Table Of Contents - Emerson Rosemount 2051 Quick Start Manual

Quick Start Guide
NOTICE
This installation guide provides basic guidelines for Rosemount 2051 transmitters. It does not
provide instructions for configuration, diagnostics, maintenance, service, troubleshooting,
Explosion-Proof, Flame-Proof, or intrinsically safe (I.S.) installations. Refer to the 2051 reference
manual (document number 00809-0200-4101) for more instruction. This manual is also
available electronically on www.emersonprocess.com/rosemount.
Explosions could result in death or serious injury.
Installation of this transmitter in an explosive environment must be in accordance with the
appropriate local, national, and international standards, codes, and practices. Please review the
approvals section of the 2051 reference manual for any restrictions associated with a safe
installation.
In an Explosion-proof/Flameproof installation, do not remove the transmitter covers when

power is applied to the unit.
Process leaks may cause harm or result in death.
To avoid process leaks, only use the o-ring designed to seal with the corresponding flange

adapter.
Electrical shock can result in death or serious injury.
Avoid contact with the leads and the terminals. High voltage that may be present on leads can

cause electrical shock.
Conduit/cable entries
Unless marked, the conduit/cable entries in the transmitter housing use a

form. Only use plugs, adapters, glands, or conduit with a compatible thread form when
closing these entries.
Contents
System readiness . . . . . . . . . . . . . . . page 3
Confirm correct device driver . . . . page 3
Transmitter installation . . . . . . . . . page 4
Tagging . . . . . . . . . . . . . . . . . . . . . . . page 8
Housing rotation . . . . . . . . . . . . . . . page 9
2
Set the switches . . . . . . . . . . . . . . . page 10
Wire, ground, and power up . . . . . page 11
Configure . . . . . . . . . . . . . . . . . . . . . page 13
Zero trim the transmitter . . . . . . . page 19
Product Certifications . . . . . . . . . . page 20
October 2014
1
/ -14 NPT thread
2