User Manuals: Dettson Chinook C30-M-S Gas Furnace

Manuals and User Guides for Dettson Chinook C30-M-S Gas Furnace. We have 5 Dettson Chinook C30-M-S Gas Furnace manuals available for free PDF download: Installation Manual And Owner's Manual, Installation Instructions And Homeowner's Manual

Dettson Chinook C30-M-S Installation Manual And Owner's Manual (76 pages)

High efficiency modulating and multiposition condensing gas furnace

Brand: Dettson | Category: Furnace | Size: 1 MB

Dettson Chinook C30-M-S Installation Manual And Owner's Manual (65 pages)

High efficiency modulating and multiposition condensing gas furnace

Brand: Dettson | Category: Furnace | Size: 3 MB

Dettson Chinook C30-M-S Installation Instructions And Homeowner's Manual (56 pages)

GAS FIRED FURNACE

Brand: Dettson | Category: Furnace | Size: 25 MB

Table of Contents
2
1 Safety

4
2 Introduction

7
3 Alizé Cooling Unit

10
4 Installation

10
- Upflow
  11
  - Right Side Condensate Drain Trap Connection
    11
  - Left Side Condensate Drain Trap Connection
    11
- Downflow
  12
- Horizontal Right
  12
- Horizontal Left
  12
- Venting Drainage
  13
- Multiposition Pressure Switch Connection
  13
5 Duct Installation

17
- General Requirements
  17
- Smart Duct System
  17
- Return Air Connections
  17
  - Bottom Return
    17
  - Side Return
    17
- Supply Air Ducts
  17
  - Ductwork Acoutiscal Treatment
    17
6 Gas Supply and Piping

18
- General
  18
- Propane Conversion
  18
- Gas Pipe Grommet
  18
- Setting Gas Pressure
  18
7 Electrical Wiring

19
- Wiring
  19
- Table 2: Maximum Capacity of Pipe Cu.ft./Hr for Pipe Length Ft (M)
  19
- Table 3: Inlet Gas Pressure
  19
- Wiring
  20
- Thermostat
  20
- Alternate Power Supply
  20
- Table 4: Electrical Data
  20
- Table 5: Thermostat Choice VS System
  20
8 Venting and Combustion Air Piping

21
9 Start Up, Adjustement and Safety Check

32
- To Start Furnace
  32
  - Lighting Instruction
    32
- Unit Operation Hazard
  32
- Setup Switches
  32
- Normal Operation
  33
- Fault Code Reset
  33
- Diagnostique Features
  33
- Sequence of Operation
  33
- Setting Input Rate
  33
10 Stat and Controls

34
- Non-Communicating Modulating Thermostat
  34
- Thermostat Input
  34
- Fuse
  34
- Vac Terminals
  34
  - Electronic Air Cleaner EAC (E103)
    34
  - HUM Terminal
    34
- Stepper Gas Valve Control
  35
- Connector 15-Pins
  35
- Ecm Motor Connection
  35
- Communications L.e.D
  35
- Memory Card
  35
- Replacing Furnace Control
  35
- Dip Switch
  35
  - Heat Adjust
    36
  - Cooling Airflow Select
    36
  - Heat Rise Adjust
    36
  - Continuous Fan Speed
    36
  - Furnace Test Mode
    36
11 User'sinformation Manual

37
- What to Do if You Smell Gas
  39
- Operating Your Furnace
  39
- Lighting Instruction
  39
12 Fault Codes

39
- H - no Modulation
  40
- Furnace Lock-Out
  40
- Failed Ignition
  41
- Low Flame Sense
  41
- Flame Lost
  41
- Unexpected Flame
  42
- Igniter Fail
  42
- Main High Limit Open
  42
- Line Neutral Reverse
  42
- Control Board Fuse Blown
  42
- MRLC (Manual Reset Limit Control Open)
  42
- Low Pressure Control Switch Closed
  43
- Low Pressure Control Switch Open
  43
- Low Pressure Control Switch Open 2
  44
- High Pressure Control Switch Close
  44
- High Pressure Control Switch Open
  44
- No Blower Communication
  45
- No Inducer Communication
  45
- No Gas Valve Feedback
  45
- Control Fault
  45
13 Unit Commissioning and Startup Checklist

46
Part List

52
- Table 17: Parts List
  54
- Table 18: Parts List MS
  55

Dettson Chinook C30-M-S Installation Instructions And Homeowner's Manual (46 pages)

