Camus Hydronics DynaMax DMH801 Manuals

Manuals and User Guides for Camus Hydronics DynaMax DMH801. We have 3 Camus Hydronics DynaMax DMH801 manuals available for free PDF download: Installation, Operation And Service Manual, Installation And Service Manual

Camus Hydronics DynaMax DMH801 Installation, Operation And Service Manual (93 pages)

DynaMax SERIES GAS FIRED WALL HUNG & FLOOR MOUNT RESIDENTIAL COMMERCIAL STAINLESS STEEL BOILERS

Brand: Camus Hydronics | Category: Boiler | Size: 8 MB

Table of Contents
3
Part 1 General Information
6
Introduction
6
Special Instructions to Owner
6
Checking Equipment
6
Display Unit
6
Sequence of Operation
6
Heat Transfer Process
6
End of Sequence
7
Installation Codes
7
Warranty
7
Removal of Existing Appliance
7
Boiler/Furnace Room Operating Condition
8
Location of Unit
8
Clearance from Combustible Material
9
Part 2 Air Inlet and Venting
13
General Venting Guide
13
Category IV Venting
13
Approved Venting Materials Category IV
13
Category II Venting
14
Approved Venting Materials Category II
14
Combined Combustion Air Inlet
14
Vent Termination and Air Inlet Clearances
15
Sidewall Venting
15
Sidewall Air Inlet
15
Sidewall Concentric Vent/Air
16
Vertical Direct Venting
16
Part 3 Gas Connection
18
Gas Connection
18
Gas Piping
18
Install Piping
18
Checking Gas Supply Pressure
18
HIGH and LOW GAS PRESSURE SWITCHES (Optional)
19
3.6 Air/Gas Ratio Valve
19
Burner
19
Part 4 Water Connection
20
Freeze Protection Outdoor Installation
20
Warning Regarding Chilled Water Systems
21
Inlet and Outlet Connections
21
Minimum Pipe Size Requirements
21
Heat Exchanger
21
Low Water Temperature Systems
21
Piping Arrangements
21
Field Supplied Components
21
FLOW PROVING DEVICE (Wall Mount Models and Combination Models Only)
23
WATER FLOW SWITCH (Floor Mount Hydronic and DHW Models Only)
23
LOW WATER CUTOFF (if Equipped)
23
Relief Valve
23
DHW TUNING VALVE (Combination Models Only)
23
Part 5 Electrical & Controls
24
Electrical Conections
24
High Limit
24
Dynamax Controller
24
Service Parts
24
Ignition Module Lockout Functions
24
Manual Reset Codes
25
Automatic Reset Codes
25
Error Table
25
Part 6 Control Panel
26
Dynamax Controller
26
Setting the Dynamax Controller
26
Central Heating Modes
26
Domestic Hot Water Modes
27
Part 7 Components
28
7.1 Direct Spark Igniter
28
Flame Sensor
28
7.3 Combustion Air Fan
28
7.4 Gas Valve
28
7.5 Outer Jacket
28
Part 8 Labvision Software
29
Installing Labvision Driver on Windows Xp
29
Installing Labvision Driver on Windows 7
29
Starting up Lab Vision
29
Adjusting Fan Speeds
30
Labvision Central Heating
31
Central Heating Mode, Installer Level
31
Central Heating Mode = 1, 2, 3 Installer Level
32
Labvision Domestic Hot Water
32
DHW Mode = 0, Installer Level
32
DHW Mode 1, 2 Installer Level
32
DHW Mode 4, Installer Level
33
Labvision Cascade
34
Data Logging
35
Procedure for Viewing Log Files in Microsoft® Excel
36
Analysis of Microsoft® Excel Log File
36
Error History
37
Part 9 Dynamax Control Panel
38
Dynamax Control Panel
38
Introduction to the Dynamax Control Panel
39
Menu Screen
40
System Monitor Display
41
Display Options Display
42
Central Heating Display
43
9.6 Domestic Hot Water Display
44
Cascade Control
46
Boiler Control
47
Error Screen
47
Part 10 Troubleshooting
48
Setting the Correct Combustion
58
Gas Valve Adjustment Procedure
58
Part 11 Maintenance
60
Examine the Venting System
60
Visually Check Main Burner Flames
60
Cleaning Boiler Heat Exchanger
60
Condensate Treatment
61
Igniter and Flame Sensor Electrodes
61
Check Igniter Ground Wiring
61
Burner Maintenance
61
Burner Removal and Cleaning
61
Freeze Protection for Indoor & Outdoor Installations
62
Removal of Combustion Chamber Lining
62
Combustion and Ventilation Air
62
Gas Valve Voltage
62
Combustible Materials
62
FREEZE PROTECTION for a HEATING BOILER SYSTEM (Optional)
63
Part 12 Installations
63
Checking the Installation
63
Checking the Construction
63
Heating Boiler Installations
63
Inspect & Recharge Condensate Collection/Neutralizing Reservoir
64
Water Connections
64
Piping Lengths
64
Summary
64
Domestic Hot Water with Storage Tank
65
Domestic Hot Water with Plate Heat Exchanger
65
Temperature Rise at Full Firing Rate
65
Setting the Correct Combustion
66
Cascade Setup
66
INTERFACE MODULE (if Equipped)
68
Write Functionality
71
12.14.1 Write CH Setpoint
71
12.14.2 Write DHW Setpoint
71
Alarm Output (if Equipped)
72
External Reset (if Equipped)
72
0-10Vdc External Input (if Equipped)
72
Appliance
72
Ignition Cycle
73
Part 13 Piping Diagrams
74
Part 14 Exploded View & Parts List
79
Part 15 Electrical Diagrams
87
DM 80- 250 Internal Wiring Diagram (Wall Hung Models)
87
DM 210-299 Internal Wiring Diagram (Floor Mount Models)
88
848IF Interface Module Wiring Schematic
89
Field Wiring
90
System Sensor
90
Cascade Setup
90
Detailed Connector Description
91

