Sony PMW-EX1 Service Manual
  1. Manuals
  2. Brands
  3. Sony Manuals
  4. Camcorder
  5. EXMOR PMW-EX1
  6. Service manual

Sony PMW-EX1 Service Manual

Solid-state memory camcorder
Hide thumbs Also See for PMW-EX1:
Table of Contents

Advertisement

Quick Links

SOLID-STATE MEMORY CAMCORDER
PMW-EX1
WIDE CONVERSION LENS
VCL-EX0877
SERVICE MANUAL
1st Edition (Revised 1)

Advertisement

Table of Contents
loading

Related Manuals for Sony PMW-EX1

Summary of Contents for Sony PMW-EX1

  • Page 1 SOLID-STATE MEMORY CAMCORDER PMW-EX1 WIDE CONVERSION LENS VCL-EX0877 SERVICE MANUAL 1st Edition (Revised 1)
  • Page 2 Ce manual est destiné uniquement aux personnes compétentes en charge de l’entretien. Afin de réduire les risques de décharge électrique, d’incendie ou de blessure n’effectuer que les réparations indiquées dans le mode d’emploi à moins d’être qualifié pour en effectuer d’autres. Pour toute réparation faire appel à une personne compétente uniquement. PMW-EX1...
  • Page 3 Hävitä käytetty paristo valmistajan ohjeiden Remplacer uniquement avec une batterie du même mukaisesti. type ou d’un type équivalent recommandé par le constructeur. Mettre au rebut les batteries usagées conformément aux instructions du fabricant. 1 (P) PMW-EX1...

  • Page 5: Table Of Contents

    BP-43 Board ............2-6 5-3. Electrical Parts List ............5-17 2-2-7. Inside Panel Assembly/Outside Panel 5-4. Supplied Accessories ............ 5-55 Assembly ............... 2-6 2-2-8. Rear Panel Assembly ..........2-7 2-2-9. Express Card Assembly ........2-8 6. Semiconductor Pin Assignments PMW-EX1...
  • Page 6 HN-319 (2/2) ..............7-11 RM-213 ................. 8-59 LED-465 ............... 7-11 SW-1375 ............... 8-59 SW-1375 (2/2) .............. 7-11 SW-1397 ............... 8-59 SW-1397 ............... 7-11 SWC-47 ................ 8-60 SWC-47 ................ 7-11 TX-115 ................8-62 TX-115 ................7-12 Frame Wiring ..............8-69 PMW-EX1...
  • Page 7 HN-339 ................9-8 JK-77 ................9-8 KSW-53 ................9-8 LE-346 ................9-9 LED-465 ................. 9-9 MA-161 ................9-9 RM-213 ................9-9 SW-1375 ................. 9-9 SW-1397 ................. 9-9 RE-250 ................9-10 RE-251 ................9-10 SWC-47 ................ 9-11 TX-115 ................9-11 PMW-EX1...

  • Page 8: Manual Structure

    Related manuals The following manuals are available in this model. If this manual is required, please contact your local Sony Sales Office/Service Center..Operating Instructions (Supplied with the unit) This manual is necessary for application and operation (and installation) of this unit.

  • Page 9: Service Overview

    _ _ _ _ _ EXT VIEW _ _ _ _ _ No. Signal Specifications LINE_MONI1_L (A/V) LINE OUT (L) LANC_SIG S_GND LANC_DC S OUT (C) LINE_MONI2_R (A/V) LINE OUT (R) AV_SW VIDEO/AUDIO_GND VIDEO Composite OUT S OUT (Y) PMW-EX1...
  • Page 10 BAT_SCL TPA+ Data on receive, strobe on transmit A (+) BAT_SDA BATT_ID_DATA (USB) : Mini-B connector (5P) BATT (_) _ _ _ _ _ EXT VIEW _ _ _ _ _ No. Signal Specifications USB Vcc USB_ USB+ Ground PMW-EX1...

  • Page 11: Location Of The Printed Wiring Boards

    @. SW-1375 board 6 BI-204 board !] EC-62 board @= KSW-53 board #/ SW-1397 board 7 BP-43 board !\ HN-318 board @[ LE-346 board #- SWC-47 board 8 CN-3006 board !; HN-319 board @] LED-465 board #= TX-115 board PMW-EX1...

  • Page 12: Circuit Description

    . EVF signal (analog): To DR-621 board camera signal processor IC (IC100), average value, peak The input/output signals of the baseband processing IC value of the RGB digital video signals that are required for (IC400) are the following signals: PMW-EX1...
  • Page 13 161 board is input to the balanced input amplifier IC101 Express signals. and IC201 of this board. Output of the balanced amplifi- IC1302 is controlled by PCI bus from IC900. er is connected to the analog switch (IC105, IC205) for switching between [INT/EXT]. PMW-EX1...
  • Page 14 (PHONE MINI) MUTE CN11 AUX IN( R) SPEAKER MONITOR LEVEL Q100 to Q102 LED-465 PWR or IC800 MUTE IC803 IC104, IC105 I2C MPX Display (DEVICE CONTROL) Block MONI1-1,2-1, (T-one) MONI2-2,2-1, GPIO BEEP, MUTE ASW-65 Fig. 1. Audio block diagram PMW-EX1...
  • Page 15 IC314 of the camera block system, IC400 of the This is the connector board. The audio output from the video signal system, and IC900 of the media recording/ ASW-65 board is connected to A/V multi-connector. playback system. PMW-EX1...
  • Page 16 IC1001 on the RE-251 board checks that the power switch The PLL circuit is used to reduce jitter of the HD-SDI on the PMW-EX1 is turned ON, and turns on the system clock signal. controller of IC1600. After that, it controls the power for The FPGA (IC100) is controlled by IC400 on the DPR-289 each circuit block according to the system controller.
  • Page 17 This helps provide detailed information about detection, automatic recovery is not performed and the the battery, including whether the battery is damaged or power must be turned on again. how long the life is, in order to provide optimal operations. PMW-EX1...

  • Page 18: Service Tools/Measuring Equipment List

    Mini USB cable For firmware version-upgrade 3-292-755-01 XLR JIGU For removing the mounted circuit board * : This cable is supplied with PMW-EX1. 1-4-2. Measuring Equipment Use the calibrated equipment or equivalent as listed below for the adjustments. Equipment Model name...

  • Page 19: Firmware Upgrade

    7. Attach the cover on the USB maintenance connector. When the PMW-EX1 is connected to the computer for the first time, the driver software will need to be installed into the computer. For more details, check the readme file that comes with the upgrade software.

  • Page 20: Recommended Replacement Parts

    1-6. Recommended Replacement Parts This section describes the recommended replacement parts and recommended replacement time. Part name Sony part No. Recommended replacement timing Eye cup 3-278-319-01 Check for deformation and deterioration from time to time. Replace it as necessary. Lens hood...

  • Page 21: Note On Service

    . The ordinary soldering iron can be used but the iron tip has to be applied to the solder joint for a slightly longer time. The printed pattern (copper foil) may peel away if the heated tip is applied for too long, so be careful. 1-13 PMW-EX1...

  • Page 22: Connector Location Diagram On Board

    When connecting the flexible card wire, check the connec- tor shape, and great care should be taken for the direction of the contact surface or isolation surface (blue). Connector : 1 Connector : 2 Isolation surface TX-115 board (A side ) (blue) CN100 Isolation surface (blue) 1-14 PMW-EX1...

  • Page 23: Replacing The Coaxial Cable With Connector (Fine Pitch Coaxial Cable)

    Be sure to hold the connector to remove. Polarity marks Hold the connector to remove. Do not attempt to remove by pulling the cables. Contact surface Hold the connector to connect. Not to bend the cable. 1-15 PMW-EX1...

  • Page 24: List Of Error Numbers On The Lcd Display

    Abnormality in obtaining the lens switch Check the connection with the lens unit. If there is no condition defect, replace the lens unit. 17017 Internal error in the media block Repair the DPR-298 board or replace it. 4XXXX 1-16 PMW-EX1...

  • Page 25: Replacement Of Main Parts

    Outside panel Rear panel assembly assembly EVF assembly Handle assembly Inside panel assembly RE-251 board TX-115 board RE-250 board Express card Prism assembly assembly DPR-289 board Cover (center) assembly ND filter Battery case Case L assembly Case R assembly PMW-EX1...

  • Page 26: Replacement Procedures

    : P2 lock ace 2 x 3 the bracket (tripod). 3. Remove the six screws of b and one screw Case (bottom ) L of c, and remove case (bottom) L and case (bottom) R. Bracket (tripod) Case (bottom ) R PMW-EX1...

  • Page 27: Microphone Holder Assembly

    2-2-3. Microphone Holder Assembly 1. Open the microphone holder assembly. B2.6 x 6 2. Remove the two screws, and remove the microphone holder assembly. Microphone holder assembly 3. Reinstall the microphone holder assembly by reversing the steps of removal. PMW-EX1...

  • Page 28: Evf Assembly

    Be very careful not to fold them. 6. Remove the four screws of b, and remove the EVF assembly. Handle cover rear assembly DR-621 board Two claws 7. Reinstall the EVF assembly by reversing the steps of removal. PMW-EX1...

  • Page 29: Handle Assembly

    Be sure to hold Flexible card the connector to remove. wire (30 core) Coaxial cable with connector (DPR-LCD) Connector (DPR-289 board) 9. Reinstall the handle assembly by reversing the steps of removal. PMW-EX1...

  • Page 30: Board

    When removing the outside panel assembly, Inside panel be careful not to drop the battery release assembly button. Outside panel assembly 4. Reinstall the inside panel assembly/outside panel assembly by reversing the steps of removal. PMW-EX1...

  • Page 31: Rear Panel Assembly

    7. Reinstall the rear panel assembly by revers- ing the steps of removal. RE-251 board RE-250 board After connecting the harness that has been removed in Step 6, tuck the wires between The wires must be the RE-250 and RE-251 boards. completely tucked in Wires PMW-EX1...

  • Page 32: Express Card Assembly

    Be careful not to drop the radiation sheet. If Express card assembly the radiation sheet is dropped, install the express card assembly, and then attach the radiation sheet at the position shown in the figure. : P2 lock ace 2 x 3 PMW-EX1...
  • Page 33 For slot A For slot B figure 1. Be sure that the cable for slot A comes under the cable for slot B. (Fig1) . When reinstalling the express card assem- bly, be careful not to drop the radiation sheet. PMW-EX1...

  • Page 34: Board/ Re-251 Board

    (CN200) on the RE-250 board. 11. Reinstall the RE-250 board/ RE-251 board by reversing the steps of removal. After connecting the harness that has been removed in Step 9, tuck the wires between the RE-250 and RE-251 boards. 2-10 PMW-EX1...

  • Page 35: Battery Case, Tx-115 Board

    : P2 lock ace 2 x 2 6. Remove the two screws of c. 7. Remove the three screws of d and remove the bracket. Bracket : P2 lock ace 2 x 3 : P2 lock ace 2 x 3 2-11 PMW-EX1...
  • Page 36 15. Reinstall the battery case and the TX-115 board by reversing the steps of removal. When reinstalling the HD-SDI assembly, be : P2 lock ace 2 x 3 careful not to drop the radiation sheet. : P2 lock ace 2 x 3 2-12 PMW-EX1...

  • Page 37: Board

    Flexible boards 2 x 4 : P2 lock ace connectors on the DPR-289 board. 10. Reinstall the DPR-289 board by reversing the steps of removal. When replacing CN-3007 (flexible board), attach the cushion CN3007 (Sony part No.: 3- 286-759-01). 2-13 PMW-EX1...

  • Page 38: Case L Assembly

    . Be careful with the position of the flexible board from the prism block when installing the case L assembly. . When reinstalling the main frame that has been removed in Step 3, reinstall the screw of b first. ND filter knob 2-14 PMW-EX1...

  • Page 39: Case R Assembly

    BI board (1) Prism assembly 3. Reinstall the prism assembly by reversing the steps of removal. When replacing the prism assembly, attach the BI board cushions (1) (Sony part No.: 3- 291-890-01) to the three positions of the BI board. 2-15 PMW-EX1...

