Advertisement

QQ
3 7 63 1515 0
DVD-S540/DV-S5650
TE
L 13942296513
CONTENTS
To Service Personnel . . . . . . . . . . . . . . . . . . 2–4
Front Panels . . . . . . . . . . . . . . . . . . . . . . . . . . . 5–6
Remote Control Panels . . . . . . . . . . . . . . . . . . 6
Rear Panels . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7–8
SPECIFICATIONS /
SERVICE HINTS /
DISASSEMBLY PROCEDURES /
分解手順
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11–13
www
.
1 0 0 8 6 3
http://www.xiaoyu163.com
This manual has been provided for the use of authorized YAMAHA Retailers and their service personnel.
It has been assumed that basic service procedures inherent to the industry, and more specifically YAMAHA Products, are already
known and understood by the users, and have therefore not been restated.
WARNING:
Failure to follow appropriate service and safety procedures when servicing this product may result in personal
injury, destruction of expensive components, and failure of the product to perform as specified. For these reasons,
we advise all YAMAHA product owners that any service required should be performed by an authorized YAMAHA
Retailer or the appointed service representative.
IMPORTANT:
The presentation or sale of this manual to any individual or firm does not constitute authorization, certification or
recognition of any applicable technical capabilities, or establish a principle-agent relationship of any form.
The data provided is believed to be accurate and applicable to the unit(s) indicated on the cover. The research, engineering, and service
departments of YAMAHA are continually striving to improve YAMAHA products. Modifications are, therefore, inevitable and
specifications are subject to change without notice or obligation to retrofit. Should any discrepancy appear to exist, please contact the
distributor's Service Division.
WARNING:
Static discharges can destroy expensive components. Discharge any static electricity your body may have
accumulated by grounding yourself to the ground buss in the unit (heavy gauge black wires connect to this buss).
IMPORTANT:
Turn the unit OFF during disassembly and part replacement. Recheck all work before you apply power to the unit.
参考仕様
. . . . . . . . . . . . . . . . . . . . 9
. . . . . . . . . . . . . . . 10
サービスヒント
x
ao
u163
y
i
http://www.xiaoyu163.com
2 9
8
DVD PLAYER
SERVICE MANUAL
SERVICE MANUAL

IMPORTANT NOTICE

Q Q
3
6 7
1 3
1 5
メンテナンスフローチャート
Block Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Printed Circuit Board . . . . . . . . . . . . . . . . 24–28
Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Schematic Diagram . . . . . . . . . . . . . . . . . . . 30–38
Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39–46
co
.
9 4
2 8
0 5
8
2 9
9 4
2 8
. . . . . . . . . . . . . . . . . 14–21
m
9 9
9 9