Camus Hydronics DynaMax DMH801 Installation And Service Manual (84 pages)

Gas Fired Residential Commercial Stainless Steel Boilers

Brand: Camus Hydronics | Category: Boiler | Size: 3 MB

Table of Contents
3
Part 1 General Information
5
Introduction
5
Special Instructions to Owner
5
Checking Equipment
5
Display Unit
5
Sequence of Operation
5
Heat Transfer Process
5
End of Sequence
6
Installation Codes
6
Warranty
6
Removal of Existing Appliance
6
Boiler/Furnace Room Operating Condition
7
1.10 Location of Unit
7
Clearance from Combustible Material
8
Part 2 Air Inlet and Venting
12
General Venting Guide
12
Category IV Venting
12
Approved Venting Materials Category IV
13
Category II Venting
14
Approved Venting Materials Category II
14
Combined Combustion Air Inlet
14
Vent Termination and Air Inlet Clearances
14
Sidewall Venting
14
Sidewall Air Inlet
15
Sidewall Concentric Vent/Air
15
Vertical Direct Venting
16
Sidewall Clearance Specifications
18
Part 3 Gas Connection
20
Gas Connection
20
Gas Piping
20
Install Piping
20
Checking Gas Supply Pressure
20
HIGH and LOW GAS PRESSURE SWITCHES (Optional)
21
Air/Gas Ratio Valve
21
Burner
21
Part 4 Water Connection
22
Freeze Protection Outdoor Installation
22
Warning Regarding Chilled Water Systems
23
Inlet and Outlet Connections
23
Minimum Pipe Size Requirements
23
Heat Exchanger
23
Low Water Temperature Systems
23
Piping Arrangements
23
Field Supplied Components
23
FLOW PROVING DEVICE (Wall Mount Models and Combination Models Only)
25
WATER FLOW SWITCH (Floor Mount Hydronic and DHW Models Only)
25
LOW WATER CUTOFF (if Equipped)
25
Relief Valve
26
DHW TUNING VALVE (Combination Models Only)
26
Part 5 Electrical & Controls
26
Electrical Conections
26
High Limit
27
Dynamax Hs Controller
27
Service Parts
27
Ignition Module Lockout Functions
27
Error Table
27
Manual Reset Codes
27
Automatic Reset Codes
28
Part 6 Control Panel
28
Dynamax Hs Controller
28
Setting the Dynamax Hs Controller
28
Central Heat Programming Instructions
31
Domestic Hot Water Programming Instructions
34
Lead Lag Programming Instructions
37
Additional Boiler Parameter Instructions
41
Boiler Setup Programming Instructions
43
Part 7 Components
45
7.1 Direct Spark Igniter
45
Flame Sensor
45
7.3 Combustion Air Fan
45
7.4 Gas Valve
45
7.5 Outer Jacket
45
Part 8 Troubleshooting
46
Setting the Correct Combustion
55
Gas Valve Adjustment Procedure
55
Part 9 Maintenance
57
Examine the Venting System
57
Visually Check Main Burner Flames
57
Cleaning Boiler Heat Exchanger
57
Condensate Treatment
58
Igniter and Flame Sensor Electrodes
58
Check Igniter Ground Wiring
59
Burner Maintenance
59
Burner Removal and Cleaning
59
Removal of Combustion Chamber Lining
59
Combustion and Ventilation Air
59
Gas Valve Voltage
60
Combustible Materials
60
Freeze Protection for Indoor & Outdoor Installations
60
FREEZE PROTECTION for a HEATING BOILER SYSTEM (Optional)
60
Part 10 Installations
60
Checking the Installation
60
Checking the Construction
60
Heating Boiler Installations
61
Inspect & Recharge Condensate Collection/Neutralizing Reservoir
61
Water Connections
61
Piping Lengths
61
Domestic Hot Water with Storage Tank
62
Domestic Hot Water with Plate Heat Exchanger
62
Temperature Rise at Full Firing Rate
62
Lead Lag Setup
63
Local/Remote Switch
64
Modbus/Local Switch
64
Appliance
64
Part 13 Piping Diagrams
65
Part 14 Exploded View & Parts List
70
Part 15 Electrical Diagrams
78
DM 200- 299 Internal Wiring Diagram
78
DM 399 - 800 Internal Wiring Diagram
79
Field Wiring
81
System Sensor
81
Lead Lag Setup
81