  • Page 40: Nd Filter

    . Check if the installation position of the ND filter aligns with the position of the two reference pins. . When reinstalling the ND filter, loosely fix the three screws, and then fully tighten Reference pin them while paying attention not to deform the ND filter. 2-16 PMW-EX1...

  • Page 41: Board, Jk-77 Board

    2-2-18. LENS UNIT P2.6 x 5 1. Refer to Sections from 2-2-1 to 2-2-16 and disassemble the unit up to “ND filter” removal. Front sub assembly 2. Remove the five screws, and remove the front sub assembly. Lens unit 2-17 PMW-EX1...

  • Page 42: Board

    2. Disconnect the harnesses from the connector (CN3) on the DP-621 board. 3. Remove the two screws, and remove the DR- 621 board. DR-621 board 4. Reinstall the DR-621 board by reversing the steps of removal. 2-18 PMW-EX1...

  • Page 43: Board

    4. Remove the speaker holder sheet, and remove the speaker harness from the slit of the Speaker speaker holder. 5. Remove the speaker from the speaker holder. Speaker holder sheet 6. Reinstall the speaker by reversing the steps of Speaker harness removal. 2-19 PMW-EX1...

  • Page 44: Board, Hn-320 Board

    5610) from the connector (CN4) on the KSW-53 board. Control switch block 6. Disconnect the HN-320 board from the (ZS-5610) connector (CN1) on the KSW-53 board. KSW-53 board HN-320 board 7. Reinstall the KSW-53 board and HN-320 board by reversing the steps of removal. 2-20 PMW-EX1...

  • Page 45: Microphone Unit Assembly

    7. Remove the microphone unit assembly in the direction of arrow “D”. Be careful not to hook or damage the har- nesses. Harness (KSW53-MA161) Harness (KSW53-RM213) Microphone unit assembly 8. Reinstall the microphone unit assembly by reversing the steps of removal. 2-21 PMW-EX1...

  • Page 46: Microphone Unit

    9. Remove the screw of d, and remove the RM-213 board. Harness MA-161 board (KSW53-RM213) : P2 tapping 2 x 5 : P2 tapping 2 x 5 10. Reinstall the microphone unit by reversing the steps of removal. 2-22 PMW-EX1...

  • Page 47: Board

    DET-44 board and the DET44 fit plate. 6. Remove the two screws of c, and remove the DET-44 board from the DET44 fit plate. DET-44 board DET44 fit plate 7. Reinstall the DET-44 board by reversing the steps of removal. 2-23 PMW-EX1...

  • Page 48: Inch Lcd Assembly

    When disconnecting the coaxial cable with connector, do not attempt to remove by pulling the cable. Be sure to hold the connector to remove. LCD bezel 6. Reinstall the 3.5-inch LCD assembly by reversing the steps of removal. 2-24 PMW-EX1...

  • Page 49: Replacing The Parts In The Lens Grip

    T/W zoom switch, assemble it by Protrusion rotating it in the direction opposite to the (START/STOP) Notch arrow. (Fig. 2) 3. Install the three screws a, and the screw b. Fig.5 (Fig. 1) Grip cover Buckle Grip belt Fig.6 2-25 PMW-EX1...

  • Page 51: Service Menu

    Correction Mode Concealment Selects the RPN correction mode that is used to Compensation register or delete the manual registration. Channel Selects and displays the channel (R-ch or G-ch or B-ch) to execute manual registration or detection of RPN correction on. PMW-EX1...
  • Page 52 Executes self-diagnostic Item 8. Cancel Item9 Execute Executes self-diagnostic Item 9. Cancel Item10 Execute Executes self-diagnostic Item 10. Cancel Item11 Execute Executes self-diagnostic Item 11. Cancel Item12 Execute Executes self-diagnostic Item 12. Cancel Item13 Execute Executes self-diagnostic Item 13. Cancel PMW-EX1...

  • Page 53: Service Menu Description

    Exiting the Menu Mode device and setting parameters that must be set uniquely to Press the MENU button again. each PMW-EX1 for correction of non-uniformity between The system exits the menu mode to return to the normal the respective lens characteristics.
  • Page 54 . The Auto BLK Shad menu enables the auto black shading correction (automatic optimization of the respective correction values of the black shading correc- tion). . When Auto BLK Shad menu is selected, the Execute and Cancel choices appear. Selecting Execute starts Auto Black Shading. PMW-EX1...
  • Page 55 . The V Saw menu enables the vertical Saw black shading correction (linear increase and decrease) level. . The V Para menu enables the vertical Parabola white shading correction (sensitivity correction at the vertical center with respect to both ends) level. PMW-EX1...
  • Page 56 (such as high illumination or reflective object) inside the picture frame. . Set the lens iris to OPEN. . If the video signal level is too high, use an electronic shutter to a moderate video signal level. . Execute Auto FB Adjust. PMW-EX1...

  • Page 57: Rpn Correct Menu

    Cursor V Position, . When the Cursor menu is turned On, the crosshair cursor the RPN cursor moves in the descending order of the indicating the RPN correction position is displayed Cursor H Position.) superimposed on the video signal. PMW-EX1...

  • Page 58: Information Menu

    . The RPN data that is registered at the factory and the RPN data is manually registered cannot be deleted by the Reset. . When the Reset menu is selected, the Execute and Cancel choices appear. In addition, selecting Execute starts reset of RPN. PMW-EX1...
  • Page 59 IC to AVIT signal processing IC Item13 4bit I/F while playing back between Diagnosis of the 4bit Bus signal line (playback direction) from display and media block AVIT signal processing IC to base band processing IC PMW-EX1...
  • Page 60 Shows the number of trials of the self-diagnosis. Success Shows the number of internal successes of the self-diagnosis. Result Shows the result of the self-diagnosis. “0” means no problems. When a value other than “0” is displayed, check the details for each self-diagnostic item. 3-10 PMW-EX1...
  • Page 61 When an error is detected in the item, it indicates a possible error in the hardware. Item2: Display block diagnosis Display block diagnosis does not function. 3-11 PMW-EX1...
  • Page 62 Audio block diagnosis analyzes the following contents. Diagnosis description Error value Type 1/2 Note 0x02 Memory area check for -1: Memory read/write 1, 2 audio block comparison NG When an error is detected in the item, it indicates a possible error in the hardware. 3-12 PMW-EX1...
  • Page 63 When an error is detected in the IIC communication test, it indicates a possible failure in the communication line or device. *: When an error is detected in the version matching test, upgrade again to a compatible version. Contact your local Sony Sales Office/Service Center for information on versions. Item6: Power block diagnosis Power block diagnosis analyzes the following contents.
  • Page 64 (in the -2: Sequence error direction from AVIT signal processing IC to base band processing) When an error is detected, it indicates a possible failure in the chip or the signal line between chips. 3-14 PMW-EX1...

  • Page 65: Alignment

    Section 4 Alignment 4-1. Servicing software “ServiceNavi-EX” Servicing software “ServiceNavi-EX” is required for electrical adjustment and self diagnosis. For how to obtain the “ServiceNavi-EX”, contact your local Sony Sales Office/Service Center. PMW-EX1...

  • Page 67: Spare Parts

    Therefore, specified parts should be used in the case of replacement. 2. Standardization of Parts Some repair parts supplied by Sony differ from those used for the unit. These are because of parts common- ality and improvement. 3. Stock of Parts Parts marked with “o”...

  • Page 68: Exploded Views

    Handle Cover (Upper) Assembly and EVF 5-2. Exploded Views PMW-EX1...
  • Page 69 3-278-319-01 s EYE CUP 3-278-644-01 s XDCAM EMBLEM 3-278-648-01 s RUBBER SW KEY 3-285-383-01 s COVER CONNECTOR 3-286-664-01 s HOOD, LENS 3-657-657-02 s SCREW (M5) 4-673-655-01 s SCREW +B 8-753-210-99 s LCX068AK-1 3-056-233-21 s SCREW (M2), LOCK ACE, P2 PMW-EX1...
  • Page 70 Handle Block 1 PTT2.6 x 6 PTT2.6 x 6 PMW-EX1...
  • Page 71 7-627-556-57 s PRECISION SCREW +P 2.6X5 TYPE1 3-968-729-52 s SCREW (M2), LOCK ACE, P2 3-282-659-01 s SHEET,HANDLE REAR 3-278-666-02 s RAIL, XLR SW 7-627-556-38 s SCREW +P 2.6X4.0 3-452-727-01 s SHEET, SPEAKER HOLDER 7-685-792-09 s SCREW +PTT 2.6X6 (S) PMW-EX1...
  • Page 72 Handle Block 2 PMW-EX1...
  • Page 73 3-278-657-01 s CASE, MICROPHONE 3-278-658-01 s HINGE COVER LOWER 3-278-660-01 s MIC CUSION(R) 3-278-661-01 s MIC CUSION(L) 3-278-662-01 s HANDLE (MAIN) 3-278-668-01 s HINGE 3-284-538-01 s SHIELD SHEET(MIC) 3-968-729-52 s SCREW (M2), LOCK ACE, P2 3-278-640-01 s SHEET PANEL BLIND PMW-EX1...
  • Page 74 Rear, Inside, Outside Panel Block PMW-EX1...
  • Page 75 3-278-651-01 s LID, LITHIUM BATTERY 3-285-186-01 s SW SPACER 3-701-439-01 s WASHER 3-285-384-01 s CUP BNC 3-729-013-61 s SCREW(M1.4X4.5),WASHERHEAD(+P) 3-968-729-52 s SCREW (M2), LOCK ACE, P2 4-644-493-11 s ACE (M2.6), LOCK 3-080-203-51 s SREW(M2),LOCK ACE,P2 4-644-492-21 s ACE (M2), LOCK PMW-EX1...
  • Page 76 Main Frame 1 5-10 PMW-EX1...
  • Page 77 A-1376-746-A s BATTERY CASE ASSY 1-780-570-11 s TERMINAL BOARD, BATTERY 1-965-708-11 s HARNESS (DPR-EC) 1-965-720-11 s HARNESS, SUB (AU313-BP43) 3-080-203-31 s SREW(M2),LOCK ACE,P2 3-086-368-31 s SCREW (M1.4),LOCK ACE P2 3-278-741-02 s EC-62 LED LENS 3-968-729-52 s SCREW (M2), LOCK ACE, P2 5-11 PMW-EX1...
  • Page 78 Main Frame 2 5-12 PMW-EX1...
  • Page 79 1-965-710-11 s HARNESS (DPR-TX) 1-965-719-11 s HARNESS, SUB (DPR289-TX115) 3-278-726-01 s MAIN FRAME REAR 3-278-727-01 s BNC COVER 3-286-759-01 s CUSHION CN3007 3-968-729-52 s SCREW (M2), LOCK ACE, P2 3-056-233-21 s SCREW (M2), LOCK ACE, P2 3-080-203-01 s SCREW(M2),LOCK ACE,P2 5-13 PMW-EX1...
  • Page 80 Front Block 5-14 PMW-EX1...
  • Page 81 3-285-955-01 s CMOS PROTECTION SHEET A 3-285-956-01 s CMOS PROTECTION SHEET B 3-968-729-52 s SCREW (M2), LOCK ACE, P2 7-627-556-57 s PRECISION SCREW +P 2.6X5 TYPE1 3-294-691-01 s WASHER 3-452-468-01 s BELT, GRIP 3-875-399-01 s LID, REAR 3-875-400-01 s CAP 5-15 PMW-EX1...
  • Page 82 VCL-EX0877 Part No. SP Description A-1538-803-A s FIXING SCREW ASSY 3-287-626-01 s CAP LENS (F) 3-287-627-01 s CAP LENS (R) 5-16 PMW-EX1...

