
and the operator may be subject to traffic tickets
and/or fines.
Do Not drive a unit on a public street or roadway.
28
Figure 16
3. Primary screen
4. Handles.