Electric Rider Battery Replacement Check List - Cub Cadet RZT-S Zero Shop Manual

ELECTRIC RIDER BATTERY REPLACEMENT CHECK LIST

Dealer number _____________
Model number_____________________
NOTE: An Authorization is required from Cub Cadet before the batteries can be replaced under warranty. This
check list must be performed prior to calling Cub Cadet for an authorization number and returned with the
old batteries. The battery pack is not considered bad until they fall below 30 AH (50% of the 1 hour rat-
ing).
NOTE: The battery charger must be evaluated with the mower for warranty authorization.
NOTE: Detailed battery testing instructions can be found in the RZT-S Zero Shop Manual form # 769-08008.
Date batteries were installed ______________
Customer Complaint __________________________________________________________________________
Grass Height _________________
Type of grass _________________
Run time per charge ____________
_____ Test run the mower
_____ Check the VCM for fault codes
_____ Repair any fault codes found
_____ Connect the mower's charger to the mower
NOTE: The customer's charger must be used in
this step to rule out a bad charger
_____ Inspect the fuses
_____ Check/adjust the brake gap
_____ Connect the charger to an approved AC power
source
Battery Position
Front
Middle
Left rear
Right rear
Authorization number _________________ Technician's signature _____________________________________
Technician_____________________________
Serial number__________________________
Battery serial number
Inspection Date_________
Prior to testing the batteries were:
completely discharged Y N
How many hours did the charger
_____ run and could not complete a charge
Check for any charger trouble codes (refer
_____ to back of sheet for trouble codes)
_____ Inspect the mowing blades
NOTE: Dull blades will greatly reduce run
time while mowing
_____ Inspect all battery connections
_____ Ambient air temperature
Capacity/Discharge tester used make/model
_____________________________________
Amp Hour reading from tester ______________
Battery code
Hours __________
fully charged Y N