Kenwood reserves the right to make changes to any otherwise, for any purpose without the prior written products herein at any time for improvement purposes.
(iii) The first local oscillator for the band B (UHF) 1. Frequency Confi guration reception. The TM-V71A/V71E has an individual VCO and PLL unit The PLL reference frequency is generated by a 12.8MHz for both band A and band B. Using these separate VCO and (band A) and a 16.8MHz (band B) crystal oscillator connected...
TM-V71A/V71E CIRCUIT DESCRIPTION 2-2. Band B VHF Receiver Circuit 2. Receiver System The incoming signal from the antenna passes through 2-1. Band A VHF Receiver Circuit a filter circuit and goes to the RF amplifier (Q293). The The incoming signal from the antenna passes through amplifi...
Page 5
TM-V71A/V71E CIRCUIT DESCRIPTION X486 45.505MHz D164,165 RF AMP D378,379 D375,376 RF AMP D370,371 D367,368 D364,365 MIXER IF AMP L377 L375 L370 L368 L366 2nd Local OSC D187,189 Q363 Q362 Q361 XF486 Q495 FM IC Band A IC486 45.05MHz IC667 Wide...
Page 7
TM-V71A/V71E CIRCUIT DESCRIPTION 3-4. Overheating Protection Circuit is amplified by Q70 and goes to the PLL IC (IC66). The pulse-swallow type PLL IC divides the input VCO oscillator To protect thermal destruction of the power modules frequency using the data from the MPU (IC918). It compares...
Page 8
TM-V71A/V71E CIRCUIT DESCRIPTION 5-3. Serial Control 6. AF Signal System The MPU (IC918) controls the panel section (Display unit 6-1. Beep Circuit and Mute Circuit X54-359) through synchronous serial communications. A beep sound is generated by the MPU (IC918) and goes to cross point switch (IC806).
Page 9
TM-V71A/V71E CIRCUIT DESCRIPTION 6-3. Microphone Key Input limiting filter. For 9600bps GMSK for example, compared ■ When the MC-59 (Supplied microphone) is used to 4800Hz signals (nearly sine wave signals passed through a fi lter), the signals have a hissing sound like digital The pulse is output from the CM terminal of the MPU to modulation when listened to by ear.
Page 10
TM-V71A/V71E CIRCUIT DESCRIPTION 7-2. Reception Signals 8-2. Key, Encoder, Volume Input Circuit PR9 is the 9600bps data communications reception Circuits to operate the panel section keys are connected output. It sends the FM detection circuit output (RD signals) to each microprocessor port. The POWER key is pulled up through a buffer amplifi...
TM-V71A/V71E SEMICONDUCTOR DATA Main MPU: 3062LFGPUKBVB: K Pin No. Port Name Function 3062LFGPUKBWB: E,M4 SQC (PNL) O Internal TNC SQC output (TX-RX (Control) unit (D/6) IC918) Serial data for DAC (M62364) and CNT_DT cross point switch Pin No. Port Name...
Page 12
TM-V71A/V71E SEMICONDUCTOR DATA Shift Register: BU2099FV (TX-RX unit (A/6) IC576) Pin No. Port Name Function PKD input switching (PKD (PNL) or Port Active PKD_SEL Pin name I/O Function PKD (EXT)) name level Wide/Narrow switching H (Narrow) L:VHF TX, H:UHF TX (V/U switching)
Page 13
TM-V71A/V71E SEMICONDUCTOR DATA Electorical Volume IC: M62364FP-F Panel MPU: 3062LFGPUKBZA (TX-RX (Control) unit (D/6) IC804) (Display unit IC903) Pin No. Pin name Function Pin No. Port Name I/O Function VIN1 B band balance adjustment input KEY4 [CALL] key input VOUT1 B band balance adjustment output...
TM-V71A/V71E SEMICONDUCTOR DATA Pin No. Port Name I/O Function Pin No. Port Name I/O Function 63~67 NC Not used (GND) 79~90 NC Not used (GND) LCD_DT_2 O LCD driver 2 data VOL_B AF VOL (Band B) A/D input LCD_CLK_2 O LCD driver 2 CLK...
Page 15
TM-V71A/V71E COMPONENTS DESCRIPTION Ref. No. Use / Function Operation / Condition / Compatibility Ref. No. Use / Function Operation / Condition / Compatibility Q0: Wide/Narrow select for B band Amplifi er Local amplifi er for A band Q1: VU_Select for B band A band PLL f-in fi...