Camus Hydronics DynaMax DMH801 Installation, Operation And Service Manual (82 pages)

GAS FIRED WALL HUNG & FLOOR MOUNT RESIDENTIAL COMMERCIAL STAINLESS STEEL BOILERS DynaMax HS SERIES

Brand: Camus Hydronics | Category: Boiler | Size: 14 MB

Table of Contents
3
Part 1 General Information
6
Introduction
6
Special Instructions to Owner
6
Checking Equipment
6
Display Unit
6
Sequence of Operation
6
Heat Transfer Process
6
End of Sequence
7
Installation Codes
7
Warranty
7
Removal of Existing Appliance
8
Boiler/Furnace Room Operating Condition
8
1.10 Location of Unit
8
Clearance from Combustible Material
9
Part 2 Air Inlet and Venting
13
General Venting Guide
13
Category IV Venting
13
Approved Venting Materials Category IV
13
Category II Venting
14
Approved Venting Materials Category II
14
Combined Combustion Air Inlet
14
Vent Termination and Air Inlet Clearances
15
Sidewall Venting
15
Sidewall Air Inlet
15
Sidewall Concentric Vent/Air
16
Vertical Direct Venting
16
Part 3 Gas Connection
18
Gas Connection
18
Gas Piping
18
Install Piping
18
Checking Gas Supply Pressure
18
HIGH and LOW GAS PRESSURE SWITCHES (Optional)
19
Air/Gas Ratio Valve
19
Burner
19
Part 4 Water Connection
20
Freeze Protection Outdoor Installation
20
Warning Regarding Chilled Water Systems
21
Inlet and Outlet Connections
21
Minimum Pipe Size Requirements
21
Heat Exchanger
21
Low Water Temperature Systems
21
Piping Arrangements
21
Field Supplied Components
21
Relief Valve
23
DHW TUNING VALVE (Combination Models Only)
23
FLOW PROVING DEVICE (Wall Mount Models and Combination Models Only)
23
WATER FLOW SWITCH (Floor Mount Hydronic and DHW Models Only)
23
LOW WATER CUTOFF (if Equipped)
23
Part 5 Electrical & Controls
24
Electrical Conections
24
High Limit
24
Dynamax Hs Controller
24
Service Parts
24
Ignition Module Lockout Functions
25
Error Table
25
Manual Reset Codes
25
Automatic Reset Codes
25
Part 6 Control Panel
26
Dynamax Hs Controller
26
Setting the Dynamax Hs Controller
26
Part 7 Components
42
7.1 Direct Spark Igniter
42
Flame Sensor
42
7.3 Combustion Air Fan
42
7.4 Gas Valve
42
7.5 Outer Jacket
42
Part 8 Troubleshooting
43
Setting the Correct Combustion
52
Gas Valve Adjustment Procedure
52
Part 9 Maintenance
54
Examine the Venting System
54
Visually Check Main Burner Flames
54
Cleaning Boiler Heat Exchanger
54
Condensate Treatment
55
Igniter and Flame Sensor Electrodes
55
Check Igniter Ground Wiring
55
Burner Maintenance
55
Burner Removal and Cleaning
56
Removal of Combustion Chamber Lining
56
Combustion and Ventilation Air
56
Gas Valve Voltage
57
Combustible Materials
57
Freeze Protection for Indoor & Outdoor Installations
57
FREEZE PROTECTION for a HEATING BOILER SYSTEM (Optional)
57
Part 10 Installations
58
Checking the Installation
58
Checking the Construction
58
Heating Boiler Installations
58
Inspect & Recharge Condensate Collection/Neutralizing Reservoir
58
Water Connections
58
Piping Lengths
58
Domestic Hot Water with Plate Heat Exchanger
59
Domestic Hot Water with Storage Tank
59
Part 10 Installations
60
Temperature Rise at Full Firing Rate
60
Lead Lag Setup
61
Part 8 Troubleshooting
62
Local/Remote Switch
62
Modbus/Local Switch
62
Appliance
62
Part 13 Piping Diagrams
63
Part 14 Exploded View & Parts List
68
Part 15 Electrical Diagrams
76
DM 80- 299 Internal Wiring Diagram
76
DM 399 - 800 Internal Wiring Diagram
77
Field Wiring
79
System Sensor
79
Lead Lag Setup
79

Camus Hydronics Categories

Boiler Water Heater Gas Heater Controller

More Camus Hydronics Manuals

Camus Hydronics DynaMax DMH801 Manuals

Camus Hydronics DynaMax DMH801 Installation, Operation And Service Manual (93 pages)

Table of Contents

Camus Hydronics DynaMax DMH801 Installation And Service Manual (84 pages)

Table of Contents

Camus Hydronics DynaMax DMH801 Installation, Operation And Service Manual (82 pages)

Table of Contents

Related Products

Camus Hydronics Categories