Advertisement

Table of Contents
loading

Summary of Contents for Yamaha DVD-S540

  • Page 1 This manual has been provided for the use of authorized YAMAHA Retailers and their service personnel. It has been assumed that basic service procedures inherent to the industry, and more specifically YAMAHA Products, are already known and understood by the users, and have therefore not been restated.
  • Page 2 DVD-S540/DV-S5650 3 7 63 1515 0 TO SERVICE PERSONNEL AC LEAKAGE 1. Critical Components Information EQUIPMENT WALL TESTER OR Components having special characteristics are marked Z OUTLET UNDER TEST EQUIVALENT and must be replaced with parts having specifications equal to those originally installed.
  • Page 3 DVD-S540/DV-S5650 3 7 63 1515 0 2) The laser power level can be adjusted with the VR on 2) レーザーパワーレベルは光ピックアップ基板上のVRに the pick-up PWB, however, this level has been set by より調整可能ですが、工場出荷前に調整セット済みな the factory prior to shipping from the factory. Do not ので、この...
  • Page 4 DVD-S540/DV-S5650 3 7 63 1515 0 J model VIDEO CLASS 1 LASER PRODUCT LASER KLASSE 1 PRODUKT D1 D2 LUOKAN 1 LASERLAITE S VIDEO COAXIAL OPTICAL KLASS 1 LASER APPARAT DIGITAL PRODUIT LASER DE CLASSE 1 DTS MPEG VIDEO OUT...
  • Page 5 M a c r o v i s i o n C o r p o r a t i o n . R e v e r s e engineering or disassembly is prohibited. L 13942296513 FRONT PANELS DVD-S540 (U, C models) DVD-S540 (A, B, G, P, T, K, J models) u163 http://www.xiaoyu163.com...
  • Page 6 DVD-S540/DV-S5650 3 7 63 1515 0 DVD-S540 (R model) DV-S5650 (U, C model) DV-S5650 (A,G models) L 13942296513 REMOTE CONTROL PANELS U, C, A, B, G, P, T, K, J models R model u163 http://www.xiaoyu163.com...
  • Page 7 DVD-S540/DV-S5650 3 7 63 1515 0 REAR PANELS DVD-S540 (U, C models) DVD-S540 (R, K models) DVD-S540 (A model) L 13942296513 DVD-S540 (G, B models) DVD-S540 (P model) u163 http://www.xiaoyu163.com...
  • Page 8 DVD-S540/DV-S5650 3 7 63 1515 0 DVD-S540 (T model) DVD-S540 (J model) DV-S5650 (U, C models) L 13942296513 DV-S5650 (A model) DV-S5650 (G model) u163 http://www.xiaoyu163.com...
  • Page 9 DVD-S540/DV-S5650 3 7 63 1515 0 SPECIFICATIONS / 参考仕様 PLAYBACK SYSTEM / 対応ディスク GENERAL / 一般 DVD Video Dimensions (w x h x d) Video CD & SVCD U, C models 435 x 75 x 302 mm (17-1/8" x 2-15/16" x 11-7/8")
  • Page 10 DVD-S540/DV-S5650 3 7 63 1515 0 SERVICE HINTS / サービスヒント 1 Repair tips 1 修理についての助言 1) Power Supply Unit 1) 電源ユニット The power supply unit has to be replaced in case of 故障の場合は、電源ユニットを交換してください。 failure. 2) DVD メカ 2) DVD Mechanism DVDメカは、...
  • Page 11 DVD-S540/DV-S5650 3 7 63 1515 0 DISASSEMBLY PROCEDURES See exploded view for item numbers. Top Cover [0250] Mounting Remove 4 screws [0113] and 3 screws [0261]. Lift cover from rearside to Dismounting remove. Front Panel [0001] DVD Mechanism [0050] Remove cable connections.