Page 16
TM-V71A/V71E COMPONENTS DESCRIPTION Ref. No. Use / Function Operation / Condition / Compatibility Ref. No. Use / Function Operation / Condition / Compatibility Ceramic fi lter select (On when FM- Q588 Switching 8TUA switch (On when A band UHF TX)
Page 17
TM-V71A/V71E COMPONENTS DESCRIPTION Ref. No. Use / Function Operation / Condition / Compatibility Ref. No. Use / Function Operation / Condition / Compatibility Reverse current D186 Switching RF switch A band PLL unlock signal prevention D187 Switching RF switch Voltage shift...
Page 18
TM-V71A/V71E COMPONENTS DESCRIPTION Ref. No. Use / Function Operation / Condition / Compatibility Ref. No. Use / Function Operation / Condition / Compatibility Local signal switch D609 Limiter Prevention from over level input D407,408 Switching (on when B band UHF RX)
TM-V71A/V71E TERMINAL FUNCTION DISPLAY UNIT (X54-3590-00) Pin No. Name Function Pin No. Name Function No connection CN902 DATA O Data signal output for VGS-1 O CLK for VGS-1 SW5V Switched 5V O Enable signal for VGS-1 KEY11 O Volume key signal (A band)
Page 20
TM-V71A/V71E TERMINAL FUNCTION Pin No. Name Function Pin No. Name Function O Squelch control output DET_A O A band detect signal output TX-RX UNIT (X57-731X-XX) (B,E/6): VCO A Section PR (PNL) O PR detect signal output for panel DET_B O B band detect signal output Pin No.
Page 21
TM-V71A/V71E TERMINAL FUNCTION Pin No. Name Function Pin No. Name Function B_PLLEN O Enable signal for B band PLL (IC66) No connection TR_DT O Data Switched 8V TR_CLK O Clock No connection 2099_EN O Enable signal for shift register (IC576)
TM-V71A/V71E PARTS LIST CAPACITORS 2 2 0 • Capacitor value CC45 Color* 010 = 1pF 0 = 22pF 1 = Type ... ceramic, electrolytic, etc. 4 = Voltage rating 100 = 10pF 2 = Shape ... round, square, etc. 5 = Value...
Page 23
Les articles non mentionnes dans le Parts No. ne sont pas fournis. Y : AAFES (Europe) X : Australia M : Oth er Areas Teile ohne Parts No. werden nicht geliefert. TM-V71A/V71E (Y51-513X-XX) DISPLAY UNIT (X54-3590-00) Desti- Desti- Ref. No.
Page 24
TM-V71A/V71E PARTS LIST DISPLAY UNIT (X54-3590-00) TX-RX UNIT (X57-731X-XX) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation CP905 RK75HA1J473J CHIP-COM 47K 1/16W TX-RX UNIT (X57-731X-XX) 0-11: K 0-21: M4 2-71: E...
Page 25
TM-V71A/V71E PARTS LIST TX-RX UNIT (X57-731X-XX) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation CK73GB1H104K CHIP C 0.10UF C164 CK73HB1H471K CHIP C 470PF C76,77 CK73HB1H102K CHIP C 1000PF...
Page 26
TM-V71A/V71E PARTS LIST TX-RX UNIT (X57-731X-XX) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation C236 CK73HB1H102K CHIP C 1000PF C383 CC73HCH1H1R5B CHIP C 1.5PF C237 CK73HB1A104K CHIP C 0.10UF...
Page 27
TM-V71A/V71E PARTS LIST TX-RX UNIT (X57-731X-XX) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation C486 CK73HB1A104K CHIP C 0.10UF C602,603 CK73GB1H104K CHIP C 0.10UF C487 CK73HB1H391K CHIP C...
Page 28
TM-V71A/V71E PARTS LIST TX-RX UNIT (X57-731X-XX) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation C716 CK73HB1E103K CHIP C 0.010UF C826 CK73HB1A104K CHIP C 0.10UF C717 CC73HCH1H390J CHIP C...
Page 29
TM-V71A/V71E PARTS LIST TX-RX UNIT (X57-731X-XX) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation ✽ C916 CK73HB1A104K CHIP C 0.10UF CN702 E40-6770-05 PIN ASSY C917,918 CK73HB1H102K CHIP C...
Page 30
TM-V71A/V71E PARTS LIST TX-RX UNIT (X57-731X-XX) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation ✽ L234 L41-3385-14 SMALL FIXED INDUCTOR (330NH) L417 L41-2288-03 SMALL FIXED INDUCTOR (220NH) L236,237...
