Porter-Cable PXCM301 Instruction Manual page 4

Read and understand all safety precautions in this manual before operating. Failure to
comply with instructions in this manual could result in personal injury, property damage,
and/or voiding of your warranty. The manufacturer WILL NOT be liable for any damage
because of failure to follow these instructions.
1. RIsK of fIRe oR
eXPlosIon. Never spray
flammable liquids in a confined
area. It is normal for the motor
and pressure switch to produce
sparks while operating. If sparks
come into contact with vapors
from gasoline or other solvents, they may
ignite, causing fire or explosion. Always
operate the compressor in a well–ventilated
area. Do not smoke while spraying. Do not
spray where sparks or flame are present.
Keep compressor as far from spray area as
possible.
2. RIsK of electRIcal
sHocK. Never use an electric
air compressor outdoors when
it is raining or on a wet surface,
as it may cause an electric shock.
3. RIsK of InJuRy. This unit
starts automatically. ALWAYS
shut off the compressor, remove
the plug from the outlet, and
bleed all pressure from the system before
servicing the compressor, and when the
compressor is not in use. Do not use the
unit with the shrouds or beltguard removed.
Serious injury could occur from contact
with moving parts.
4. RIsK of buRstIng. Check
the manufacturer's maximum
pressure rating for air tools and
accessories. Compressor outlet
pressure must be regulated so as to never
exceed the maximum pressure rating of the
tool. Relieve all pressure through the hose
before attaching or removing accessories.
5. RIsK of buRns. High
temperatures are generated
by the pump and manifold. To
prevent burns or other injuries, DO NOT
touch the pump, manifold or transfer tube
while the pump is running. Allow them to
cool before handling or servicing. Keep
children away from the compressor at all
times.
waRnIng
6. RIsK to bReatHIng. Be
certain to read all labels when
you are spraying paints or toxic
materials, and follow the safety
instructions. Use a respirator mask if there
is a chance of inhaling anything you are
spraying. Read all instructions and be sure
that your respirator mask will protect you.
Never directly inhale the compressed air
produced by a compressor. It is not
suitable for breathing purposes.
7. RIsK of eye InJuRy.
Always wear ANSI Z87.1
approved safety goggles when
using an air compressor. Never point any
nozzle or sprayer toward a person or any
part of the body. Equipment can cause
serious injury if the spray penetrates the
skin.
8. RIsK of buRstIng. Do not
adjust the relief valve for any
reason. Doing so voids all
warranties. The relief valve has
been pre-set at the factory for the
maximum pressure of this unit. Personal
injury and /or property damage may result if
the relief valve is tampered with.
9. RIsK of buRstIng.Do not
use plastic or pvc pipe for
compressed air. Use only
gavanized steel pipe and fittings
for compressed air distribution lines.
10. RIsK to HeaRIng. Always
wear hearing protection when
using an air compressor. Failure
to do so may result in hearing loss.
11. The power cord on this
product contains lead, a
chemical known to the State of
California to cause cancer, and
birth defects or other reproductive harm.
Wash hands after handling.
note: electRIcal wIRIng. Refer to
the air compressor's serial label for the
unit's voltage and amperage requirements.
4- ENG