  • Page 12 DVD-S540/DV-S5650 3 7 63 1515 0 分解手順 項目番号については分解図を参照してください。 Top Cover [0250] 取り付け ネジ[0113]4本とネジ [0261]3本を外します。 カバーを後ろ側から上げ 取り外し て取り外します。 Front Panel [0001] DVD Mechanism [0050] ケーブルの接続を外します。 ケーブルとフレキの接続を外します。 トレーを開けます。 トレーを開きます (「手動でトレーを開く方法」を参照) (「手動でトレーを開く方法」を参照) トレーカバー[0035]を外し、トレーを閉め トレーカバー[0035]を外し、トレーを閉 ます。 めます。 4ヶのスナップ(側面の2ヶ、底部の2ヶ) DVDメカを底部に取り付けているネジ を外して、フロントパネルをフレームから [0155]4本を取り外します。 外します。 DVDメカを少し持ち上げて後方に動かし...
  • Page 13 DVD-S540/DV-S5650 3 7 63 1515 0 手動でトレーを開く方法 HOW TO MANUALLY EJECT THE TRAY a.本体を上下反転します。 a. Turn the player bottom up. b.トレーが出てくるまで、ドライバーでス b. Move the slider in the direction indicated ライダーを図に示す矢印の方向に動かし with a screw driver until the tray is ejected.
  • Page 14 DVD-S540/DV-S5650 3 7 63 1515 0 MAINTENANCE FLOW CHART Start Power on 1. Check Cable Voltages 2. Replace Power Supply Unit if Mono Board is not shorted, at all pins of connector (Ref 1601) otherwise find out first where the short is.
  • Page 15 DVD-S540/DV-S5650 3 7 63 1515 0 メンテナンスフローチャート 開始 電源ON 1. ケーブルをチェックする コネクター(Ref 1601)の 2. Mono P.C.B.がショートしていなければ電源ユニットを交換する 全部のピンの電圧が ショートしていたら、最初にショートがどこで起きたか調べる 正常か ? DV33と LD1117 (Ref 7601) と1N4002 (Ref 6604) と周辺回路をチェックする V25は正常か ? メインクロックは OSC回路をチェックする LOGOが表示されるか ? 正常か ? L 13942296513 リセット信号は...
  • Page 16 DVD-S540/DV-S5650 3 7 63 1515 0 Signal TROUT Does the tray Check the position-switch (Pin 48 of MT1336E) and automatically close when on DVD mechanism TRIN (Pin 47 of MT1336E) it is open? is correct ? Signal Check the circuit between TRCLOSE &...
  • Page 17 DVD-S540/DV-S5650 3 7 63 1515 0 信号TROUT DVDメカ上の トレーが (MT1336Eの48ピン)とTRIN ポジション・スイッチを 開いている時、自動的に (MT1336Eの47ピン)は チェックする 閉まるか ? 正しいか ? 信号 MT1336EとBA5954間の回路 TRCLOSEとTROPENは をチェックする 正しいか ? 信号 LOAD+とLOAD-は BA5954と周辺をチェックする 正しいか ? DVDメカを接続する回路を チェックする スレッドが 信号 STBYに関連する回路を 外周側にある時、自動的に内周側に STBY(BA5954の28ピン)は チェックする 移動するか ? "H"レベルか...
  • Page 18 DVD-S540/DV-S5650 3 7 63 1515 0 Check the peripheral Signal circuit of MT1336E When read disc, LDO1 and LDO2 are Check the peripheral Laser on OK ? normal ? circuit of two transistor (Ref 7620 & 7621) Voltage of Check the peripheral TP22 &TP24...
  • Page 19 DVD-S540/DV-S5650 3 7 63 1515 0 MT1336Eの周辺回路を 信号 チェックする ディスクの読み取り時に LDO1とLDO2は 2個のトランジスター レーザーONはOKか ? 正常か ? (Ref 7620と7621)の 周辺回路をチェックする 2個のトランジスター TP22と (Ref 7620と7621)の TP24の電圧は OKか ? 周辺回路をチェックする DVDメカを接続している回路を レーザーOFF ディスクが搭載されているか ? チェックする 光ピックアップが損傷している かもしれない MT1336Eの 光ピックアップとMT1336E間 ピンA, B, C, D, E, Fのどれ...
  • Page 20 DVD-S540/DV-S5650 3 7 63 1515 0 Signal TEO Check MT1336E and its Track on OK ? (pin 21 of MT1336E) peripheral circuit. normal ? Signal TRSO Check the connection (pin13 of MT1379BE) between MT1379BE (pin 13) normal ? and MT1336E (pin 26)
  • Page 21 DVD-S540/DV-S5650 3 7 63 1515 0 信号TEO MT1336Eとその周辺回路を トラックONはOKか ? (MT1336Eの21ピン)は チェックする 正常か ? MT1379BEの13ピンと 信号TRSO BA5954の26ピン間の接続を (MT1379BEの13ピン)は チェックする 正常か ? 信号T+ BA5954とその周辺回路を (TP3)とT-(TP14) チェックする は正常か ? 光ピックアップとBA5954の間 の接続をチェックする ディスクはスタンバイ状態か ? RF信号をチェックする L 13942296513 AKM4382A MT1379BEとAKM4382A間の接続を オーディオ信号は正常か ? が正しいデータを...