  • Page 83: Electrical Parts List

    6-807-802-01 s IC UPD78F0533AGB(S)-402-UEU-A R151 1-208-903-81 s RES, CHIP 4.7K (1005) L100 1-469-549-21 s INDUCTOR, CHIP 1.0UH (LB2016) R152 1-208-863-81 s RES, CHIP 100 (1005) L101 1-469-549-21 s INDUCTOR, CHIP 1.0UH (LB2016) R153 1-208-863-81 s RES, CHIP 100 (1005) 5-17 PMW-EX1...
  • Page 84 C136 1-124-779-21 s CAP, ELECT 10MF (4.3X5.5) C137 1-124-779-21 s CAP, ELECT 10MF (4.3X5.5) C138 1-124-779-21 s CAP, ELECT 10MF (4.3X5.5) C203 1-164-935-81 s CAP, CHIP CERAMIC 470PF B 1005 C204 1-126-401-21 s CAP, CHIP ELECT 1MF (4X5.7) 5-18 PMW-EX1...
  • Page 85 8-719-069-61 s DIODE UDZSNPTE-1710B Q302 8-729-112-85 s TRANSISTOR 2SA1330-T1O6 D204 8-719-069-61 s DIODE UDZSNPTE-1710B Q321 6-550-981-01 s TRANSISTOR RN1905(T5RSONY,D,F) D205 8-719-820-42 s DIODE 1SS302-TE85L Q322 8-729-112-85 s TRANSISTOR 2SA1330-T1O6 D206 8-719-820-42 s DIODE 1SS302-TE85L 1-218-911-91 s RES, CHIP 470K (1608) 5-19 PMW-EX1...
  • Page 86 1-208-943-81 s RES, CHIP 220K (1005) R229 1-208-911-81 s RES, CHIP 10K (1005) R134 1-208-935-81 s RES, CHIP 100K (1005) R230 1-208-891-81 s RES, CHIP 1.5K (1005) R135 1-216-864-91 s CONDUCTOR, CHIP (1608) R231 1-208-891-81 s RES, CHIP 1.5K (1005) 5-20 PMW-EX1...
  • Page 87 1-208-863-81 s RES, CHIP 100 (1005) R406 1-208-863-81 s RES, CHIP 100 (1005) R409 1-208-927-81 s RES, CHIP 47K (1005) RB401 1-233-578-21 s RES, CHIP NETWORK 47K (3216) RB402 1-233-578-21 s RES, CHIP NETWORK 47K (3216) 1-781-696-31 s VIBRATOR, CRYSTAL (32.768 KHz) 5-21 PMW-EX1...
  • Page 88 1-220-870-81 s RES, CHIP 10 (1005) 1-220-870-81 s RES, CHIP 10 (1005) 1-220-870-81 s RES, CHIP 10 (1005) 1-220-870-81 s RES, CHIP 10 (1005) 1-220-870-81 s RES, CHIP 10 (1005) 1-220-870-81 s RES, CHIP 10 (1005) 1-208-923-81 s RES, CHIP 33K (1005) 5-22 PMW-EX1...
  • Page 89 1-220-870-81 s RES, CHIP 10 (1005) 1-220-870-81 s RES, CHIP 10 (1005) 1-220-870-81 s RES, CHIP 10 (1005) 1-220-870-81 s RES, CHIP 10 (1005) 1-220-870-81 s RES, CHIP 10 (1005) 1-220-870-81 s RES, CHIP 10 (1005) 1-220-870-81 s RES, CHIP 10 (1005) 5-23 PMW-EX1...
  • Page 90 1-220-870-81 s RES, CHIP 10 (1005) 1-220-870-81 s RES, CHIP 10 (1005) 1-220-870-81 s RES, CHIP 10 (1005) 1-220-870-81 s RES, CHIP 10 (1005) 1-220-870-81 s RES, CHIP 10 (1005) 1-220-870-81 s RES, CHIP 10 (1005) 1-208-923-81 s RES, CHIP 33K (1005) 5-24 PMW-EX1...
  • Page 91 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) C234 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) C235 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) C236 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) C237 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) 5-25 PMW-EX1...
  • Page 92 1-112-197-91 s CAP, CERAMIC 10PF CH (0603) C351 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) C559 1-112-197-91 s CAP, CERAMIC 10PF CH (0603) C353 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) C560 1-112-197-91 s CAP, CERAMIC 10PF CH (0603) 5-26 PMW-EX1...
  • Page 93 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) C712 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) C773 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) C713 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) C775 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) 5-27 PMW-EX1...
  • Page 94 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) C940 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) C1040 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) C941 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) C1041 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) 5-28 PMW-EX1...
  • Page 95 1-114-569-11 s CAP, CERAMIC 0.01MF X7R 1608 C1310 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) C1530 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) C1311 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) C1531 1-114-570-11 s CAP, CERAMIC 0.068MF X7R 1608 5-29 PMW-EX1...
  • Page 96 1-820-560-21 s CONNECTOR, COAXIAL(RECEPTACLE) C1589 1-100-881-91 s CAP, CERAMIC 47MF C (3216) CN1300 1-817-456-21 s CONNECTOR, COAXIAL C1590 1-112-716-91 s CAP, CERAMIC 0.1UF B (0603) C1591 1-114-569-11 s CAP, CERAMIC 0.01MF X7R 1608 CN1301 1-817-456-21 s CONNECTOR, COAXIAL 5-30 PMW-EX1...
  • Page 97 1-400-462-21 s FERRITE, EMI (SMD) (1005) FB411 1-400-462-21 s FERRITE, EMI (SMD) (1005) FB1824 1-400-462-21 s FERRITE, EMI (SMD) (1005) FB501 1-400-462-21 s FERRITE, EMI (SMD) (1005) FB502 1-400-462-21 s FERRITE, EMI (SMD) (1005) IC102 6-703-848-01 s IC SN74CB3T3306DCUR 5-31 PMW-EX1...
  • Page 98 1-469-549-21 s INDUCTOR, CHIP 1.0UH (LB2016) Q608 8-729-929-27 s TRANSISTOR DTC114TE-TL L404 1-469-549-21 s INDUCTOR, CHIP 1.0UH (LB2016) Q1100 6-550-832-01 s TRANSISTOR SI2301BDS-T1 L405 1-469-549-21 s INDUCTOR, CHIP 1.0UH (LB2016) Q1500 6-550-119-01 s TRANSISTOR DTC144EMT2L L406 1-469-549-21 s INDUCTOR, CHIP 1.0UH (LB2016) 5-32 PMW-EX1...
  • Page 99 1-240-718-91 s RES, CHIP 100K (0603) R312 1-240-718-91 s RES, CHIP 100K (0603) R390 1-240-695-91 s RES, CHIP 1K (0603) R313 1-240-683-91 s RES, CHIP 100 (0603) R391 1-240-707-91 s RES, CHIP 10K (0603) R392 1-240-679-91 s RES, CHIP 47 (0603) 5-33 PMW-EX1...
  • Page 100 1-240-762-91 s RES, CHIP 120 (0603) R548 1-240-772-91 s RES, CHIP 330 (0603) R464 1-240-784-91 s RES, CHIP 1K (0603) R549 1-240-772-91 s RES, CHIP 330 (0603) R465 1-240-695-91 s RES, CHIP 1K (0603) R550 1-240-772-91 s RES, CHIP 330 (0603) 5-34 PMW-EX1...
  • Page 101 1-240-676-91 s RES, CHIP 22 (0603) R913 1-240-714-91 s RES, CHIP 47K (0603) R649 1-240-676-91 s RES, CHIP 22 (0603) R914 1-240-714-91 s RES, CHIP 47K (0603) R650 1-240-676-91 s RES, CHIP 22 (0603) R915 1-240-714-91 s RES, CHIP 47K (0603) 5-35 PMW-EX1...
  • Page 102 1-240-749-91 s RES, CHIP 36 (0603) R1258 1-240-695-91 s RES, CHIP 1K (0603) R1114 1-240-749-91 s RES, CHIP 36 (0603) R1259 1-240-807-91 s RES, CHIP 9.1K (0603) R1115 1-240-788-91 s RES, CHIP 1.5K (0603) R1260 1-240-680-91 s RES, CHIP 56 (0603) 5-36 PMW-EX1...
  • Page 103 1-240-752-91 s RES, CHIP 47 (0603) R1631 1-240-718-91 s RES, CHIP 100K (0603) R1424 1-240-752-91 s RES, CHIP 47 (0603) R1632 1-240-676-91 s RES, CHIP 22 (0603) R1425 1-240-752-91 s RES, CHIP 47 (0603) R1633 1-240-676-91 s RES, CHIP 22 (0603) 5-37 PMW-EX1...
  • Page 104 1-240-759-91 s RES, CHIP 91 (0603) R2516 1-240-759-91 s RES, CHIP 91 (0603) R2517 1-240-754-91 s RES, CHIP 56 (0603) R2518 1-240-764-91 s RES, CHIP 150 (0603) R2519 1-240-777-91 s RES, CHIP 510 (0603) R2520 1-240-778-91 s RES, CHIP 560 (0603) 5-38 PMW-EX1...
  • Page 105 8-729-928-25 s TRANSISTOR 2SA1774TL-QR 6-550-119-01 s TRANSISTOR DTC144EMT2L 6-550-232-01 s TRANSISTOR 2SA2029T2LQ/R 6-551-797-01 s TR UNR92A3G0LS0 8-729-427-76 s TRANSISTOR XP4601-TXE 6-551-797-01 s TR UNR92A3G0LS0 8-729-427-76 s TRANSISTOR XP4601-TXE 1-208-935-81 s RES, CHIP 100K (1005) 1-208-935-81 s RES, CHIP 100K (1005) 5-39 PMW-EX1...
  • Page 106 1-794-276-21 o CONNECTOR, SQUARE TYPE 4P 6-500-750-01 s DIODE NSAD500H-T1-A 1-400-476-11 s COMMON MODE CHOKE COIL 1-218-990-81 s CONDUCTOR, CHIP (1005) THP1 1-805-726-11 s THERMISTOR, POSITIVE THP2 1-805-726-11 s THERMISTOR, POSITIVE THP3 1-805-726-11 s THERMISTOR, POSITIVE THP4 1-805-726-11 s THERMISTOR, POSITIVE 5-40 PMW-EX1...
  • Page 107 1-218-941-81 s RES, CHIP 100 VDR8 1-802-245-11 s ESD SUPPRESSOR R104 1-218-977-81 s RES, CHIP 100K VDR9 1-802-245-11 s ESD SUPPRESSOR R105 1-220-874-81 s RES, CHIP 15 (1005) R107 1-220-876-81 s RES, CHIP 18 (1005) R109 1-208-855-81 s RES, CHIP 47 (1005) 5-41 PMW-EX1...
  • Page 108 1-208-927-81 s RES, CHIP 47K (1005) R121 1-208-911-81 s RES, CHIP 10K (1005) R122 1-208-911-81 s RES, CHIP 10K (1005) R123 1-208-911-81 s RES, CHIP 10K (1005) R124 1-208-911-81 s RES, CHIP 10K (1005) R125 1-208-927-81 s RES, CHIP 47K (1005) 5-42 PMW-EX1...
  • Page 109 1-208-947-81 s RES, CHIP 330K (1005) 1-208-895-81 s RES, CHIP 2.2K (1005) 1-208-883-81 s RES, CHIP 680 (1005) 1-208-895-81 s RES, CHIP 2.2K (1005) 1-208-883-81 s RES, CHIP 680 (1005) 1-208-895-81 s RES, CHIP 2.2K (1005) 1-208-895-81 s RES, CHIP 2.2K (1005) 5-43 PMW-EX1...
  • Page 110 1-125-777-81 s CAP, CHIP CERAMIC 0.1MF B 1005 C206 1-125-777-81 s CAP, CHIP CERAMIC 0.1MF B 1005 C207 1-165-989-91 s CAP, CERAMIC 10MF (2012) C208 1-165-989-91 s CAP, CERAMIC 10MF (2012) C209 1-165-989-91 s CAP, CERAMIC 10MF (2012) 5-44 PMW-EX1...
  • Page 111 8-759-338-95 s IC NJM2903V(TE2) 8-719-938-77 s DIODE SB05-05C-TB-E 8-719-069-28 s DIODE 1SS400TE-61 1-456-622-21 s COIL, CHOKE 1UH 8-719-069-28 s DIODE 1SS400TE-61 1-456-622-21 s COIL, CHOKE 1UH 1-457-045-11 s COIL, CHOKE (8.2UH) 8-719-069-28 s DIODE 1SS400TE-61 1-457-045-11 s COIL, CHOKE (8.2UH) 5-45 PMW-EX1...
  • Page 112 1-208-935-81 s RES, CHIP 100K (1005) Q204 8-729-928-28 s TRANSISTOR DTA144EE-TL 1-208-911-81 s RES, CHIP 10K (1005) Q205 8-729-928-28 s TRANSISTOR DTA144EE-TL 1-208-915-81 s RES, CHIP 15K (1005) Q206 8-729-928-28 s TRANSISTOR DTA144EE-TL 1-218-990-81 s CONDUCTOR, CHIP (1005) Q207 8-729-928-28 s TRANSISTOR DTA144EE-TL 5-46 PMW-EX1...
  • Page 113 1-218-990-81 s CONDUCTOR, CHIP (1005) R231 1-208-927-81 s RES, CHIP 47K (1005) R101 1-208-919-81 s RES, CHIP 22K (1005) R232 1-208-927-81 s RES, CHIP 47K (1005) R102 1-208-919-81 s RES, CHIP 22K (1005) R233 1-208-927-81 s RES, CHIP 47K (1005) 5-47 PMW-EX1...
  • Page 114 1-208-887-81 s RES, CHIP 1.0K (1005) R333 1-208-879-81 s RES, CHIP 470 (1005) R334 1-219-611-21 s RES, CHIP (SQUARE TYPE) 0.047 R338 1-208-935-81 s RES, CHIP 100K (1005) R339 1-208-935-81 s RES, CHIP 100K (1005) R341 1-208-959-81 s RES, CHIP 1M (1005) 5-48 PMW-EX1...
  • Page 115 Q107 8-729-929-27 s TRANSISTOR DTC114TE-TL Q108 8-729-929-27 s TRANSISTOR DTC114TE-TL C1015 1-125-777-81 s CAP, CHIP CERAMIC 0.1MF B 1005 Q109 8-729-929-27 s TRANSISTOR DTC114TE-TL C1016 1-125-777-81 s CAP, CHIP CERAMIC 0.1MF B 1005 Q112 6-551-523-01 s TRANSISTOR SI7114DN-T1-E3 5-49 PMW-EX1...
  • Page 116 1-208-959-81 s RES, CHIP 1M (1005) R102 1-208-959-81 s RES, CHIP 1M (1005) R103 1-208-959-81 s RES, CHIP 1M (1005) R106 1-208-927-81 s RES, CHIP 47K (1005) R107 1-208-927-81 s RES, CHIP 47K (1005) R108 1-208-927-81 s RES, CHIP 47K (1005) 5-50 PMW-EX1...
  • Page 117 1-208-895-81 s RES, CHIP 2.2K (1005) 1-208-895-81 s RES, CHIP 2.2K (1005) 1-208-895-81 s RES, CHIP 2.2K (1005) 1-786-157-51 s TACTILE SWITCH 1-762-650-21 s SWITCH, SLIDE 1-786-157-51 s TACTILE SWITCH 1-479-022-71 s SENSOR, ANGULAR VELOCITY 1-479-022-81 s SENSOR, ANGULAR VELOCITY 5-51 PMW-EX1...
  • Page 118 1-208-895-81 s RES, CHIP 2.2K (1005) R500 1-208-927-81 s RES, CHIP 47K (1005) R501 1-208-927-81 s RES, CHIP 47K (1005) R502 1-208-927-81 s RES, CHIP 47K (1005) R504 1-208-863-81 s RES, CHIP 100 (1005) R505 1-208-895-81 s RES, CHIP 2.2K (1005) 5-52 PMW-EX1...
  • Page 119 1-125-777-81 s CAP, CHIP CERAMIC 0.1MF B 1005 C406 1-125-777-81 s CAP, CHIP CERAMIC 0.1MF B 1005 C407 1-125-777-81 s CAP, CHIP CERAMIC 0.1MF B 1005 C500 1-125-777-81 s CAP, CHIP CERAMIC 0.1MF B 1005 C501 1-125-777-81 s CAP, CHIP CERAMIC 0.1MF B 1005 5-53 PMW-EX1...
  • Page 120 1-208-919-81 s RES, CHIP 22K (1005) IC103 8-759-592-49 s IC TC7SZ125FU(TE85R) IC104 6-707-853-01 s IC TC74LCX541FT(EKJ) R308 1-208-863-81 s RES, CHIP 100 (1005) IC200 6-709-619-01 s IC GS1578ACNE3 R309 1-208-863-81 s RES, CHIP 100 (1005) R310 1-208-887-81 s RES, CHIP 1.0K (1005) 5-54 PMW-EX1...

