Where in a manufacturer’s service documentation, for example in circuit diagrams or lists of components, a symbol is used to indicate that a specific component shall be replaced only by the component specified in that documentation for safety reasons, the following symbol shall be used: L 13942296513 u163 MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Page 3
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. MVH-P8200BT/XNUC http://www.xiaoyu163.com...
If the microphone is not connected securely, the microphone input signals may become inaccurate and an error message “Plug the supplied microphone securely into the jack” may appear due to the measurement failure. area and a heat sink becomes hot areas. Be careful not to burn yourself. u163 MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia. L 13942296513 u163 MVH-P8200BT/XNUC http://www.xiaoyu163.com...
2. SPECIFICATIONS 3 7 63 1515 0 2.1 SPECIFICATIONS MVH-P8200BT/XNUC, MVH-P8200/XNUC General Bass boost: Gain ........+12 dB to 0 dB Power source......14.4 V DC (10.8 V to 15.1 V allowable) Grounding system....Negative type USB standard specification Maximum current consumption ...........USB 1.1, USB 2.0 full speed...
Page 8
Power output ......14 W RMS × 4 Channels (4 ohm and 1 % THD+N) S/N ratio ........91 dBA (reference: 1 W into 4 ohm) Note Specifications and the design are subject to mod- ifications without notice. L 13942296513 u163 MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Page 9
Subwoofer (mono): (Power class 2) Frequency......50/63/80/100/125 Hz Slope........–18 dB/oct Note Gain ........+6 dB to –24 dB Phase .........Normal/Reverse Specifications and the design are subject to mod- Bass boost: ifications without notice. Gain ........+12 dB to 0 dB u163 MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Page 10
Gain ........+6 dB to –24 dB Phase .........Normal/Reverse Note Bass boost: Gain ........+12 dB to 0 dB Specifications and the design are subject to mod- ifications without notice. USB standard specification ...........USB 1.1, USB 2.0 full speed u163 MVH-P8200BT/XNUC http://www.xiaoyu163.com...
(BT model only) The Bluetooth word mark and logos are owned by the Bluetooth SIG, Inc. and any use of such marks by Pioneer Corporation is under license. Other trademarks and trade names are those of their respective owners. (UC model only)
+ /– (VO- Press to increase or decrease vo- CAUTION LUME) lume. Use an optional Pioneer USB cable (CD-U50E) to Press to mute. Press again to un- MUTE connect the USB audio player/USB memory as mute. any device connected directly to the unit will pro- Press to perform manual seek trude out from the unit and may be dangerous.
Press to display the folder list, file list or preset channel list depend- ing on the source. Press to directly select the desired DIRECT channel for XM/SIRIUS tuner. Press to cancel the input number Clear when 0 to 9 are used. u163 MVH-P8200BT/XNUC http://www.xiaoyu163.com...
See the table below for the items to be checked regarding audio: Item to be checked regarding audio Distortion Noise Volume too low Volume too high Volume fluctuating Sound interrupted L 13942296513 u163 MVH-P8200BT/XNUC http://www.xiaoyu163.com...
3 7 63 1515 0 SD PCB Tuner Amp Unit(Service) Tuner Amp Unit Panel PCB Keyboard PCB Monitor PCB BT ANT PCB L 13942296513 A:MVH-P8200BT/XNUC B:MVH-8200BT/XNEW5 C:MVH-8250BT/XNES D:MVH-P8200/XNUC E:MVH-8200/XNEW5 F:MVH-8250/XNES Unit Number : CXX2822(A) Unit Number : CXX2823(B) Unit Number : CXX2821(C)
3.3 JIGS LIST 3 7 63 1515 0 - Jigs List Name Name Jig No. Jig No. Remarks Remarks GGF1539 Remove the Cord Assy L 13942296513 u163 MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Touch Panel model and Full GUI (English version). *2 A parameter of UART command, such as “receipt error notice”, that the DVD mechanism transmits. *3 It transmits DRM setting information notification from MMD, it occurs when DRM information setting response does not return. u163 MVH-P8200BT/XNUC http://www.xiaoyu163.com...