MODULATING GAS FURNACE MULTIPOSITION

Brand: Dettson | Category: Furnace | Size: 21 MB

Table of Contents
2
Safety
4
Safety Labeling and Warning Signs
4
Important Information
4
Safety Consideration
5
Detection Systems
6
Danger of Freezing
6
Introduction
7
Codes and Standards
7
Table 1: Codes and Standards
7
Electrostatic Discharge
8
Location
8
Clearance and Accessibility
8
Location Relative to Cooling Equipement
8
Installation
8
Upflow
8
Table 2: Minimum Clearance
8
Right Side Condensate Drain Trap Connection
9
Left Side Condensate Drain Trap Connection
9
Downflow
10
Downflow Condensate Drain Trap Connection
10
Downflow Multiposition Pressure Switch Connection
10
Horizontal Right
11
Horizontal Right Condensate Drain Trap Connection
11
Horizontal Right Multiposition
12
Pressure Switch Connection
12
Horizontal Left
12
Horizontal Left Condensate Drain Trap Connection
12
Alternate Drain Trap Location in Horizontal Left Position
13
Horizontal Left Multiposition
13
Pressure Switch Connection
13
Multiposition Venting Drainage
13
Duct Installation
13
General Requirements
13
Duct External Static Pressure
14
Smart Duct System
14
Return Air Connections
14
Bottom Return
14
Side Return
14
Table 3: Suggested Return Size
14
Supply Air Ducts
15
Ductwork Acoutiscal Treatment
15
Gas Supply and Piping
15
General
15
Propane Conversion
15
Gas Pipe Grommet
15
Setting Gas Pressure
16
Table 4: Inlet Gas Pressure
16
Table 5: Outlet Gas Pressure
16
Table 6: Maximum Capacity of Pipe Cu.ft./Hr for Pipe Length Ft (M)
16
Electrical Connection
17
120V Wiring
17
Wiring
17
Thermostat
17
Non-Communicating Modulating
17
One-Stage or Two-Stage Thermostat
17
Thermostat Input
17
Table 7: OPERATION with SINGLE
17
Operation with Single Stage T-Stat
17
Table 8: THERMOSTAT TYPE SELECTION
17
Alternate Power Supply
18
Table 10: Electrical Data
18
Table 11: Thermostat Choice VS System
18
Venting and Combustion Air Piping
20
General
20
Vent/Exhaust Blockage Due to Ice Build up
20
Direct Vent
21
Non Direct Vent
21
Special Venting Requirements for Installation in Canada
21
Material
21
Size the Vent and Combustion Air Pipes
21
Table 12: Approved Vent and Combustion Air Pipe Material USA Installation
21
Exhaust Pipe Connection to Furnace
22
Table 13: Maximum Equivalent Vent Length (Ft) for Modulating Units and Altitude up to 4500 Ft
22
Table 14: Deduction for Fittings
22
Combustion Air Pipe Connection
23
Vent Termination
23
Concentric Vent
24
Two Pipe Termination
24
Start Up, Adjustement and Safety Check
29
To Start Furnace
29
Lighting Instruction
29
Unit Operation Hazard
29
Normal Operation
29
Fault Code Reset
29
Diagnostic Features
29
Sequence of Operation
30
Setting Input Rate
30
Controls
31
Fuse
31
120 Vac Terminals
31
Electronic Air Cleaner EAC (E103)
31
HUM Terminal
31
Stepper Gas Valve Control
31
Connector 15-Pins
31
Ecm Motor Connection
31
Communications L.e.D
31
Memory Card
32
Replacing Furnace Control
32
Dip Switch
32
Heat Adjust
32
Cooling Airflow Select
32
Heat Rise Adjust
32
Table 15: Air Flow Adjustement - S1
32
Table 16: Cooling Airflow Adjust
32
Continuous Fan Speed
33
Furnace Test Mode
33
Table 17: Heat Rise
33
Table 18: Continuous Fan Selection
33
Table 19: Test Mode
33
User'sinformation Manual
35
What to Do if You Smell Gas
35
Operating Your Furnace
35
Lighting Instruction
35
Table 20: Fault Code
37
Unit Commissioning and Startup Checklist
39
Table 21: Legacy Cooling Airflow
40
Table 22: Specifications
40
Table 23: Specifications for -MS
41
Part List
43
Table 24: Part List CXX-M-V
45
Table 25: Part List CXX-M-S
46

Dettson Chinook C30-M-S Installation Instructions And Homeowner's Manual (61 pages)