  • Page 121: Supplied Accessories

    1-208-955-81 s RES, CHIP 680K (1005) R713 1-218-990-81 s CONDUCTOR, CHIP (1005) R714 1-208-951-81 s RES, CHIP 470K (1005) R715 1-208-911-81 s RES, CHIP 10K (1005) R719 1-208-935-81 s RES, CHIP 100K (1005) R720 1-218-990-81 s CONDUCTOR, CHIP (1005) 5-55 PMW-EX1...
  • Page 123 In addition, for semiconductors with ID Nos., refer to the separate CD-ROM titled “Semiconductor Pin Assignments” (Sony Part No. 9-968-546-06) that allows searching for parts by semiconductor type or ID No. The semiconductors in the manual or on the CD-ROM are listed by equivalent types.

  • Page 125: Block Diagrams

    OUTPUT connector KSW-53 Handle switch 7-3, 7-8 LED-465 Tally switch 7-11 MA-161 MIC jack RE-250 DC-DC converter RE-251 DC-DC converter 7-10 RM-213 Remote connector SW-1375 Shutter switch 7-3, 7-11 SW-1397 Switch 7-11 SWC-47 INSIDE switch 7-11 TX-115 HD-SDI 7-12 PMW-EX1...

  • Page 126: Overall

    LIGHT IC1101 DRIVER DEVICE TIMING IC512-514 Y,PR,PB COMPONENT IC515 VIDEO MA-161 AU-313 IC101,201 (2/2) MIC1,MIC2 IC510,511 IC105,205 IC800,801 IC804 AXM-35 IC102,202 AUDIO IN TX-115 AUDIO CPLD CH1,CH2 LED-465 ASW-65 AD/DA IC100 IC200 (2/2) COPRO SDI OUT IC102 SPEAKER Overall PMW-EX1...

  • Page 127: Au-313 (1/2)

    Harness (i.LINK CN) ANGLE_LEVEL_V ANGLE_LEVEL_V ANGLE_LEVEL_V TILT HN-338 LENS_TX LENS_TX Handle switch LENS_RX LENS_RX KSW-53 (1/2) LENS_RESET LENS_RESET LENS_FLMDO LENS_FLMDO LENS LENS_FLMDI LENS_FLMDI LENS_UNREG_OUT LENS_UNREG_OUT MIC jack 31,32 LENS_UNREG_GND LENS_UNREG_GND MA-161 33,34 ND_POSI_0 ND_POSI_0 LENS ND_POSI_1 ND_POSI_1 Shutter switch SW-1375 (1/2) PMW-EX1...

  • Page 128: Bi-202

    I/O1.7 SCK0 IC319 SY_SC21_IMG_CLK CMOS sensor CN1803 SDIN(DP) BI-203 CN1802 B_HDMI_IIC_SDA RXD0 LENS_REMOTE/LOCAL IC320 SY_SC21_IMG_DIN SCLK(DP) B_HDMI_IIC_SCK IC307 TXD0 SY_SC21_IMG_DOUT CN1802 CN1802 LENS_COMP_IRIS_CONT SY_SC21_IMG_RDY SDIN(DP) B_HDMI_IIC_SDA IC308 SCLK(DP) CMOS sensor EXTAL B_HDMI_IIC_CLK IC321 SY_MLN_CLK BI-204 MAIN board DPR-289 (1/4) PMW-EX1...

  • Page 129: Ec-62

    MD_OPCRSTX PRST IPCINTBX INTA IPCREQX1 IC1400 X1400 X1200 BPCGNTX1 CLOCK BUFFER 33.333MHz 24.576MHz PCLK XTAL_IN BCLK0 P-RESET OSYSPLOCK BCLK1 ISYSCK MAIN board BCLK2 ISYSDRPCK DPR-289 (2/4) BCLK3 IPCPCLK BCLK5 EXPRESS card slot BCLK4 EC-62 Harness (i.LINK CN) HN-319 (1/2) PMW-EX1...

  • Page 130: Jk-77

    IC504 F8,F2 DP_B_DDR_DM0-3 DM0-3 L8,L2, IC501 IC502 GLK_STX IC500 CN400 E8,E2 DP_B_DDR_DQS0-3 DP_O_SDI_CLK DQS0-3 GLK_SCLK IC503 X500 CONV IC504 IC505 O_GLK_SCS MAIN board IC502 IC521 IC504 O_VCO_CTL0 DPR-289 (3/4) PHASE O_VCO_CTL1 COMP O_S_C Q512,515 OUTPUT connector DP_ADJ_54M JK-77 (1/2) PMW-EX1...
  • Page 131 IC1712 I2C_SDA RE-251 I2C_SCL SY_SC21_DISP_CLK RE-251 SCK2 IC1711 SY_+2.5V CN1802 RXD3 I2C_SDA AA14 SY_SC21_MEDIA_DOUT IC1707 I2C_SCL TXD3 SY_SC21_MEDIA_DIN SCK3 SY_SC21_MEDIA_CLK IC1703 CN1803 SERIAL I2C_SDA EEPROM MAIN board I2C_SCL DPR-289 (4/4) JOG_A AB10 TI2A JOG_B TI2B OUTPUT connector JK-77 (2/2) PMW-EX1...

  • Page 132: Axm-35 (2/2)

    AUDIO XLR Q1,2 LED_FRTALLY_HIGH P130 AXM-35 (2/2) SWITCH +2.5V LED_FRTALLY_LOW SW_FRRMOUT REMOTE RECEIVE P141 IC101 LCD switch DET-44 AXM-35 (2/2) EVF driver LINE/MIC/+48V_1 DR-621 +48V LINE1_SW LINE +48V_1_SW Handle switch LINE/MIC/+48V_2 LINE2_SW KSW-53 (2/2) +48V_2_SW +48V LINE Remote connector RM-213 PMW-EX1...

  • Page 133: Dc-143

    D205, SW_IM_2P5V D218-220 SW_DP_2P5V SW_SY_2P5V SW_IM_3P1V SW_DP_3P1V IC21 IC22 IC11 SW_ME_3P1V Q15,16,43,44,47,48 SW_SY_3P1V RE-251 SW_IM_4P6V SW_DP_4P6V IC21 IC22 IC11 SW_SY_4P6V Q45,46,53 Q41,42,52 Q10,40,51 SW_IM_1P2V SW_SY_1P2V CN201 IM_EN ME_EN DP_EN H_SHUTDOWN DC-IN connector CN200 H_SHUTDOWN H_SHUTDOWN DC-143 DC-DC converter RE-250 PMW-EX1...

  • Page 134: Re-251

    BAT_SDA SW_DP_13P5V BAT_SCL GP_140 BATT_DET GP_141 DC/BATT_DET GP_50 GP_51 SW_IM_1P0V SW_IM_1P2V SW_SY_1P2V SW_SY_2P5V SW_PWR_A SW_IM_4P6V SW_PWR_B SW_SY_4P6V SW_BATTINFO SW_ME_2P5V SW_IM_2P5V SW_DP_2P5V SW_IM_3P1V SW_DP_3P1V SW_ME_3P1V SW_SY_3P1V SW_DP_4P6V SY_EN ME_EN DP_EN IM_EN Q1000 Q1001 PWR_ON/HOLD PWR_WAKEUP DC-DC converter RE-251 7-10 7-10 PMW-EX1...