Page 31
TM-V71A/V71E PARTS LIST TX-RX UNIT (X57-731X-XX) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation CP576 RK74HB1J102J CHIP-COM 1.0K 1/16W R54,55 RK73HB1J222J CHIP R 2.2K 1/16W CP577-579 RK74HB1J472J CHIP-COM 4.7K...
Page 32
TM-V71A/V71E PARTS LIST TX-RX UNIT (X57-731X-XX) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation R161 RK73HB1J222J CHIP R 2.2K 1/16W R264 RK73HB1J000J CHIP R 1/16W R162 RK73HB1J122J CHIP R 1.2K...
Page 33
TM-V71A/V71E PARTS LIST TX-RX UNIT (X57-731X-XX) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation R380 RK73HB1J391J CHIP R 1/16W R470 RK73HB1J333J CHIP R 1/16W R381 RK73HB1J330J CHIP R...
Page 34
TM-V71A/V71E PARTS LIST TX-RX UNIT (X57-731X-XX) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation R558 RK73HB1J220J CHIP R 1/16W R696 RK73HB1J000J CHIP R 1/16W R559,560 RK73HB1J124J CHIP R...
Page 35
TM-V71A/V71E PARTS LIST TX-RX UNIT (X57-731X-XX) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation R825 RK73HB1J822J CHIP R 8.2K 1/16W R927 RK73HB1J473J CHIP R 1/16W R826 RK73HB1J473J CHIP R...
Page 36
TM-V71A/V71E PARTS LIST TX-RX UNIT (X57-731X-XX) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation D163 EDZ5.1B ZENER DIODE D701 HSC277 DIODE D164,165 L407CDB DIODE (50V/1W) D703-705 1SV325F VARIABLE CAPACITANCE DIODE...
Page 37
TM-V71A/V71E PARTS LIST TX-RX UNIT (X57-731X-XX) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation Q68,69 2SC4617(R) TRANSISTOR Q751,752 DTC114YE DIGITAL TRANSISTOR 2SC5636 TRANSISTOR Q753 ✽ SSM6L05FU-F DTC144EE DIGITAL TRANSISTOR...
TM-V71A/V71E ADJUSTMENT Measuring Equipment for Alignment Preparation 1. Digital voltmeter (D.V.M) • Set the controls and switches to the positions listed below unless otherwise specifi ed. Input impedance: High 2. RF valve voltmeter (RF V.M) BAND SEL/ VOL (Band A) control Fully counterclockwise Input impedance: 1MΩ...
Page 41
TM-V71A/V71E ADJUSTMENT ■ Rear panel ■ DATA connector pin assignment E (GND) q ANT e PC Terminals e and y are short circuited. w DATA r SP (SP1/SP2) e PKS (SEND switch for DATA terminal) Connect PTT output. If PKS is set to ”GND”, data are sent and the microphone will be mute.
Page 42
TM-V71A/V71E ADJUSTMENT 4) Check the PTT signal operation. 16. BPF RSSI (Band B) (144MHz band, 200MHz band, q Input 5 to 10 V to pin 2 of the transceiver PC terminal 430MHz band)*1 or pin 7 of the PG-5H D-SUB terminal (CTS).
Page 43
TM-V71A/V71E ADJUSTMENT ■ Panel key operation in the adjustment mode ■ Example of the adjustment mode operation procedure The operating procedure when the BPF RSSI of band A Key name Function (430MHz band, low frequency) is adjusted is described as Changes the adjustment item or adjustment follows.
Page 44
TM-V71A/V71E ADJUSTMENT ■ Adjustment item, adjustment band item, display and the frequency that is set to the transceiver The frequency that is set to Display the transceiver Adjustment item Adjustment band item Signaling Adjustment Adjustment K type E, M4 types...
Page 45
TM-V71A/V71E ADJUSTMENT The frequency that is set to Display the transceiver Adjustment item Adjustment band item Signaling Adjustment Adjustment K type E, M4 types item band item 144MHz band, Low frequency BPF A 118.050MHz 118.050MHz 144MHz band, Center frequency BPF A 145.050MHz...
Page 46
TM-V71A/V71E ADJUSTMENT The frequency that is set to Display the transceiver Adjustment item Adjustment band item Signaling Adjustment Adjustment K type E, M4 types item band item 144MHz band SQT B 145.050MHz 145.050MHz 200MHz band SQT B 220.050MHz 220.050MHz Squelch tight...