MODULATING GAS FURNACE MULTIPOSITION

Brand: Dettson | Category: Furnace | Size: 25 MB

Table of Contents
2
1 Safety

8
- Safety Labeling and Warning Signs
  8
- Important Information
  8
- Detection Systems
  11
- Danger of Freezing
  11
2 Introduction

11
- Codes and Standards
  12
  - Safety
    12
  - General Installation
    12
  - Combustion and and Air Ventilation
    12
  - Duct Systems
    12
  - Acoustical Lining and Fibrous Glass Duct
    12
  - Gas Piping and Pipe Pressure Testing
    12
  - Electrical Connections
    12
- Electrostatic Discharge
  12
- Location
  13
  - Location Relative to Cooling Equipement
    13
  - Table 1: Minimum Clearance
    13
3 Alizé Cooling Unit

14
4 Installation

14
- Upflow
  15
  - Right Side Condensate Drain Trap Connection
    15
  - Left Side Condensate Drain Trap Connection
    15
- Downflow
  16
- Horizontal Right
  16
- Horizontal Left
  16
- Venting Drainage
  17
- Multiposition Pressure Switch Connection
  17
5 Duct Installation

18
- General Requirements
  18
- Smart Duct System
  19
- Return Air Connections
  19
- Bottom Return
  19
- Side Return
  19
- Supply Air Ducts
  19
  - Ductwork Acoutiscal Treatment
    19
6 Gas Supply and Piping

20
- General
  20
- Propane Conversion
  20
- Gas Pipe Grommet
  21
- Setting Gas Pressure
  21
- Table 2: Maximum Capacity of Pipe Cu.ft./Hr for Pipe Length Ft (M)
  23
- Table 3: Inlet Gas Pressure
  23
7 Electrical Wiring

25
- 120V Wiring
  25
- Wiring
  25
- Thermostat
  25
- Alternate Power Supply
  25
- Table 4: Electrical Data
  26
- Table 5: Thermostat Choice VS System
  26
8 Venting and Combustion Air Piping

28
9 Start Up, Adjustement and Safety Check

34
- To Start Furnace
  34
  - Lighting Instruction
    34
- Unit Operation Hazard
  34
- Setup Switches
  34
- Normal Operation
  35
- Fault Code Reset
  35
- Diagnostique Features
  35
- Sequence of Operation
  35
- Setting Input Rate
  35
10 Thermostat and Controls

36

Dettson Categories

Furnace Boiler

Air Conditioner Thermostat Air Handlers

More Dettson Manuals

User Manuals: Dettson Chinook C30-M-S Gas Furnace

Dettson Chinook C30-M-S Installation Manual And Owner's Manual (76 pages)

Table of Contents

1 Safety Regulation

2 Introduction

3 Alizé Cooling Unit

4 Installation

5 Duct Installation

6 Gas Piping

7 Electrical Connections

8 Venting and Combustion Air Piping

9 Start Up, Adjustment and Safety Check

10 Thermostat

11 User's Information Manual

Dettson Chinook C30-M-S Installation Manual And Owner's Manual (65 pages)

Table of Contents

1 Safety Regulation

2 Introduction

3 Combustion Air and Ventilation

4 Installation

5 Duct Installation

6 Gas Piping

7 Electrical Connections

8 Venting

9 Start Up, Adjustment and Safety Check

10 Thermostat

11 User's Information Manual

Dettson Chinook C30-M-S Installation Instructions And Homeowner's Manual (56 pages)

Table of Contents

1 Safety

2 Introduction

3 Alizé Cooling Unit

4 Installation

5 Duct Installation

6 Gas Supply and Piping

7 Electrical Wiring

8 Venting and Combustion Air Piping

9 Start Up, Adjustement and Safety Check

10 Stat and Controls

11 User'sinformation Manual

12 Fault Codes

13 Unit Commissioning and Startup Checklist

Part List

Dettson Chinook C30-M-S Installation Instructions And Homeowner's Manual (46 pages)

Table of Contents

Dettson Chinook C30-M-S Installation Instructions And Homeowner's Manual (61 pages)

Table of Contents

1 Safety

2 Introduction

3 Alizé Cooling Unit

4 Installation

5 Duct Installation

6 Gas Supply and Piping

7 Electrical Wiring

8 Venting and Combustion Air Piping

9 Start Up, Adjustement and Safety Check

10 Thermostat and Controls

Related Products

Dettson Categories