  • Page 135: Asw-65

    SW_BACKLIGHT LED-465 SW_BRIGHT_P,M SW_TC_UB_CT 51,50,56, SW_STATUS S500-509 10 9 63,4-1,62 SW_OUTPUT P141 SWITCH Shutter switch P41-43 P120 SW-1375 (2/2) IC103 CN101 Q500 LINE_AV_OUT1 S500 +2.5V CN101 LINE_AV_OUT2 Switch SW-1397 IC103 Q103 Q104 CN101 SW_BATTERY_INFO/DISPLAY INSIDE switch SWC-47 7-11 7-11 PMW-EX1...

  • Page 136: Tx-115

    IC308 IC600 CONFIG OE/RESET PROM CN100 JTAG_TDO Q700 CN700 +3.3V +2.5V_IN +2.5V_COP +3.1V +2.5V_HDSDI R710 IC704 CN700 DP_SDI_DWN IC702 +2.5V_IN DC-DC +3.3V_COP CONV +3.3V_PLL IC701 IC703 +1.8V_IN DC-DC +1.5V_COP CONV IC705 +3.1V DC-DC +2.5V_DIF CONV HD-SDI TX-115 7-12 7-12 PMW-EX1...

  • Page 137: Schematic Diagrams

    EC-62 8-45 HN-318 8-45 HN-319 8-45 HN-320 8-46 HN-338 8-46 HN-339 8-46 JK-77 8-46 KSW-53 8-47 LE-346 8-48 LED-465 8-48 MA-161 8-49 RE-250 8-51 RE-251 8-55 RM-213 8-59 SW-1375 8-59 SW-1397 8-59 SWC-47 8-60 TX-115 8-62 Frame Wiring 8-69 PMW-EX1...

  • Page 138: Asw-65

    HP_MUTE C101 LED-465 GND(A) CN100 +2.5V A_GND AN_AUDIO_VOL2 AU Vol. +5.0V +2.5V GND(A) LED_REARTALLY Module LED_RRTALLY R104 4.7k A_GND VR_AUCH1 VR_AUCH1 AN_AUDIO_VOL1 11 12 D104 C100 1SS302-TE85L A_GND INPUT LEVEL 1 ASW-65 (1/3) A_GND A_GND BOARD NO. 1-875-323-11 PMW-EX1_ASW-65_11F_1 PMW-EX1...
  • Page 139 47uF 10uF R150 A_GND R149 R140 -5.0V_A A_GND A_GND A_GND A_GND A_GND A_GND A_GND Q100 R124 100k DTC123JE-TL Q104 Q103 MUTE_CONT A_GND 2SC3326N-TE85L-AB 2SC3326N-TE85L-AB C109 10uF HP_MUTE R125 Q102 2SA2029T2LQ/R A_GND A_GND -5.0V_A ASW-65 (2/3) BOARD NO. 1-875-323-11 PMW-EX1_ASW-65_11F_2 PMW-EX1...
  • Page 140 +2.5V SW_JOG_PUSH SW_JOG_PUSH SW_JOG_MENU SW_JOG_MENU SW_EXCHANGE SW-1397 SW_EXCHANGE JOGA_A JOGA_A JOGA_B JOGA_B 11 12 13 14 SW_INT SEED_BUS JOGA POWER SW_PWR S104 D108 R113 MAZT082H08S0 2.2k MEDIA SW_PWR_B R112 D109 2.2k MAZT082H08S0 SW_PWR_A ASW-65 (3/3) BOARD NO. 1-875-323-11 PMW-EX1_ASW-65_11F_3 PMW-EX1...

  • Page 141: Au-313

    0.47uF 0.1uF VREF FREQ 0.001uF 220k A_GND 10pF 100k PGND 47uF A_GND 100k EPAD COMP MBRS130LT3 0.47uF PS_GND 100uF 0.0022uF 100k 470k 0.47uF 4.7k 10uF 10uH 0.047uF 10uF 10uF -5.0V_A AU-313 (1/3) 1.2k BOARD NO. 1-875-329-11 A_GND PMW-EX1_AU-313_11F_1 A_GND PMW-EX1...
  • Page 142 A_GND A_GND A_GND R241 Q322 003-I3 LINE_2 2SA1330-T1O6 Q207 A_GND R322 DTC144EE-TL -5.0V_A A_GND 001-K8,002-B4 +48V R224 C321 R324 C322 +3.3V_A 0.1uF 220k R323 100k R321 A_GND 003-I4 +48V_2 -BIAS 001-F9,002-E5 Q321 AU-313 (2/3) RN1905(T5RSONY,D,F) BOARD NO. 1-875-329-11 PMW-EX1_AU-313_11F_2 PMW-EX1...
  • Page 143 AUTO_WIN_1 I/O0 WIN_DET_1 001-G6 R405 +12dB_1 I/O1 +12dB_1 002-G4 R406 AUTO_WIN_2 I/O2 WIN_DET_2 001-G6 D_GND +12dB_2 I/O3 +12dB_2 002-G8 LINK_1_A I/O4 LINK_1_A 002-K3 LINK_2_A I/O5 LINK_2_A 002-K8 I/O6 I/O7 NC(TM) D_GND D_GND 001-K7 AU-313 (3/3) BOARD NO. 1-875-329-11 PMW-EX1_AU-313_11F_3 PMW-EX1...

  • Page 144: Axm-35

    A_GND +48V A_GND +48V_1 LINE_1 LINE1 SW +48V_1 +48V_1 SW LINE_1 LINE_2 LINE2 SW LINE +48V_2 +48V_2 SW MAZT082H08S0 1000pF 1000pF 16 17 LINE/MIC/+48V_2 +48V +48V_2 KSW-53 LINE LINE_2 MAZT082H08S0 1000pF 1000pF AUDIO XLR AXM-35 BOARD NO. 1-875-339-11 PMW-EX1_AXM-35_11F_1 PMW-EX1...

  • Page 145: Bi-202

    +3.3V(CPVD) AGND AGND CPVD +3.3V(AVD0) 0.1uF VDDLB AVD0 +3.3V(AVD) +1.8V(AVD1) AVD1 VSSDA +3.3V(SVD) AGND AGND 0.1uF AGND O.S. +3.3V(AVD) AGND AGND VDDSN1 LM75CIMMX-3 AGND AGND 0.1uF 2.2uF VDDSN2 AGND 0.1uF AGND BI-202 VSSSN1 VSSSN2 BOARD NO. 1-875-552-11 AGND PMW-EX1_BI-202_11F_1 PMW-EX1...

  • Page 146: Bi-203

    AGND CPVD +3.3V(AVD) 0.1uF VDDLB +3.3V(AVD0) AVD0 +1.8V(AVD1) AVD1 VSSDA +3.3V(SVD) 0.1uF O.S. AGND AGND AGND +3.3V(AVD) AGND LM75CIMMX-3 AGND VDDSN1 AGND AGND 2.2uF 0.1uF AGND VDDSN2 AGND 0.1uF BI-203 VSSSN1 VSSSN2 BOARD NO. 1-875-553-11 AGND PMW-EX1_BI-203_11F_1 8-10 8-10 PMW-EX1...

  • Page 147: Bi-204

    AGND CPVD +3.3V(AVD0) 0.1uF VDDLB AVD0 +3.3V(AVD) +1.8V(AVD1) AVD1 VSSDA +3.3V(SVD) AGND AGND 0.1uF AGND O.S. +3.3V(AVD) AGND AGND VDDSN1 LM75CIMMX-3 AGND AGND 2.2uF 0.1uF VDDSN2 AGND 0.1uF AGND BI-204 VSSSN1 VSSSN2 BOARD NO. 1-875-554-11 AGND PMW-EX1_BI-204_11F_1 8-11 8-11 PMW-EX1...

  • Page 148: Bp-43

    +1.0V_IM +1.0V_IM +1.0V_IM +1.0V_IM +1.0V_IM +1.0V_IM +1.0V_IM +1.0V_IM DET-44 BOARD NO. 1-875-341-11 +2.5V_ME +2.5V_ME PMW-EX1_DET-44_11F_1 +2.5V_ME +2.5V_ME +3.1V_SY +3.1V_SY DOWN_DET_ME DOWN_DET_SYDP DOWN_DET_SYDP DOWN_DET_ME H_SHUTDOWN H_SHUTDOWN H_START_UP H_START_UP CN-3007 CN-3006 BOARD NO. 1-875-334-11 BOARD NO. 1-875-332-11 PMW-EX1_CN-3007_11F_1 PMW-EX1_CN-3006_11F_1 8-12 8-12 PMW-EX1...