Page 47
TM-V71A/V71E ADJUSTMENT Common Section Measurement Adjustment Item Condition Specifi cations / Remarks Test- Unit Terminal Unit Parts Method equipment 1.Setting 1) Power supply voltage DC power supply terminal : 13.8V 2. All LCD 1) All LCD segments light check Confi rm that all LCD segments light.
Page 48
TM-V71A/V71E ADJUSTMENT Measurement Adjustment Item Condition Specifi cations / Remarks Test- Unit Terminal Unit Parts Method equipment 6. SWR 1) Adj item: [SWR V] Power meter Rear Front Tuning Set the following protection Adjust: [ panel panel control adjustment values...
Page 49
TM-V71A/V71E ADJUSTMENT Measurement Adjustment Item Condition Specifi cations / Remarks Test- Unit Terminal Unit Parts Method equipment 11. CTCSS 1) Adj item: [CT A V] Linear Rear Front Tuning Write 0.75kHz±0.05kHz deviation Adjust: [ detector panel panel control (Band A)
Page 50
TM-V71A/V71E ADJUSTMENT Measurement Adjustment Item Condition Specifi cations / Remarks Test- Unit Terminal Unit Parts Method equipment • Band B 8) Frequency: 144.000MHz Power meter Rear Check 47~53W 9) Frequency: 145.000MHz E,M4 Ammeter panel 12A or less Frequency: 146.000MHz K 10) Frequency: 145.990MHz E,M4...
Page 51
TM-V71A/V71E ADJUSTMENT Measurement Adjustment Item Condition Specifi cations / Remarks Test- Unit Terminal Unit Parts Method equipment 18. MIC 1) Frequency: 145.000MHz E,M4 Linear Rear Check ±2.34~4.17kHz K,M4 sensitivity Frequency: 146.000MHz K detector panel ±2.38~4.05kHz E Check AG: 1kHz/5mV K,M4 Oscilloscope •...
Page 52
TM-V71A/V71E ADJUSTMENT Measurement Adjustment Item Condition Specifi cations / Remarks Test- Unit Terminal Unit Parts Method equipment • Band B 5) Frequency: 145.000MHz E,M4 Linear Rear Check 0.65~0.85kHz Frequency: 146.000MHz K detector panel Detector: +P HOLD Oscilloscope LPF: 3kHz HPF: OFF...
Page 53
TM-V71A/V71E ADJUSTMENT Measurement Adjustment Item Condition Specifi cations / Remarks Test- Unit Terminal Unit Parts Method equipment 2. BPF RSSI 1) Adj item: [BPF B VL] → Rear Front Tuning Turn the Tuning (Band B) [BPF B VC] → [BPF B VH]...
Page 54
TM-V71A/V71E ADJUSTMENT Measurement Adjustment Item Condition Specifi cations / Remarks Test- Unit Terminal Unit Parts Method equipment 5. Squelch 1) Adj item: [SQT A V] Rear Front Tuning Write tight Adjust: [ panel panel control (Band A) SSG output: –119dBm (0.25µV)
Page 55
TM-V71A/V71E ADJUSTMENT Measurement Adjustment Item Condition Specifi cations / Remarks Test- Unit Terminal Unit Parts Method equipment 8 .S-meter S1 1) Adj item: [SM1 B V] Rear Front Tuning Write (Band B) Adjust: [ panel panel control Writing SSG output: –118dBm (0.28µV) •...
Page 56
TM-V71A/V71E ADJUSTMENT Measurement Adjustment Item Condition Specifi cations / Remarks Test- Unit Terminal Unit Parts Method equipment 11. AF distortion 1) Frequency: 145.250MHz E,M4 Rear Check 4% or less Check Frequency: 146.250MHz K Oscilloscope panel EXT.SP • Band A SSG output: –53dBm (501µV)
Page 57
TM-V71A/V71E ADJUSTMENT Measurement Adjustment Item Condition Specifi cations / Remarks Test- Unit Terminal Unit Parts Method equipment • Band B 16) Frequency: 145.250MHz E,M4 Rear Check 12dB SINAD or more (Wide) Frequency: 146.250MHz K panel EXT.SP SSG output: –122dBm (0.178µV)
Page 58
TM-V71A/V71E ADJUSTMENT Measurement Adjustment Item Condition Specifi cations / Remarks Test- Unit Terminal Unit Parts Method equipment 3) Frequency: 435.000MHz E,M4 Frequency: 444.000MHz K Oscilloscope SSG output: –53dBm (501µV) Distortion AF V.M: 0dB meter AF V.M 4) SSG DEV: OFF Check –43dB or less...