  • Page 22 DVD-S540/DV-S5650 3 7 63 1515 0 MEMO L 13942296513 u163 http://www.xiaoyu163.com...
  • Page 23 DVD-S540/DV-S5650 The first digit of a component indicates the component type. 3 7 6 3 1 5 1 5 0 1xxx : Connector 3xxx : Resistor 5xxx : Coil 7xxx : IC, Transistor, FET PRINTED CIRCUIT BOARD 2xxx : Capacitor...
  • Page 24 DVD-S540/DV-S5650 The first digit of a component indicates the component type. 3 7 6 3 1 5 1 5 0 1xxx : Connector 3xxx : Resistor 5xxx : Coil 7xxx : IC, Transistor, FET PRINTED CIRCUIT BOARD 2xxx : Capacitor...
  • Page 25 DVD-S540/DV-S5650 The first digit of a component indicates the component type. 3 7 6 3 1 5 1 5 0 J, B, G models only 1xxx : Connector 3xxx : Resistor 5xxx : Coil 7xxx : IC, Transistor, FET...
  • Page 26 DVD-S540/DV-S5650 The first digit of a component indicates the component type. 3 7 6 3 1 5 1 5 0 1xxx : Connector 3xxx : Resistor 5xxx : Coil 7xxx : IC, Transistor, FET PRINTED CIRCUIT BOARD 2xxx : Capacitor...
  • Page 27 DVD-S540/DV-S5650 The first digit of a component indicates the component type. 3 7 6 3 1 5 1 5 0 1xxx : Connector 3xxx : Resistor 5xxx : Coil 7xxx : IC, Transistor, FET PRINTED CIRCUIT BOARD 2xxx : Capacitor...
  • Page 28 DVD-S540/DV-S5650 The first digit of a component indicates the component type. 3 7 6 3 1 5 1 5 0 1xxx : Connector 3xxx : Resistor 5xxx : Coil 7xxx : IC, Transistor, FET SCHEMATIC DIAGRAM 2xxx : Capacitor...
  • Page 29 DVD-S540/DV-S5650 The first digit of a component indicates the component type. 3 7 6 3 1 5 1 5 0 1xxx : Connector 3xxx : Resistor 5xxx : Coil 7xxx : IC, Transistor, FET SCHEMATIC DIAGRAM 2xxx : Capacitor...
  • Page 30 DVD-S540/DV-S5650 The first digit of a component indicates the component type. 3 7 6 3 1 5 1 5 0 1xxx : Connector 3xxx : Resistor 5xxx : Coil 7xxx : IC, Transistor, FET SCHEMATIC DIAGRAM 2xxx : Capacitor...
  • Page 31 DVD-S540/DV-S5650 The first digit of a component indicates the component type. 3 7 6 3 1 5 1 5 0 1xxx : Connector 3xxx : Resistor 5xxx : Coil 7xxx : IC, Transistor, FET SCHEMATIC DIAGRAM 2xxx : Capacitor...
  • Page 32 DVD-S540/DV-S5650 The first digit of a component indicates the component type. 3 7 6 3 1 5 1 5 0 1xxx : Connector 3xxx : Resistor 5xxx : Coil 7xxx : IC, Transistor, FET SCHEMATIC DIAGRAM 2xxx : Capacitor...
  • Page 33 DVD-S540/DV-S5650 The first digit of a component indicates the component type. 3 7 6 3 1 5 1 5 0 1xxx : Connector 3xxx : Resistor 5xxx : Coil 7xxx : IC, Transistor, FET SCHEMATIC DIAGRAM 2xxx : Capacitor...
  • Page 34 DVD-S540/DV-S5650 The first digit of a component indicates the component type. 3 7 6 3 1 5 1 5 0 1xxx : Connector 3xxx : Resistor 5xxx : Coil 7xxx : IC, Transistor, FET SCHEMATIC DIAGRAM 2xxx : Capacitor...