  • Page 149: Dpr-289

    C100 C102 C103 C108 C110 C111 C115 C117 C118 IM_SCL_TEMP 47uF 0.1uF 47uF 0.1uF 47uF IM_STRB_P_B AD14 0.1uF I_STRB_B R118 IM_B_VIDEO_IN IM_EX_ND_CONT_1 IM_SDA_TEMP IM_LD(LENS) IC100 (2/6) CXD9189GG-P IC102 SN74CB3T3306DCUR DPR-289 (1/18) 001,003 IM_IMX_COM BOARD NO. 1-875-327-13 PMW-EX1_DPR-289_13F_1 8-13 8-13 PMW-EX1...
  • Page 150 8-14 8-14 PMW-EX1...
  • Page 151 0.1uF IM_I_CAM_VALID O_DGTL_FVALID IM_I_CAM_HD C209 C213 C244 C246 O_DGTL_H_X C211 C245 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF IM_I_CAMA_SKIN O_DGTL_SKIN O_DGTL_V_X IM_O_DGTL_V_X 003,004,016 R211 IC100 (3/6) IM_B_RET_VSYNC CXD9189GG-P R212 IM_B_RET_HSYNC R213 IM_B_RET_FSYNC DPR-289 (2/18) BOARD NO. 1-875-327-13 PMW-EX1_DPR-289_13F_2 8-15 8-15 PMW-EX1...
  • Page 152 R323 R330 5.6k C315 C318 C322 C323 C325 C326 C327 C330 C332 C334 C335 C336 C337 C339 C341 0.1uF 0.1uF 10uF 10uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF R314 FB305 AGND_PLL IM_IRIS_CLOSE 8-16 8-16 PMW-EX1...
  • Page 153 IM_+3.3V_SUN AN7/PJ7 VSSQUSB IM_IRIS_POS AN3/PJ3 UEXTAL AVDD[AD] VSSQ6 IM_D0 VSS3 IM_D1 AVSS[AD] IM_D4 TEND/PI4 IM_+2.5V IC320 R393 IM_+3.3V TC7SZ08AFE IM_+2.5V IM_RXD4 CL303 CL311 C366 0.1uF IM_TXD4 CL304 CL312 IM_+2.5V_SUN SY_SC2I_IMG_CLK DPR-289 (3/18) BOARD NO. 1-875-327-13 IM_+3.3V_SUN PMW-EX1_DPR-289_13F_3 8-17 8-17 PMW-EX1...
  • Page 154 DP_B_PXY_VIDEO1 B_PXY_VIDEO1 AE35 DP_B_PXY_VIDEO0 DP_I_CAM_AU_DT B_PXY_VIDEO0 DP_I_CAM_AU_DT12 I_CAM_AU_DT12 DP_O_CAM_AU_DT12 R402 O_CAM_AU_DT12 R403 DP_O_CAM_AU_DT34 O_CAM_AU_256FS O_CAM_AU_64FS DP_I_CAM_AU_DT34 I_CAM_AU_DT34 DP_A4.6V DP_A4.6V_A O_CAM_AU_DT34 DP_O_SDI_AU_DT12 R404 L402 DP_O_CAM_AU_DT R405 DP_O_SDI_AU_DT34 C406 C407 DP_O_SDI_AU_DT 10uF 0.1uF R407 DP_MCK1 R408 DP_O_SDI_AU_64FS R409 DP_BCK1 8-18 8-18 PMW-EX1...
  • Page 155 +1.8V +5.0V DP_O_D_HSYNC FB403 O_D_HSYNC RM_UNREG O_HDMI_VDTA_EN For HDMI Option To SC-COPRO R457 RM_UNREG O_D_XRST DP_O_D_XRST R458 SY_+4.6V O_D_CLK DP_O_D_CLK R459 -5.0V DP_O_D_FLDID FB404 O_D_FLDID -5.0V DP_SDI_DWN DP_SDI_DWN DP_-4.6V Media I/F DPR-289 (4/18) BOARD NO. 1-875-327-13 PMW-EX1_DPR-289_13F_4 8-19 8-19 PMW-EX1...
  • Page 156 IC504 C513 C515 C524 TC74LCX08FT(EKJ) 0.1uF 10uF 0.1uF R520 IC505 (1/2) R524 TC7SZ126FU(TE85R) DP_I_CLK_54M_SEL DP_I_CLK_54M R525 DP_VIDEO_1 005,018 R527 005,006 DP_ADJ_54M DP_O_EVF_CLK R2530 DP_O_SDI_CLK 12.5MHz DP_I_XTL_CLK_12M DP_B_XTL_CLK_12M R526 X501 12.5MHz C525 C527 22pF 22pF Genlock(SYNC SEP.)/PLL 256FS/12.5MHz/80.125MHz 8-20 8-20 PMW-EX1...
  • Page 157 DP_A4.6V_2 IC511 R2536 R2535 C554 AD8014ARTZ-REEL7 C562 0.1uF L508 R553 4.7uH R2504 1005 R2519 R541 C552 C557 R550 C564 0.1uF R564 R2528 R2540 R2541 DP_-4.6V_2 R594 2.7k DP_-4.6V_3 R581 R595 1.6k DPR-289 (5/18) BOARD NO. 1-875-327-13 PMW-EX1_DPR-289_13F_5 8-21 8-21 PMW-EX1...
  • Page 158 R632 DP_O_LCD_BLC O_LCD_BLC VDD_BL(+5.0V) FB602 VDD_BL(+5.0V) FB600 GND_BL GND_BL VDD (+3.3V) IC609 (2/2) IC610 (2/2) SPARE R629 TC7SZ125FU(TE85R) TC7SZ125FU(TE85R) 41 42 43 44 45 46 47 48 49 50 51 DP_+3.1V DP_+3.1V R630 C631 C632 0.1uF 0.1uF 8-22 8-22 PMW-EX1...
  • Page 159 R631 DP_O_FM_ADRS0 DP_B_FM_DATA1 A0[H7] DQ1[B9] 100k DP_B_FM_DATA0 DQ0[A8] DP_O_EXRAM_ WE WE[F9] DP_O_EXRAM_ CS CS[G9] DP_O_EXRAM_ CAS CAS [F7] DP_O_EXRAM_ RAS RAS [F8] DP_O_FM_ADRS21 UDQM[F1] DP_O_FM_ADRS20 LDQM[E8] DP_O_EXRAM_CKE CKE[F3] DP_O_EXRAM_CLK CLK[F2] NC[E2] DPR-289 (6/18) BOARD NO. 1-875-327-13 PMW-EX1_DPR-289_13F_6 8-23 8-23 PMW-EX1...
  • Page 160 CXD9211BGG VSS71 VDDI12_19 AJ16 VDDI12_1 DP_O_DDR_CLK0 DP_B_DDR_DATA2 VSS72 VDDI12_17 DP_O_DDR_CLKN0 DP_B_DDR_DATA1 VSS79 VDDI12_15 DP_B_DDR_DATA0 VSS80 C713 VDDI12_14 AK11 0.1uF VSS81 AK13 VSS82 AK15 VSS83 AK17 VSS84 AK19 VSS85 VSS92 VSS94 IC400 (4/7) VSS95 CXD9211BGG VSS96 AR14 VSS97 8-24 8-24 PMW-EX1...
  • Page 161 AP27 A_PLL_AVD33_2 I_VBS_VREF NC39 NC91 AR27 R708 A_PLL_AVD33_1 O_YC_VRO NC40 NC90 2.7k FB705 O_VBS DP_O_VBS NC41 NC89 I_YC_VREF NC42 NC88 DP_VREF_+1.1V NC43 NC87 C785 0.001uF C778 0.1uF DP_O_BS_RTCK DP_VREF_+1.1V C779 0.1uF DPR-289 (7/18) BOARD NO. 1-875-327-13 PMW-EX1_DPR-289_13F_7 8-25 8-25 PMW-EX1...
  • Page 162 DP_HP_1_R DP_SP_1_+ DP_SP_1_- DP_MONI_MIX1 DP_MONI_MIX2 DP_I_CAM_AU_DT12_0 DP_I_CAM_AU_DT34_0 DP_O_CAM_AU_DT12_0 DP_O_CAM_AU_DT34_0 DP_+3.1V DP_A3.3V_A L800 IC802 DP_A4.6V DP_A4.6V_A_1 TPS73632DBVR DP_+3.3V_A_1 L801 C814 C815 C820 C821 10uF 0.1uF 0.1uF 10uF C819 0.1uF DP_A_GND DP_A_GND DP_A_GND DP_A_GND DP_A_GND DP_A_GND L802 DP_-4.6V DP_-4.6V_A 8-26 8-26 PMW-EX1...
  • Page 163 DP_BCK1 IO23 IO53 C833 0.1uF B_GPIO_BP_B3 I_EXT_INT0 004,009 MD_TORINO_IVFSYNC DP_A3.3V_A IC803 RB800 PCA9546ABS DP_+2.5V DP_+2.5V C822 0.1uF DP_I2C_1 DP_I2C_2 DP_SDA_1 DP_SCL_1 004,006,018 DP_B_HDMI_IIC DP_SDA_2 DP_SCL_2 B_HDMI_IIC_SDA B_HDMI_IIC_CLK DP_SYS_RESET RESET 007,008,017 EPAD DPR-289 (8/18) BOARD NO. 1-875-327-13 PMW-EX1_DPR-289_13F_8 8-27 8-27 PMW-EX1...
  • Page 164 GND78[H12] VDDQ43[R17] GND38[U7] GND79[H11] C930 FB903 0.1uF GND39[V7] GND80[H10] VDDQ3[B22] AVDD2[A17] GND40[V8] GND81[H9] C917 VDDQ39[L18] 0.1uF GND41[V9] VDDQ40[K18] AGND2[A16] VDDQ41[J18] L900 C931 C954 C956 C958 R902 VDDQ45[L17] 0.001uF 0.1uF 47uF 47uF 22uH 0.22 VDDQ46[K17] AVDD3[AD14] VDDQ4[B19] AGND3[AD13] 8-28 8-28 PMW-EX1...
  • Page 165 AF24 MD_BBDT25 MD_BBDT24 BBDT2_4 MD_BBDT24 AF23 MD_BBDT23 BBDT2_3 MD_BBDT23 AJ28 C966 C967 MD_BBDT22 BBDT2_2 MD_BBDT22 0.1uF 0.1uF RB903 AK28 MD_BBDT21 MD_BBDT21 BBDT2_1 AF25 MD_BBDT20 BBDT2_0 MD_BBDT20 AE18 004,008,009 MD_TORINO_IVFSYNC IVFSYNC MD_BBDT2 DPR-289 (9/18) BOARD NO. 1-875-327-13 PMW-EX1_DPR-289_13F_9 8-29 8-29 PMW-EX1...
  • Page 166 C1030 C1041 C1051 VDDQ10 VDDQ10 VSS4 0.1uF 0.001uF VSS4 0.1uF 0.001uF VSS3 VSS3 DLLVDD_3 VSS2 VSS2 C1001 C1009 VSS1 VSS1 47uF 0.1uF DLLGND_3 NC10 NC10 NC11 NC11 NC12 NC12 NC13 NC13 DPR-289 (10/18) BOARD NO. 1-875-327-13 PMW-EX1_DPR-289_13F_10 8-30 8-30 PMW-EX1...
  • Page 167 OUBRSTX MD_OUBRSTX GND2[M6] NC1[A1] IUBVBUS MD_IUBVBUS R1118 NC6[A12] 100k OUBPSWX MD_OUBPSWX NC10[B11] BUNRI[L12] NC7[B2] FM21[M2] Q1100 NC5[E12] SCAN0[H2] SI2301BDS-T1 NC4[F12] SCAN1[H3] MD_+3.3V MD_+3.3V_PIFC NC9[L11] R1104 NC8[L2] NC2[M1] NC3[M12] C1116 10uF R1105 DPR-289 (11/18) BOARD NO. 1-875-327-13 PMW-EX1_DPR-289_13F_11 8-31 8-31 PMW-EX1...
  • Page 168 BPCAD_3 MD_BPCAD3 012,013 012,013 MD_BPCAD3 IPCMSSEL 8.2k R1250 BPCAD_2 MD_BPCAD2 012,013 012,013 MD_BPCAD2 R1251 8.2k BPCAD_1 MD_BPCAD1 012,013 012,013 MD_BPCAD1 C1208 C1214 R1252 8.2k 10pF 10pF BPCAD_0 MD_BPCAD0 012,013 012,013 MD_BPCAD0 DPR-289 (12/18) BOARD NO. 1-875-327-13 PMW-EX1_DPR-289_13F_12 8-32 8-32 PMW-EX1...
  • Page 169 R1319 ICS9DB102BGLFT CLKD 49.9 CLKD R1314 R1316 R1318 DPR-289 (13/18) 49.9 49.9 49.9 MD_IPECKP1 X1300 IREF R1315 R1317 MD_IPECKN1 25MHz GNDODA GNDXD R1310 49.9 49.9 MD_IPECKP2 BOARD NO. 1-875-327-13 MD_IPECKN2 C1300 C1301 12pF 12pF R1311 PMW-EX1_DPR-289_13F_13 181305221 8-33 8-33 PMW-EX1...
  • Page 170 8-34 8-34 PMW-EX1...
  • Page 171 MD_+3.3V AB31 OURSDO2 BGPIO_4 BGPIO_28 MD_BGPIO_28 AC27 OURRTS2 AA30 BGPIO_3 AA31 AC25 IC1402 BGPIO_2 IURCTS2 R1426 AB29 TC7SZ125FU(TE85R) BGPIO_1 BGPIO_20 CL1400 AB30 MD_+3.3V BGPIO_0 BGPIO_21 C1407 0.1uF 011,014 MD_IUBVBUS OUTY MD_VBUS DPR-289 (14/18) BOARD NO. 1-875-327-13 PMW-EX1_DPR-289_13F_14 8-35 8-35 PMW-EX1...
  • Page 172 SYNC COMP MD_BGPIO_6 SHDN/RT R1523 PGND SGND NC(TM) 3.3k C1587 GP_140 C1563 220pF R1531 R1537 10pF C1557 C1560 R1524 0.1uF 0.1uF 6.3V 6.3V R1538 C3500 C1586 R1512 330k 10pF 100pF 100k S-GND P-GND Q1502 Q1508 DTC144EMT2L DTC114TE-TL 8-36 8-36 PMW-EX1...
  • Page 173 GND72 GND145 SPA_VD10_14 GND73 GND144 SPA_VD10_15 SPA_VD10_16 SPA_VD10_17 SPA_VD10_18 SPA_VD10_19 SPA_VD10_20 SPA_VD10_21 SPA_VD10_22 SPA_VD10_23 SPA_VD10_24 SPA_VD10_25 SPA_VD10_26 SPA_VD10_27 SPA_VD10_28 SPA_VD10_29 SPA_VD10_30 SPA_VD10_31 SPA_VD10_32 SPA_VD10_33 SPA_VD10_34 SPA_VD10_35 SPA_VD10_36 SPA_VD10_37 SPA_VD10_38 SPA_VD10_39 SPA_VD10_40 DPR-289 (15/18) BOARD NO. 1-875-327-13 PMW-EX1_DPR-289_13F_15 8-37 8-37 PMW-EX1...
  • Page 174 SY_MLN_ WE1 /DQMLU SY_FLASH_ WAIT TC7SZ08AFE WE1 /DQMLU/ ICWE SY_+2.5V SY_+2.5V WE2 /DQMUL/ ICIORD SY_+2.5V WE3 /DQMUU/AH/ ICIOWR AB19 AA20 R1607 R1608 100k AA19 WAIT IC1606 (1/2) TC7SZ08AFE AA21 TEST2 AB20 TEST1 STATUS1/PR3 SY_PWR_MLN_STAT1 TEST0 STATUS0/PR2 SY_PWR_MLN_STAT0 8-38 8-38 PMW-EX1...
  • Page 175 MSDATA3/PF5 VDD7 VSSQ2 AC21 MSBS/PF6 VDD8 VSSQ3 VSSQ4 VSS1 VSSQ5 SYSCON VSS2 VSSQ6 VSS3 VSSQ7 VSS4 VSSQ8 (5/10) VSS5 VSSQ9 AC13 VSS6 VSSQ10 AC14 AC16 VSS7 VSSQ11 AC19 AC20 VSS8 VSSQ12 DPR-289 (16/18) BOARD NO. 1-875-327-13 PMW-EX1_DPR-289_13F_16 8-39 8-39 PMW-EX1...
  • Page 176 8-40 8-40 PMW-EX1...
  • Page 177 DP_+2.5V SY_+2.5V DP_+2.5V SY_+2.5V DP_+2.5V DP_+2.5V IC1600 (4/10) IC1706 (2/2) IC1712 (2/2) CXD3175BGG-T6 TC7SZ08AFE TC7SZ08AFE R1737 R1738 SYSCON AA14 C1702 SDA/PR0 SY_I2C_SDA 0.1uF (4/10) SCL/PR1 SY_I2C_SCL SY_+2.5V C1701 0.1uF IC1703 DPR-289 (17/18) M24256-BWMN6TP(A) BOARD NO. 1-875-327-13 PMW-EX1_DPR-289_13F_17 8-41 8-41 PMW-EX1...

