Set-Up - U.S.SAWS ACH GB-16 Operating Manual

SYMBOLS & LABELS
TITLE
THE FOLLOWING SYMBOLS & DEFINITIONS ARE FOUND THROUGHOUT THIS MANUAL AND
SYMBOLS & LABELS
TITLE
ARE DESIGNED TO MAKE YOU AWARE OF POTENTIAL HAZARDS OR UNSAFE PRACTICES.
THE FOLLOWING SYMBOLS & DEFINITIONS ARE FOUND THROUGHOUT THIS MANUAL AND
ARE DESIGNED TO MAKE YOU AWARE OF POTENTIAL HAZARDS OR UNSAFE PRACTICES.
WARNING
THE FOLLOWING SYMBOLS & DEFINITIONS ARE FOUND THROUGHOUT THIS MANUAL AND
ARE DESIGNED TO MAKE YOU AWARE OF POTENTIAL HAZARDS OR UNSAFE PRACTICES.
WARNING
WARNING
CAUTION
CAUTION
CAUTION
IMPORTANT
IMPORTANT
Guide Bar and Diamond Chain Installation
IMPORTANT
THE FOLLOWING SYMBOLS & LABELS MAY BE FOUND IN THIS MANUAL OR ON THE SAW
STEP 1
Loosen side cover nut an remove side
THE FOLLOWING SYMBOLS & LABELS MAY BE FOUND IN THIS MANUAL OR ON THE SAW
cover.
THE FOLLOWING SYMBOLS & LABELS MAY BE FOUND IN THIS MANUAL OR ON THE SAW
STEP 2
Place bar onto saw chassis and ensure the
bar sits over bar spacers on stud bolts.
STEP 3
Mount the diamond chain on the guidebar
starting at the drive sprocket and continue
over the guidebar nose.
4
4
4
STEP 4
Install the side cover and ensure chain
adjustment pin engages hole in bar. Do not
fully tighten side cover until after chain is
properly tensioned.

Set-up

A potentially hazardous situation exists which, if not avoided,
could result in death or serious injury.
A potentially hazardous situation exists which, if not avoided,
could result in death or serious injury.
A potentially hazardous situations exists which, if not avoided,
A potentially hazardous situation exists which, if not avoided,
could result in death or serious injury.
could result in death or serious injury.
A potentially hazardous situation exists which, if not avoided,
may result in minor or moderate injury or property damage.
A potentially hazardous situation exists which, if not avoided,
A potentially hazardous situation exists which, if not avoided,
may result in minor or moderate injury or property damage.
may result in minor or moderate injury or property damage.
A potentially hazardous situation exists which, if not avoided,
may result in minor or moderate injury or property damage.
A potential situation exists which, if not avoided, may result in
A potential situation exists which, if not avoided, may result in
product or property damage.
product or property damage.
A potential situation exists which, if not avoided, may result in
product or property damage.
A potential situation exists which, if not avoided, may result in
product or property damage.
Read the operator's manual carefully and understand the
contents before you use this equipment.
Read the operator's manual carefully and understand the
contents before you use this equipment.
Read the operator's manual carefully and understand the
contents before you use this equipment.
Always use:
• Protective helmet
Always use:
• Ear protection
• Protective helmet
• Protective glasses or full face protection
Always use:
• Ear protection
• Protective helmet
• Protective glasses or full face protection
• Ear protection
• Protective glasses or full face protection
Wear hand protection
Wear hand protection
Wear hand protection
© 2011 ICS, Blount Inc.
© 2011 ICS, Blount Inc.
© 2011 ICS, Blount Inc.
Air Powered Chain Saw
633GC / 633F4 OPERATOR'S MANUAL
633GC / 633F4 OPERATOR'S MANUAL
STEP 5
Make sure all the drive links are inside
the guidebar groove then lift the bar nose
and tension the chain by turning the screw
clockwise.
SYMBOLS & LABELS
TITLE
THE FOLLOWING SYMBOLS & DEFINITIONS ARE
STEP 6 ARE DESIGNED TO MAKE YOU AWARE OF POTE
Before cutting, check for proper tension by
WARNING
pulling the chain around the bar by hand. If
you cannot easily pull by hand, the chain is
too tight and needs to be loosened slightly.
CAUTION
Be aware that the guidebar rails may
develop sharp edges over time so always
pull the diamond chain by the diamond
IMPORTANT
segments.
F/N 70944 May 2011
F/N 70944 May 2011
A potentially hazardou
F/N 70944 May 2011
could result in death o
A potentially hazardou
may result in minor or
A potential situation e
6
product or property d