Removing And Installing Rear Vent Warm Air And Cold Air Flap Control Motor (Left-Side/Right- Side); Removing And Installing Rear Vent Warm Air And Cold Air Flap Control Motor (Left-Side/Right-Side) - Audi A8 2003 Workshop Manual

Audi A8 2003 ➤
General body repairs, interior - Edition 07.2011
Vehicles with 4-zone climate control
– Unplug electrical connectors at rear left ( -V220- ) -4- and rear right ( -V221- ) -5- vent warm air and cold
air flap control motors.
– Unplug electrical connectors at rear left ( -G311- ) -7- and rear right ( -G312- ) -6- centre console tem‐
perature sensors.
All vehicles (continued)
– Unscrew bolts -2- (4x).
– Take out centre console air distributor -3-.
♦ Installing
Install in reverse order of removal. Observe the following:
– Observe correct assignment when plugging in connectors at rear left ( -V220- ) -4- and rear right ( -V221- )
-5- vent warm air and cold air flap control motors.
– Observe correct assignment when plugging in connectors at rear left ( -G311- ) -7- and rear right ( -
G312- ) -6- centre console temperature sensors.
4 - Rear left vent warm air and cold air flap control motor -V220-
❑ For 2 and 4-zone climate control
❑ Removing and installing ⇒ Rep. gr. 87
5 - Rear right vent warm air and cold air flap control motor -V221-
❑ For 4-zone climate control
❑ Removing and installing ⇒ Rep. gr. 87
6 - Rear right centre console temperature sensor -G312-
❑ For 4-zone climate control
❑ Removing and installing ⇒ Rep. gr. 87
7 - Rear left centre console temperature sensor -G311-
❑ For 4-zone climate control
❑ Removing and installing ⇒ Rep. gr. 87
8 - Bolts (2x), 2 Nm
9 - Bolts (2x), 2 Nm
10 - Rear air duct (left-side)
♦ Removing
– Remove centre console
– Unscrew bolts -8- (2x).
– Pull rear left air duct out of centre console air distributor -3-.
♦ Installing
Install in reverse order of removal.
11 - Rear air duct (right-side)
♦ Removing
– Remove centre console
– Unscrew bolts -9- (2x).
– Pull rear right air duct out of centre console air distributor -3-.
♦ Installing
Install in reverse order of removal.
2.23 Removing and installing rear vent warm
air and cold air flap control motor (left-
side/right-side)
♦ Removing and installing rear left vent warm air and cold air
flap control motor -V220- ⇒ Rep. gr. 87
46
Rep. gr.68 - Interior equipment
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
⇒ page 19 .
⇒ page 19 .