  • Page 178: Power Supply

    DP_UNREG B_HDMI_IIC_CLK +3.1V_ME SCLK (DP) UNREG_DP GND(D) UNREG_DP GND(D) SY_+1.25V DP_A_GND +1.2V_SY SWD_UNREG +1.2V_SY IM_+1.25V +1.2V_IM +1.2V_IM IM_+1.0V +1.0V_IM +1.0V_IM +1.0V_IM +1.0V_IM MD_+2.5V +2.5V_ME +2.5V_ME SY_+3.3V +3.1V_SY DOWN_DET_SYDP DOWN_DET_SYDP DOWN_DET_ME DOWN_DET_ME H_SHUTDOWN H_SHUTDOWN 006,015 H_START_UP H_START_UP 006,015 8-42 8-42 PMW-EX1...
  • Page 179 VIDEO_2 DP_VIDEO_3 DP_CONE_V_CPNT S_JK_SW DP_CONE_V_S DP_S_Y S_Y_GND DP_S_C S_C_GND LINE MONI1_L(A/V) DP_LINE_AV_1 AV_JK_SW DP_VIDEO_2 LINE MONI2_R(A/V) DP_LINE_AV_2 VIDEO_1 DP_VIDEO_1 USB_DM_OTG0 SY_USB_D- USB_VBUSOTG0 SY_USB_VBUSHS USB_DP_OTG0 SY_USB_D+ USB_DM MD_USB_D- USB_VSUB MD_USB_VCC USB_DP MD_USB_D+ DPR-289 (18/18) BOARD NO. 1-875-327-13 PMW-EX1_DPR-289_13F_18 8-43 8-43 PMW-EX1...

  • Page 180: Dr-621

    O_EVF_R_PR +2.5V DPR-289 O_EVF_R_PR O_EVF_XRST O_EVF_XRST O_EVF_SCLK O_EVF_SCLK 001-B7 I_LCD_EVF_SRX I_LCD_EVF_SRX 001-B8 O_EVF_STX O_EVF_STX 001-B8 1SS302-TE85L O_EVF_VD O_EVF_VD 1SS302-TE85L O_EVF_HD O_EVF_HD 2.2k I2C_SCL I2C_SDA 2.2k +2.5V +2.5V PANEL_REVERSE PANEL_OPEN/CLOSE ZOOM SW_BATT_INFO/DISP 001-B4 DR-621 BOARD NO. 1-875-325-11 PMW-EX1_DR-621_12F_1 8-44 8-44 PMW-EX1...

  • Page 181: Ec-62

    TPA+ A5.0V A5.0V -5.0V -5.0V -5.0V -5.0V +3.3V +3.3V +3.3V +3.3V EC-62 NSAD500H-T1-A CHASSIS-GND SDIN(DP) SDIN(DP) BOARD NO. 1-875-322-11, 12 SCLK(DP) SCLK(DP) PMW-EX1_EC-62_11F_1 GND(D) GND(D) GND(D) GND(D) HN-319 HN-318 BOARD NO. 1-875-330-11 BOARD NO. 1-875-342-11 PMW-EX1_HN-319_11F_1 PMW-EX1_HN-318_11F_1 8-45 8-45 PMW-EX1...

  • Page 182: Hn-320

    +5V(A) USB_DM_OTGO USB_DM_OTGO +5V(A) USB_VBUSOTGO USB_VBUSOTGO GND(A) USB_DP_OTGO USB_DP_OTGO GND(A) GND(A) GND(A) USB_DM USB_DM GND(A) USB_VSUB USB_VSUB GND(A) USB_DP USB_DP GND(A) GND(A) HN-338 HN-339 JK-77 BOARD NO. 1-875-337-11 BOARD NO. 1-875-345-11 BOARD NO. 1-875-320-11 PMW-EX1_HN-338_11F_1 PMW-EX1_HN-339_11F_1 PMW-EX1_JK-77_11F_1 8-46 8-46 PMW-EX1...

  • Page 183: Ksw-53

    SW_REC_SS GND(A) XLR(C)2 Zoom SW_ZOOMTELE SW_ZOOM_T +5V(A) GND(A) Module +5V(A) SW_ZOOMWIDE SW_AUCH1EXT_A SW_ZOOM_W +5V(A) LINE1_SW SW_AUCH1EXT_B +5V(A) +48V_1_SW SW_AUCH2EXT_A GND(A) LINE2_SW SW_AUCH2EXT_B GND(A) +48V_2_SW GND(A) GND(A) GND(A) 16 17 GND(A) KSW-53 GND(A) GND(A) BOARD NO. 1-875-324-11 PMW-EX1_KSW-53_11F_1 8-47 8-47 PMW-EX1...

  • Page 184: Le-346

    LED_DA LED_ON/OFF CN11 FL11 NSCW455AT-TY5 220uF PSIG RN4983FE(TPLR3) GND1 GND2 FL12 220uF HEADPHONE 1.8k GND1 GND2 NJM2125F(TE2) 100pF 100k 2SC3326N-TE85L-AB 0.0022uF 0.0022uF MAZT082H08S0 CHASSIS-GND 2SC3326N-TE85L-AB 6.8k HN1B04FE-Y/GR(TPLR3) LE-346 LED-465 BOARD NO. 1-875-336-11 BOARD NO. 1-875-333-11 PMW-EX1_LE-346_11F_1 PMW-EX1_LED-465_11F_1 8-48 8-48 PMW-EX1...

  • Page 185: Ma-161

    100k 2SD2216J-QR(TX).SO 2SC2713G-TE85L 2SC2713G-TE85L 220k 2.2k 220k 2.2k 2.2k 2.2k 2.2k 330k 10uF -EM_R(R) 330k 2SC2713G-TE85L +EM_R(R) 0.047uF +EM_F(R) 0.047uF 470pF -EM_F(R) 470pF 100k 330k 2.2k 330k 470pF 470pF 100k Int MIC MA-161 BOARD NO. 1-875-321-11 PMW-EX1_MA-161_11F_1 8-49 8-49 PMW-EX1...
  • Page 186 8-50 8-50 PMW-EX1...

  • Page 187: Re-250

    C306 C307 C319 C320 C322 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF CL303 IC301 (2/2) IC305 (2/2) IC309 (2/2) TC7SH08FU(T5RSOYJF) TC7SH08FU(T5RSOYJF) TC7SH00FU(T5RSOYJF) IC304 (2/2) IC306 (2/2) IC310 (2/2) TC7SH08FU(T5RSOYJF) TC7SH32FU(T5RSOYJF) TC7SH08FU(T5RSOYJF) RE-250 (1/3) BOARD NO. 1-875-244-12 PMW-EX1_RE-250_12A_1 8-51 8-51 PMW-EX1...
  • Page 188 R141 R142 R145 R147 R149 R150 100k IC22 (2/3) H:ERROR NJM2903V(TE2) OPEN:NO ERROR DTA144EE-TL IC22 (1/3) 2SC4617TL-QR NJM2903V(TE2) R140 R164 4.7k R143 0.22uF R144 R146 R148 003-H9 H_START_UP 4.7uF 6.3V DTC114TE-TL DTC114TE-TL DTC114TE-TL 003-L5 ME_EN 001-M7,003-H9 H_SHUTDOWN 8-52 8-52 PMW-EX1...
  • Page 189 P-GND OUTGND2 POWERGOOD OUT2_D 0.01uF SOFTSTART2 10uF 150uF OUT2_U INV2 10uF 6.3V 8 7 6 5 SB05-05C-TB-E 8.2uH 100k +3.1V 003-B5 0.022uF FDS6690A 0.0068uF S-GND 6.8k DTC114TE-TL 1SS400TE-61 1SS400TE-61 1SS400TE-61 1SS400TE-61 RE-250 (2/3) BOARD NO. 1-875-244-12 PMW-EX1_RE-250_12A_2 8-53 8-53 PMW-EX1...
  • Page 190 H_START_UP H_START_UP +1.2V_SY Q227 Q225 D218 DTA144EE-TL 001-B7,002-T9,003-B10,003-L6 SI7114DN-T1-E3 1SS400TE-61 R229 R230 DOWN_DET_SY 002-R4,003-L4 C218 C216 0.1uF 10uF SW_SY_1P2V 6.3V C236 R224 R265 Q229 0.1uF 220k DTC114TE-TL RE-250 (3/3) Q238 Q239 2SC4617TL-QR DTC144EE-TL BOARD NO. 1-875-244-12 PMW-EX1_RE-250_12A_3 8-54 8-54 PMW-EX1...

  • Page 191: Re-251

    H:ERROR REF_+2.5V DTA144EE-TL MM1431ANRE OPEN:NO ERROR REF 4 H_SHUTDOWN 002-M5 (1/3) 2SC4617TL-QR 0.001uF NJM2903V(TE2) 100k 0.22uF 002-M5,003-C4 H_START_UP 4.7uF 6.3V 0.1uF IC7 (3/3) DTC114TE-TL NJM2903V(TE2) DTC114TE-TL DTC114TE-TL 003-M5 SY_EN 001-M4,002-G4,002-M4 DOWN_DET_SY RE-251 (1/3) BOARD NO. 1-875-245-12 PMW-EX1_RE-251_12A_1 8-55 8-55 PMW-EX1...
  • Page 192 +13.5V_DP 470k SW_DP_13P5V +13.5V_DP +13.5V_DP Q118 DTC114TE-TL UNREG_IM UNREG_IM UNREG_IM UNREG_IM SWD_UNREG 001-C8,002-M5,003-C1 SWD_UNREG SWD_UNREG UNREG_DP UNREG_DP Q100 SI2307BDS-T1 UNREG_IM SWD_UNREG C121 R100 470k R121 SW_IM_UNREG 470k Q101 DTC114TE-TL PWR_SW 001-C7,003-M4 RE-251 (2/3) BOARD NO. 1-875-245-12 PMW-EX1_RE-251_12A_2 8-56 8-56 PMW-EX1...
  • Page 193 R1021 R1022 002-I3 MLN_IIC BAT_IIC 002-M3 EVER_2.5V R1134 R1135 R1080 R1081 RB1000 002-I2 SW_PWR_A 002-I2 SW_PWR_B 002-I2 SW_BATINFO 002-I2 SW_INT E1000 002-M5 DC/BATT_DET H:Battery L:EXT_DC 002-M5 BATT_DET H:Battery nashi L:Battery ari RE-251 (3/3) BOARD NO. 1-875-245-12 PMW-EX1_RE-251_12A_3 8-57 8-57 PMW-EX1...
  • Page 194 8-58 8-58 PMW-EX1...