  • Page 35 DVD-S540/DV-S5650 The first digit of a component indicates the component type. 3 7 6 3 1 5 1 5 0 1xxx : Connector 3xxx : Resistor 5xxx : Coil 7xxx : IC, Transistor, FET SCHEMATIC DIAGRAM 2xxx : Capacitor...
  • Page 36 DVD-S540/DV-S5650 The first digit of a component indicates the component type. 3 7 6 3 1 5 1 5 0 1xxx : Connector 3xxx : Resistor 5xxx : Coil 7xxx : IC, Transistor, FET SCHEMATIC DIAGRAM 2xxx : Capacitor...
  • Page 37 DVD-S540/DV-S5650 3 7 6 3 1 5 1 5 0 BLOCK DIAGRAM 7602 MONO BOARD 7611 7609 SD5.4 8 Mbit FLASH 64 Mbit SDRAM RF AMPLIFIER S VIDEO 1603 MT1336 VIDEO 1605 1606 COMPONET VIDEO AUDIO OUT 1614 COAXIAL...
  • Page 38 DVD-S540/DV-S5650 3 7 6 3 1 5 1 5 0 WIRING DIAGRAM SD5.4 MONO BOARD POWER SUPPLY UNIT 1609 1601 D5V (+5VL) +12V_IN CD/DVD -12V STDBY +5VL 10 GND D5V (+5VD) GND-PD D5V (+5VD) +12_IN (+12VA) 1 GND 1616...
  • Page 39 DVD-S540/DV-S5650 3 7 63 1515 0 PARTS LIST ELECTRICAL PARTS WARNING Components having special characteristics are marked Z and must be ● 印のある部分は、安全確保部品を示しています。部品の交換が必要な場合、 replaced with parts having specifications equal to those originally installed. パーツリストに記載されている部品を使用してください。 ABBREVIATIONS IN THIS LIST ARE AS FOLLOWS : C.A.EL.CHP...
  • Page 40 DVD-S540/DV-S5650 3 7 63 1515 0 Ref. PART NO. Description Remarks Markets 部品名 Rank P.C.B. MONO SD5.4 PCB MONO * 1603 AAX50440 TERMINAL S-VIDEO S-5D 3141 010 30422 Sビデオ端子 * 1605 AAX50610 JACK.PIN 2P YE/BL 3141 010 30411 ピンジャック * 1606 AAX50630 JACK.PIN...
  • Page 41 DVD-S540/DV-S5650 3 7 63 1515 0 Ref. PART NO. Description Remarks Markets 部品名 Rank * 7613 AAX50380 IC NJM4560M 9338 800 40685 IC * 7614 AAX50330 IC MC78L05ACD 9322 043 00668 IC * 7615 AAX46780 IC AKM4382AVT 9322 177 09685 IC...
  • Page 42 DVD-S540/DV-S5650 3 7 63 1515 0 Ref. PART NO. Description Remarks Markets 部品名 Rank * 7119 AAX47380 TR BC847B 3198 010 42030 BG トランジスタ * 7121 AAX46620 IC LM833D 9322 020 18668 BG IC AAX50420 P.C.B. FRONT 3139 248 82661 JUCTKABGP PCB フロント...
  • Page 43 DVD-S540/DV-S5650 3 7 6 3 1 5 1 5 0 Parts List for Chip Carbon Resistors Parts List for Chip Ceramic Capacitors Value 1/10W Type Part No. Value 1/10W Type Part No. Value 1/16W Type Part No. 0 Ω...
  • Page 44 DVD-S540/DV-S5650 3 7 6 3 1 5 1 5 0 EXPLODED VIEW When disassembling, use the special screw driver with tip shape in figure. 分解には図のような特殊ドライバーを使用します。 0261 0250 0155 2.7 mm 0050 0310 0200 0110 0218 2000 0210 0113 1003...
  • Page 45 DVD-S540/DV-S5650 WARNING Components having special characteristics are marked Z and must be 3 7 6 3 1 5 1 5 0 replaced with parts having specifications equal to those originally installed. MECHANICAL PARTS 印のある部分は、安全確保部品を示しています。部品の交換が必要な場合、 パーツリストに記載されている部品を使用してください。 Ref. Ref. PART NO.
  • Page 46 DVD-S540/DV-S5650 3 7 6 3 1 5 1 5 0 MEMO DVD-S540/DV-S5650 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 http://www.xiaoyu163.com...

This manual is also suitable for:

Dv-s5650

Table of Contents