Dettson CC15-M-V Manuals

Manuals and User Guides for Dettson CC15-M-V. We have 3 Dettson CC15-M-V manuals available for free PDF download: Installation Instructions And Homeowner's Manual

Dettson CC15-M-V Installation Instructions And Homeowner's Manual (60 pages)

GAS FIRED FURNACE

Brand: Dettson | Category: Furnace | Size: 19 MB

Table of Contents
2
1 Safety

4
2 Introduction

7
3 Alizé Cooling Unit

9
4 Installation

10
- Upflow
  11
  - Uplow Condensate Drain Connection
    11
- Downflow
  12
  - Downflow Condensate Drain Connection
    12
- Horizontal
  13
  - Horizontal Condensate Drain Connection
    13
- Venting Drainage
  14
- Multiposition Pressure Switch Connection
  14
5 Duct Installation

23
- General Requirements
  23
- Smart Duct System
  23
- Return Air Connections
  23
- Supply Air Ducts
  23
  - Ductwork Acoutiscal Treatment
    23
6 Gas Supply and Piping

23
- General
  23
- Setting Gas Pressure
  24
- Propane Conversion
  24
- Gas Pipe Grommet
  25
7 Electrical Wiring

25
8 Venting and Combustion Air Piping

27
9 Start Up, Adjustement and Safety Check

34
- To Start Furnace
  34
  - Lighting Instruction
    34
- Unit Operation Hazard
  34
- Setup Switches
  34
- Normal Operation
  35
- Fault Code Reset
  35
- Diagnostique Features
  35
- Sequence of Operation
  35
- Setting Input Rate
  35
10 Thermostat and Controls

36
- Non-Communicating Modulating Thermostat
  36
- Thermostat Input
  36
- Fuse
  36
- Vac Terminals
  36
  - Electronic Air Cleaner EAC (E103)
    36
  - HUM Terminal
    36
- Stepper Gas Valve Control
  36
- Connector 15-Pins
  37
- ECM Motor Connection
  37
- Communications L.e.D
  37
- Memory Card
  37
- Replacing Furnace Control
  37
- Dip Switch
  37
- Heat Adjust
  38
- Cooling Airflow Select
  38
- Heat Rise Adjust
  38
- Continuous Fan Speed
  38
  - Furnace Test Mode
    38
11 User'sinformation Manual

38
- What to Do if You Smell Gas
  39
- Operating Your Furnace
  40
- Lighting Instruction
  40
12 Fault Codes 12.1 D1

40
- H - no Modulation
  41
- Furnace Lock-Out
  41
- Failed Ignition
  41
- Low Flame Sense
  42
- Flame Lost
  42
- Unexpected Flame
  42
- Igniter Fail
  43
- Main High Limit Open
  43
- Line Neutral Reverse
  43
- Control Board Fuse Blown
  43
- MRLC (Manual Reset Limit Control Open)
  43
- Low Pressure Control Switch Closed
  44
- Low Pressure Control Switch Open
  44
- Low Pressure Control Switch Open 2
  44
- High Pressure Control Switch Close
  45
- High Pressure Control Switch Open
  45
- No Blower Communication
  45
- No Inducer Communication
  46
- No Gas Valve Feedback
  46
- Control Fault
  46
- Table 10: Air Flow Adjustement - S1
  47
- Table 11: Cooling Airflow Demand
  48
- Table 12: Cooling Airflow Adjust
  48
- Table 13: Heat Rise - Test Mode
  49
- Table 14: Dehumidification
  49
- Table 15: Normal Operation Codes
  49
13 Commisionning Check List and Furnace Info

50
- Table 16: CFM Table
  51
- Table 17: Specification Table
  51
14 Part List

52
- Table 18: Part List Chinook Compact
  55
- Table 19: Part List Continued
  56
15 Notes

57

Dettson CC15-M-V Installation Instructions And Homeowner's Manual (53 pages)

GAS FIRED FURNACE

Brand: Dettson | Category: Furnace | Size: 14 MB

Table of Contents
2
1 Safety

8
- Safety Labeling and Warning Signs
  8
- Important Information
  8
- Detection Systems
  10
- Danger of Freezing
  11
2 Introduction

11
- Codes and Standards
  11
  - Safety
    11
  - General Installation
    11
  - Combustion and and Air Ventilation
    12
  - Duct Systems
    12
  - Acoustical Lining and Fibrous Glass Duct
    12
  - Gas Piping and Pipe Pressure Testing
    12
  - Electrical Connections
    12
- Electrostatic Discharge
  12
- Location
  12
  - Location Relative to Cooling Equipement
    13
  - Table 1: Minimum Clearance
    13
3 Alizé Cooling Unit

14
4 Installation

16
- Upflow
  16
  - Condensate Drain Connection
    16
- Downflow
  16
- Horizontal
  17
  - Condensate Drain Connection
    17
- Venting Drainage
  17
- Multiposition Pressure Switch Connection
  17
5 Duct Installation

22
- General Requirements
  22
- Smart Duct System
  22
  - Return Air Connections
    22
  - Supply Air Ducts
    22
    
    Ductwork Acoutiscal Treatment
    22
6 Gas Supply and Piping

23
7 Electrical Wiring

27
- 120V Wiring
  27
- Wiring
  27
- Thermostat
  27
- Alternate Power Supply
  27
- Table 5: Electrical Data
  27
- Table 6: Thermostat Choice VS System
  28
- Figure 13: Wiring Diagram
  29
8 Venting and Combustion Air Piping

