Safety Precautions - Heatmaster G100 Operation And Maintenance Manual

Read and understand all precautions before operating the furnace.
This wood heater needs periodic inspection and repair for proper operation. It is against
federal regulations to operate this wood heater in a manner inconsistent with operating
instructions in this manual.
ATTENTION: Save these instructions. Retain this manual as long as you own your
G SERIES outdoor furnace. Carefully read and follow these directions.
ATTENTION: BURN WOOD ONLY. LOAD FUEL CAREFULLY OR DAMAGE MAY
RESULT
ATTENTION: The person(s) operating this furnace must comply with all applicable
local and state laws or other requirements,
ATTENTION: The person(s) operating this furnace are responsible to run it in such a
way so that it does not cause a public or private nuisance. Consult with local authori-
ties prior to installation to adhere to local laws and ordinances.
DANGER: Do not start fire with or burn garbage, gasoline, naptha, engine oil or
other inappropriate materials. Only competent persons with a sound understanding of
this heating method should operate this furnace. Improper firing could result in person-
al injury and/or damage to the unit and void warranty.
ATTENTION: DO NOT OVERFIRE THIS HEATER. Attempts to achieve heat output
rates that exceed the heater design specifications can result in permanent damage to
the heater.
WARNING: All installations and operations of your G SERIES product must follow
state, provincial, and local laws pertaining to operations, wiring, plumbing and building
codes.
WARNING: All models operate at atmospheric pressure. DO NOT obstruct, block or
plug the overflow vent tube in any way, which is located on top of the boiler .
CAUTION: Do not start or operate furnace without checking heating fluid. Furnace
must be filled until heating fluid comes out of vent pipe on the top of the furnace.
CAUTION: Check for buried cables and utility lines before digging the trench to your
furnace.
CAUTION: For safety and proper temperature control keep all doors closed during op-
eration.
WARNING: When installing the furnace, the chimney should never be connected
to a chimney flue serving another appliance
WARNING: Do not operate furnace in event of power failure
WARNING: Use caution when opening firebox and ash cleaning doors. Push by-
pass rod on front of furnace and slowly crack door open for at least 20 seconds before
opening door.
WARNING: Risk of fire:
- Do not operate with fuel loading or ash removal doors open.
- Do not store fuel or other combustible material within marked installation clear
ances
- Inspect and clean flues and chimney regularly
CAUTION: Hot Surfaces: Keep children away. Do not touch during operation.
www.heatmasterss.com

SAFETY PRECAUTIONS

G Series Outdoor Furnaces
- 3 -