Page 59
TM-V71A/V71E ADJUSTMENT Measurement Adjustment Item Condition Specifi cations / Remarks Test- Unit Terminal Unit Parts Method equipment • 430MHz band 7) Frequency: 435.250MHz E,M4 Rear Check SQL knob (Band B) position: Frequency: 444.250MHz K Oscilloscope panel EXT.SP 8:00~11:00 SSG output: OFF BUSY icon disappear.
TM-V71A/V71E LEVEL DIAGRAM Receiver Section Center Frequency 45.05MHz 455kHz AF (1kHz) –123dBm –121dBm –109.5dBm –105dBm –110dBm 155mVrms D134,135 D186,188 XF486 A Band IC486 FM IC Q228 Q227 Q226 A Band VHF Receiver circuit 1st Local Wide Narrow 49.95MHz 450kHz AF (1kHz) –121dBm...
TM-V71A/V71E SPECIFICATIONS TM-V71A TM-V71E TM-V71A General K Type E Type M4 Type 144~148MHz 144~146MHz Guaranteed range Band A & B TX & RX 438~450MHz 430~440MHz Band A 118 ~ 524MHz – Frequency range 136~524MHz – Band B 800~1300MHz (excluding cellular band) –...
Page 92
Unit 3712-3724, Level 37, Tower one Metroplaza, 223 Hing Fong Road, Bp 58416 Villepinte, 95944 Roissy Ch De Gaulle Cedex Kwai Fong, N.T., Hong Kong KENWOOD House, Dwight Road, Watford, Herts., 1 Ang Mo Kio Street 63, Singapore 569110 WD18 9EB United Kingdom...
Page 93
TM-V71A/V71E TM-V71A/V71E PC BOARD PC BOARD DISPLAY UNIT (X54-3590-00) (A/3, B/3, C/3) Component side view (J79-0140-09) DISPLAY UNIT (X54-3590-00) (A/3, B/3, C/3) Component side view (J79-0140-09) J79-0140-09 A/3 ED903 S902 S911 POWER D960 D959 D958 D957 D956 D955 D966 D965...
Page 94
TM-V71A/V71E TM-V71A/V71E PC BOARD PC BOARD DISPLAY UNIT (X54-3590-00) (A/3, B/3, C/3) Foil side view (J79-0140-09) DISPLAY UNIT (X54-3590-00) (A/3, B/3, C/3) Foil side view (J79-0140-09) J79-0140-09 A/3 D989 D921 IC902 R955 Q905 IC904 IC905 CP908 Q903 R905 D920 IC907...
Page 95
TM-V71A/V71E TM-V71A/V71E PC BOARD PC BOARD J79-0142-19 A/6 TX-RX UNIT TX-RX UNIT (X57-731X-XX)(A/6): (X57-731X-XX)(A/6): R647 TX-RX SECTION TX-RX SECTION C660 VGS-1 0-11 : K 0-21 : M4 2-71 : E 0-11 : K 0-21 : M4 2-71 : E CN677...
Page 96
TM-V71A/V71E TM-V71A/V71E PC BOARD PC BOARD J79-0142-19 A/6 TX-RX UNIT TX-RX UNIT (X57-731X-XX)(A/6): (X57-731X-XX)(A/6): C633 C634 R635 R636 TX-RX SECTION TX-RX SECTION C608 C611 C609 0-11 : K 0-21 : M4 2-71 : E 0-11 : K 0-21 : M4 2-71 : E...
Page 97
TM-V71A/V71E TM-V71A/V71E PC BOARD PC BOARD TX-RX UNIT (X57-731X-XX) (D/6) : CONTROL SECTION TX-RX UNIT (X57-731X-XX) (D/6) : CONTROL SECTION 0-11 : K 0-21 : M4 2-71 : E Component side view (J79-0142-19 D/6) 0-11 : K 0-21 : M4 2-71 : E Component side view (J79-0142-19 D/6)
Page 98
TM-V71A/V71E TM-V71A/V71E PC BOARD PC BOARD TX-RX UNIT (X57-731X-XX) (D/6) : CONTROL SECTION TX-RX UNIT (X57-731X-XX) (D/6) : CONTROL SECTION 0-11 : K 0-21 : M4 2-71 : E Foil side view (J79-0142-19 D/6) 0-11 : K 0-21 : M4 2-71 : E Foil side view (J79-0142-19 D/6)