  • Page 195: Rm-213

    R600 2.2k 2.2k SW_JOG_MENU SW_EXCHANGE +2.5V R400 +2.5V 2.2k SW_JOG_PUSH SW_JOG_PUSH ASW-65 SW_JOG_PUSH SW_JOG_MENU SW_JOG_MENU R401 R402 2.2k 2.2k SW_EXCHANGE SW_EXCHANGE JOGA_A JOGA_A JOGA_B JOGA_B JOG SW 400- 500- 600- Menu Mem_chg SW-1397 BOARD NO. 1-875-344-11 PMW-EX1_SW-1397_11F_1 8-59 8-59 PMW-EX1...

  • Page 196: Swc-47

    2.2k SW_GAIN_B 2.2k SW_ZEBRA SW_GAIN_A R303 2.2k GAIN SW 300- +2.5V Plug CN101 +2.5V +2.5V I2C_SCL I2C_SDA RTC_MEAS SW_SY_BATINFO SW_BATTERY_INFO/DISPLAY RTC_VDD SW_AWB SW_AWB SW_SHUTTER_A SW_FRSHUT_A SW_SHUTTER_B SW_FRSHUT_B AU-313 SW_ASSIGN4 SW_ASSIGN4 FRONT AUDIO AMP RESERVED_A1 RESERVED_A2 EZ+ZEBRA 200- 8-60 8-60 PMW-EX1...
  • Page 197 1SS302-TE85L 1SS302-TE85L STATUS BACK LIGHT S507 S503 R505 R512 2.2k 2.2k SW_BACKLIGHT SW_STATUS D509 1SS302-TE85L BARS/CAM S508 R513 2.2k SW_OUTPUT DISPLAY/BAT INFO S509 D510 R514 2.2k MAZT082H08S0 400- 500- ASSIGN DISPLAY SHOT_TRANS SWC-47 BOARD NO. 1-875-340-11 PMW-EX1_SWC-47_11F_1 8-61 8-61 PMW-EX1...

  • Page 198: Tx-115

    TC7SZ125FU(TE85R) JTAG_TMS JTAG_TMS JTAG_TCK JTAG_TCK JTAG_TDI JTAG_TDI JTAG_TDO JTAG_TDO JTAG R103 R104 100k 100k IC101 (2/2) IC103 (2/2) IC102 (2/2) TC7SZ125FU(TE85R) TC7SZ125FU(TE85R) TC7SZ125FU(TE85R) +2.5V_IN FB100 C104 C106 C107 0.1uF 0.1uF 0.1uF TX-115 (1/7) BOARD NO. 1-875-331-11 PMW-EX1_TX-115_11F_1 8-62 8-62 PMW-EX1...
  • Page 199 FB212 VTRXPAD7 VTRXPAD18 NC(TM) R217 C200 C203 L203 0.22uF 0.22uF R233 4.7nH FB202 GNDA7 GNDA18 C201 C202 CN201 R228 C214 0.22uF 0.22uF FB206 4.7uF SD/ HD 2 3 4 SDI_DIS_L R232 TX-115 (2/7) BOARD NO. 1-875-331-11 PMW-EX1_TX-115_11F_2 8-63 8-63 PMW-EX1...
  • Page 200 (3/3) IC304 (3/3) IC305 (2/2) IC306 (2/2) IC309 (2/2) TC74VHC221AFT(EKJ) NJU7043RB1(TE2) TC7SZ125FU(TE85R) TC7SZ125FU(TE85R) TC7SZ32FU(TE85R) +3.3V_PLL L306 10uH C323 C333 C324 C322 10uF C328 C332 10uF C345 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF TX-115 (3/7) BOARD NO. 1-875-331-11 PMW-EX1_TX-115_11F_3 8-64 8-64 PMW-EX1...
  • Page 201 IO_L06P_5/VRN_5 IO_L69N_1/VREF_1_2 IO_L07N_5/VREF_5_2 IO_L06N_1 IO_L69P_5 IO_L02N_1 IO_L06N_5/VRP_5 IO_L01N_1/VRP_1 IO_L69N_5/VREF_5_3 IO_L01P_1/VRN_1 IO_L69P_1 IO_L07N_1 IO_L06P_1 IO_L09N_1/VREF_1_3 IO_L09P_1 +3.3V_COP +2.5V_COP VCCO_1_1 VCCO_5_1 C406 C402 VCCO_1_2 VCCO_5_2 0.1uF 0.1uF C407 C403 VCCO_1_3 VCCO_5_3 0.1uF 0.1uF TX-115 (4/7) BOARD NO. 1-875-331-11 PMW-EX1_TX-115_11F_4 8-65 8-65 PMW-EX1...
  • Page 202 IO_L01P_6/VRN_6 IO_L88N_7/VREF_7_2 +3.3V_COP IO_L03P_6 IO_L86P_7 D502 NM SD/ HD IO_L02P_6 IO_L90P_7 CL-196YG-CD-T R502 SC-COPRO 3/6 +3.3V_COP +3.3V_COP VCCO_6_1 VCCO_7_1 C500 C502 VCCO_6_2 VCCO_7_2 0.1uF 0.1uF C501 VCCO_6_3 VCCO_7_3 C503 0.1uF 0.1uF TX-115 (5/7) BOARD NO. 1-875-331-11 PMW-EX1_TX-115_11F_5 8-66 8-66 PMW-EX1...
  • Page 203 IO_L74N_4/GCLK3S DP_O_SDI_CLK GND19 GND20 R657 GND21 IO_L74P_5/GCLK4P O_CAM_AU_64FS GND22 IO_L75P_0/GCLK4S CL611 R658 GND23 IO_L75N_0/GCLK5P CL612 GND24 IO_L74N_5/GCLK5S O_GLK_SCLK CL613 R659 GND25 IO_L75P_5/GCLK6P GND26 IO_L74P_0/GCLK6S CLK74M_PLL CL614 GND27 IO_L74N_0/GCLK7P CL615 GND28 IO_L75N_5/GCLK7S TX-115 (6/7) BOARD NO. 1-875-331-11 PMW-EX1_TX-115_11F_6 8-67 8-67 PMW-EX1...
  • Page 204 4.7uH VIN1 R711 R701 VIN2 C711 C708 001,007 SDI_DWN_H 0.022uF 22uF R712 IC701 (1/2) MODE 680k TC7SZ04FU(TE85R) R702 R704 SYNC GND1 GND2 C705 10uF R713 R714 R703 R705 470k C703 4.7uF TX-115 (7/7) BOARD NO. 1-875-331-11 PMW-EX1_TX-115_11F_7 8-68 8-68 PMW-EX1...

  • Page 205: Frame Wiring

    DC-DC converter B Harness SUB Fine-wire coaxial (DPR289-TX115) (DPR-TX) Micro Computer RE-251 Micro computer Harness SUB CN700 CN100 Harness (DC143-RE250) Insede SW Assign SWC-47 HD-SDI TX-115 CN200 DC-143 Battery CN Display Short_trans DC-IN Coaxial cable Frame Wiring SDI OUT 8-69 8-69 PMW-EX1...
  • Page 207 Index Board Name Page ASW-65 AU-313 AXM-35 BI-202 BI-203 BI-204 BP-43 CN-3006 CN-3007 DC-143 DET-44 DPR-289 DR-621 EC-62 HN-318 HN-319 HN-320 HN-338 HN-339 JK-77 KSW-53 LE-346 LED-465 MA-161 RE-250 9-10 RE-251 9-10 RM-213 SW-1375 SW-1397 SWC-47 9-11 TX-115 9-11 PMW-EX1...
  • Page 208 CN102 R122 S105 C135 Q105 R110 R166 R259 CN103 R123 S106 C136 Q106 R111 R203 R260 R124 C137 D101 Q107 R112 R204 R261 D100 R125 C138 D102 Q108 R113 R205 R262 D101 R126 C203 D103 Q109 R114 R206 R263 PMW-EX1...
  • Page 209 CL11 BI-203 CL12 -B SIDE- CL13 CL12 CL14 CL11 CL14 SUFFIX: -11 BI-202 -A SIDE- SUFFIX: -11 --------------------- BI-203 (1-875-553-11) --------------------- *:B SIDE CL10 R31 R32 CL12 CL14 CL11 BI-202 -B SIDE- CL10 CL11 SUFFIX: -11 CL12 CL13 CL14 PMW-EX1...
  • Page 210 CL12 CL14 CL11 CN-3006 CN-3006 -A SIDE- -B SIDE- SUFFIX: -11 SUFFIX: -11 BI-204 -B SIDE- --------------------- SUFFIX: -11 BI-204 (1-875-554-11) --------------------- *:B SIDE CL10 CL11 CL12 CL13 CL14 CN-3007 CN-3007 -A SIDE- -B SIDE- SUFFIX: -11 SUFFIX: -11 PMW-EX1...
  • Page 211 C1117 C1528 C1638 CN101 C324 SUFFIX: -13 C325 C553 C735 C935 C1200 C1529 C1639 CN102 C554 C736 C936 C1201 C1530 C1644 CN400 C326 C555 C737 C937 C1202 C1531 C1646 CN401 C327 C556 C738 C938 C1203 C1532 C1647 CN402 C328 PMW-EX1...
  • Page 212 R802 R1110 R1322 R1616 RB901 FB903 IC700 Q303 R317 R442 R550 R803 R1112 R1323 R1622 RB902 FB1000 *B1 IC701 Q500 R318 R443 R552 R804 R1113 R1324 R1623 RB903 FB1100 IC800 Q501 R319 R444 R553 R809 R1114 R1326 R1627 RB904 PMW-EX1...
  • Page 213 SUFFIX: -11, 12 HN-319 -A SIDE- SUFFIX: -11 EC-62 -B SIDE- SUFFIX: -11, 12 HN-319 -B SIDE- SUFFIX: -11 HN-320 -A SIDE- SUFFIX: -11 HN-318 HN-318 -A SIDE- -B SIDE- SUFFIX: -11 SUFFIX: -11 HN-320 -B SIDE- SUFFIX: -11 PMW-EX1...
  • Page 214 R126 D105 R127 D106 R128 D107 R129 D108 R130 D109 D110 S100 D111 S101 D112 S102 D113 S103 HN-339 -B SIDE- D114 S104 S105 SUFFIX: -11 HA001 S106 S107 KSW-53 HB001 S108 -B SIDE- S109 IC100 S110 SUFFIX: -11 PMW-EX1...
  • Page 215 SUFFIX: -11 SUFFIX: -11 VDR11 VDR12 --------------------- MA-161 (1-875-321-11) --------------------- *:B SIDE MA-161 MA-161 R500 -A SIDE- -B SIDE- D500 SUFFIX: -11 SUFFIX: -11 D401 R401 D400 R400 D402 SW-1397 SW-1397 -A SIDE- -B SIDE- SUFFIX: -11 SUFFIX: -11 PMW-EX1...
  • Page 216 Q212 R236 RB1005 *A3 C233 Q213 R237 RB1006 C234 C235 IC10 Q214 R238 IC11 Q215 R239 C236 IC12 Q216 R240 C237 C238 IC13 Q217 R241 IC14 Q218 R242 C239 IC17 Q219 R243 C300 IC18 Q220 R244 C301 9-10 9-10 PMW-EX1...
  • Page 217 R300 R620 D300 R206 R508 C403 CL504 IC302 R301 R630 D301 R207 R509 R208 R510 C404 CL505 IC304 R302 R631 D302 C405 CL506 IC305 R303 R643 D303 R209 R511 C406 CL507 IC306 R304 R645 D400 R210 R512 9-11 9-11 PMW-EX1...
  • Page 220 Printed in Japan Sony Corporation 2008. 3 16 PMW-EX1 (UC, E, CE, CN) E ©2007 9-968-400-02...

Table of Contents