When 8 digits of read number is strange, displayed with red. [Operation specification] Operational description Remote controller key Return to test mode mene Page up Page down u163 2. Touch Panel Test There is no information to be shown in this menu. MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Page 36
When normally ends, "success" is displayed. When will not end in four seconds, judged to be abnormal, "failure" is displayed. u163 [Operation specification] Operational description Remote controller key Selection cursor left movement Selection cursor right movement Return to test mode mene Menu enter MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Page 37
Display of monochrome stripe signal (1dot Width) [Operation specification] Operational description Remote controller key Return to test mode mene [COLOR BAR] u163 Display of color bar signal [Operation specification] Operational description Remote controller key Return to test mode mene MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Page 38
[Operation specification] Operational description Remote controller key Return to test mode mene Next signal L 13942296513 [CENTER MARKER] Display of signal for screen central location setting. [Operation specification] Operational description Remote controller key Return to test mode mene u163 MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Panel Assy. Panel Assy Removing the Tuner Amp Unit (Fig.3) Remove the three screws. Remove the screw. Remove the screw. Straighten the tabs at four locations indicated and then remove the Tuner Amp Unit. Fig.3 Tuner Amp Unit u163 MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Page 40
BT ANT PCB. Fig.4 BT ANT PCB Removing the Keyboard PCB (Fig.5) Remove the three screws. Remove the Knob Unit. (not shown) Remove the Cover from this position Fig.5 u163 and then remove the Keyboard PCB. Keyboard PCB Cover MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Page 41
Removing the Panel PCB (Fig.9) Remove the three screws and then remove the Holder and Panel PCB. u163 Fig.9 Panel PCB MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.) L 13942296513 u163 MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Page 49
13-2 Owner's Manual See Contrast table(2) Cover See Contrast table(2) 13-3 Quick Start Guide See Contrast table(2) (2) CONTRAST TABLE MVH-P8200BT/XNUC, MVH-8200BT/XNEW5, MVH-8250BT/XNES, MVH-P8200/XNUC, MVH-8200/XNEW5 and MVH-8250/XNES are constructed the same except for the following: MVH-P8200BT/ MVH-8200BT/ MVH-8250BT/ MVH-P8200/ MVH-8200/ MVH-8250/ Mark No.
Page 51
XBL7005 Screw See Contrast table(2) Keyboard Unit See Contrast table(2) Grille Assy See Contrast table(2) (2) CONTRAST TABLE MVH-P8200BT/XNUC, MVH-8200BT/XNEW5, MVH-8250BT/XNES, MVH-P8200/XNUC, MVH-8200/XNEW5 and MVH-8250/XNES are constructed the same except for the following: MVH-P8200BT/ MVH-8200BT/ MVH-8250BT/ MVH-P8200/ MVH-8200/ MVH-8250/ Mark No.
Page 53
Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. u163 Symbol indicates a capacitor. DCH1201-A 10uF/10v No differentiation is made between chip capacitors and discrete capacitors. BTH1200-A 1.0uH BTH1201-A 2.2uH NM : No Mount MVH-P8200BT/XNUC http://www.xiaoyu163.com...
: The power supply is shown with the marked box. DCH1201-A 10uF/10v BTH1200-A 1.0uH The > mark found on some component parts indicates BTH1201-A 2.2uH the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board. IC 301 (A, 91, 111) IC NJM2068V Circuit Symbol and No. Part No. Circuit Symbol and No. Part No. A:MVH-P8200BT/XNUC Unit Number : CXX2822(A) B:MVH-8200BT/XNEW5 Unit Number : CXX2823(B) C:MVH-8250BT/XNES Unit Number : CXX2821(C) D:MVH-P8200/XNUC...