30
9 Start Up, Adjustement and Safety Check

35
- To Start Furnace
  35
  - Lighting Instruction
    35
- Unit Operation Hazard
  35
- Setup Switches
  35
- Normal Operation
  36
- Fault Code Reset
  36
- Diagnostique Features
  36
- Sequence of Operation
  36
- Setting Input Rate
  36
10 Thermostat and Controls

37
- Connector 15-Pins
  38
- Dip Switch
  39
11 User's Information Manual

41
- What to Do if You Smell Gas que Faire si Vous Sentez du Gaz
  41
12 Fault Codes

42
- Solutions
  43
- Failed Ignition
  44
- Causes
  45
- Line Neutral Reverse
  46
  - Causes
    47
- High Pressure Control Switch Close
  48
13 Information

51

Dettson CC15-M-V Installation Instructions And Homeowner's Manual (40 pages)

GAS FIRED FURNACE

Brand: Dettson | Category: Furnace | Size: 14 MB

Table of Contents
2
Safety
4
Safety Labeling and Warning Signs
4
Important Information
4
Safety Consideration
4
Detection Systems
6
Danger of Freezing
6
Introduction
7
Codes and Standards
7
Table 1: Codes and Standards
7
Electrostatic Discharge
8
Location
8
Location Relative to Cooling Equipement
8
Alizé Cooling Unit
8
Position of the Interface Board - Alize System
8
Installation
8
Table 2: Minimum Clearance
8
Upflow
9
Uplow Condensate Drain Connection
9
Downflow
10
Downflow Condensate Drain Connection
10
Horizontal
11
Horizontal Condensate Drain Connection
11
Venting Drainage
12
Multiposition Pressure Switch Connection
12
Duct Installation
13
General Requirements
13
Duct External Static Pressure
13
Smart Duct System
14
Return Air Connections
14
Supply Air Ducts
14
Ductwork Acoutiscal Treatment
14
Gas Supply and Piping
14
General
14
Setting Gas Pressure
14
Propane Conversion
15
Gas Pipe Grommet
15
Table 3: Inlet Gas Pressure
15
Table 4: Outlet Gas Pressure
15
Table 5: Maximum Capacity of Pipe Cu.ft./Hr for Pipe Length Ft (M)
15
Electrical Connection
16
120V Wiring
16
Wiring
16
Thermostat
16
Non-Communicating Modulating, One-Stage or Two-Stage Thermostat
16
Thermostat Input
16
Table 6: OPERATION with SINGLE STAGE T- STAT
16
Table 7: THERMOSTAT TYPE SELECTION
16
Alternate Power Supply
17
Table 8: Electrical Data
17
Table 9: Thermostat Choice VS System
17
Venting and Combustion Air Piping
19
General
19
Direct Vent
19
Non Direct Vent
19
Special Venting Requirements for Installation in Canada
19
Material
20
Size de Vent and Combustion Air Pipes
20
Connecting to Furnace
20
Table 10: Maximum Equivalent Vent Length (Ft) for
20
Table 11: Deduction for Fittings
20
Combustion Air
21
Vent Termination
21
Concentric Vent
21
Two Pipe Termination
22
Start Up, Adjustment and Safety Check
25
To Start Furnace
25
Lighting Instruction
25
Unit Operation Hazard
25
Setup Switches
25
Normal Operation
25
Fault Code Reset
26
Diagnostique Features
26
Sequence of Operation
26
Setting Input Rate
26
120 Vac Terminals
26
Electronic Air Cleaner EAC (E103)
26
HUM Terminal
26
Communications L.e.D
26
Memory Card
27
Replacing Furnace Control
27
Dip Switch
27
CFM Heat Adjust
27
Cooling Airflow Select
27
Table 12: Heating Airflow Adjustment - S1
27
Table 13: Cooling Airflow Adjustement
27
Table 14: Cooling Airflow % Adjustement
27
Heat Rise Adjust
28
Continuous Fan Speed
28
Furnace Test Mode
28
User'sinformation Manual
28
Table 15: Heat Rise Adjust
28
Table 16: Test Mode
28
What to Do if You Smell Gas
29
Operating Your Furnace
29
Table 17: Fault Code
30
Commisionning Check List and Furnace Info
32
Table 18: Specification Table
33
Part List
34
Table 19: Part List Chinook Compact
36
Table 20: Part List Continued
37
Notes
38

Dettson Categories

Furnace Boiler

Air Conditioner Thermostat Heat Pump

More Dettson Manuals

Dettson CC15-M-V Manuals

Dettson CC15-M-V Installation Instructions And Homeowner's Manual (60 pages)

Table of Contents

1 Safety

2 Introduction

3 Alizé Cooling Unit

4 Installation

5 Duct Installation

6 Gas Supply and Piping

7 Electrical Wiring

8 Venting and Combustion Air Piping

9 Start Up, Adjustement and Safety Check

10 Thermostat and Controls

11 User'sinformation Manual

12 Fault Codes 12.1 D1

13 Commisionning Check List and Furnace Info

14 Part List

15 Notes

Dettson CC15-M-V Installation Instructions And Homeowner's Manual (53 pages)

Table of Contents

1 Safety

2 Introduction

3 Alizé Cooling Unit

4 Installation

5 Duct Installation

6 Gas Supply and Piping

7 Electrical Wiring

8 Venting and Combustion Air Piping

9 Start Up, Adjustement and Safety Check

10 Thermostat and Controls

11 User's Information Manual

12 Fault Codes

13 Information

Dettson CC15-M-V Installation Instructions And Homeowner's Manual (40 pages)

Table of Contents

Related Products

Dettson Categories