Table of Contents
Advertisement
19
19
20
24
24
25
26
27
27
27
28
28
30
Limited Warranty
Maintenance Notes
31
Customer Installation Record Form
32
Part 1 - General Safety Information
33
33
This boiler is approved for indoor installations only and is not
33
intended for use as a pool heater. Clearance to combustible
33
materials: 0" top, bottom, sides, and back. Left side has all
33
boiler mechanical connections. Boiler must have room for
34
service: 24" front is minimum recommended service clearance.
34
(A combustible door or removable panel is acceptable front
34
clearance.) This boiler has been approved for closet installation
34
and installation on combustible flooring. Do not install directly on
34
carpeting. Install the boiler in a location where temperature and
35
pressure relief valve discharge or a leak will not result in damage
35
to the surrounding area. If such a location is not available, install
35
an auxiliary catch pan. Use only Category IV vent systems.
35
35
Installer - Read all instructions in this manual before installing.
38
Perform steps in the given order.
38
39
User - This manual is for use only by a qualified heating installer /
40
service technician. Have this boiler serviced / inspected annually
41
by a qualified service technician.
41
FAILURE TO ADHERE TO THE GUIDELINES ON THIS PAGE
41
CAN RESULT IN SUBSTANTIAL PROPERTY DAMAGE,
41
SEVERE PERSONAL INJURY, OR DEATH.
42
NOTE: If the boiler is exposed to the following, do not operate.
42
Immediately call a qualified service technician.
42
1. Fire
42
2. Damage
43
3. Water
43
Failure to follow this information could result in property
43
damage, severe personal injury, or death.
43
DO NOT USE THIS BOILER IF ANY PART HAS BEEN
44
SUBMERGED IN WATER. Immediately call a qualified
44
service technician. The boiler MUST BE replaced if it has been
44
submerged. Attempting to operate a boiler that has been
44
submerged could create numerous harmful conditions, such as
45
a potential gas leakage causing a fire and/or explosion, or the
45
release of mold, bacteria, or other harmful particulates into
46
the air. Operating a previously submerged boiler could result in
46
property damage, severe personal injury, or death.
49
NOTE: Boiler damage due to flood or submersion is considered
49
an Act of God, and IS NOT covered under product warranty.
49
52
5
53
53
53
53
53
54
60
60
60
60
61
66
66
70
72
73
WHL-052 Rev. 4.28.16
Advertisement
Table of Contents