Page 102
(A,14,93) Fuse 3 A CEK1286 >P1731 D 342 (A,84,21) Diode DZ2S068C (A,15,60) Fuse 1.5 A CEK1282 D 343 (A,84,19) Diode DZ2S068C P 1901 (A,139,36) Poly Switch MINISMDC075F/24 D 344 (A,81,19) Diode DZ2S068C BZ601 (A,142,48) Buzzer CPV1062 CN351 (A,77,10) Plug CKS3537 MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Page 103
R 564 (A,156,124) RS1/16SS390J R 222 (A,137,124) RS1/10SR0R0J R 565 (A,144,124) RS1/16SS390J R 223 (A,143,101) RS1/16SS473J R 566 (A,153,124) RS1/16SS390J R 224 (A,122,110) (A B C) RS1/16SS0R0J R 567 (A,140,129) RS1/16SS223J R 568 (A,149,129) RS1/16SS223J R 251 (A,76,36) RS1/10SR0R0J MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Page 104
R 665 (A,124,62) (A B C) RS1/16SS473J R 816 (A,64,54) RS1/16SS103J R 667 (A,136,69) (A B D E) RS1/16SS223J R 817 (A,65,55) RS1/16SS103J R 668 (A,137,84) RS1/10SR0R0J R 818 (A,66,55) RS1/16SS103J R 669 (A,120,94) RS1/10SR0R0J R 819 (A,67,54) RS1/16SS103J MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Page 105
(A,45,61) RAB4CQ560J R 1628 (A,119,106) RS1/16SS0R0J R 909 (A,48,61) RAB4CQ560J R 1629 (A,119,105) RS1/16SS4701D R 910 (A,55,76) RS1/16SS560J R 1630 (A,116,105) RS1/16SS0R0J R 911 (A,52,72) RS1/16SS0R0J R 1632 (A,107,107) RS1/16SS0R0J R 921 (A,55,20) RS1/10SR0R0J R 1633 (A,99,111) RS1/10SR681J MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Page 106
C 566 (A,153,121) 4.7 uF CCG1201 C 209 (A,126,105) (A B C) CKSRYB105K10 C 567 (A,161,130) CKSRYB103K50 C 210 (A,146,106) CKSRYB105K10 C 581 (A,34,115) (A D) CKSSYB102K50 C 211 (A,126,104) (A D) CKSRYB105K10 C 582 (A,34,114) (A D) CKSSYB102K50 MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Page 107
(A,59,102) CEAT332M16(P35) C 835 (A,86,74) CKSSYB104K10 C 1621 (A,121,115) CKSSYB104K16 C 836 (A,87,81) 10 uF DCH1201 C 1624 (A,108,103) CKSSYB103K16 C 837 (A,86,76) CKSSYB104K10 C 1625 (A,115,115) 4.7 uF CCG1222 C 838 (A,83,51) CCSSCH8R0D50 C 1626 (A,114,106) CKSSYB104K16 MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Page 108
(B,41,26) LED NSSM025A-A0886 D 5001 (B,100,36) Diode HZM6.8Z4MWA R 5008 (A,100,19) RS1/16SS0R0J R 5009 (B,98,18) RS1/16SS0R0J D 5002 (B,93,22) Diode DZ2S068C R 5010 (B,98,20) RS1/16SS0R0J D 5003 (B,91,16) Diode DZ2S068C R 5011 (B,92,18) RS1/16SS223J D 5004 (A,100,16) Diode DZ2S068C MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Page 109
R 5544 (B,63,23) RS1/16SS102J C 5502 (B,32,15) CKSRYB105K10 C 5503 (B,54,50) CKSSYB104K10 R 5545 (B,40,9) RS1/16SS0R0J C 5504 (A,34,40) 10 uF DCH1201 R 5546 (B,52,14) RS1/16SS105J R 5547 (B,50,16) RS1/16SS220J C 5505 (B,42,46) CSZS100M10 R 5548 (B,49,14) RS1/16SS332J MVH-P8200BT/XNUC http://www.xiaoyu163.com...
Page 110
CKSSYB104K10 C 7504 (A,25,23) CCSSCH180J50 C 7505 (B,20,14) CCSSCH180J50 C 7506 (B,22,13) CCSSCH180J50 C 7508 (A,31,13) CCSSCH180J50 C 7509 (A,33,13) CCSSCH180J50 C 7510 (A,20,11) CKSSYB104K10 C 7511 (B,33,32) CKSSYB104K10 C 7512 (B,32,17) CKSSYB104K10 Miscellaneous Parts List u163 CWX3869 MVH-P8200BT/XNUC http://www.xiaoyu163.com...