Examination And Solutions For Other Problems - Haier AFD631GW Service Manual

SERVICE MANUAL
Model:AFD631GW/GB/GR

8-2 Examination and Solutions for Other Problems

Problems
Water/moisture/frost in the refrigerator
Moisture accumulates
on the refrigerators
inner walls
Water/moisture/frost on outside surface of the refrigerator
Moisture accumulates
on the refrigerator's
outside surface or
between two doors
Refrigerator operation
The compressor does
not work
The fridge storage
compartment does not
work
The refrigerator runs
frequently or runs for
too long period
Causes
Hot and moist climate.
The door is not closed
tightly
The door is opened too
frequently or for too long
time
Damp climate
The refrigerator door is
not closed tightly. This
causes mixing of the cold
air in the refrigerator with
the warm air outside it
The refrigerator is in
defrosting cycle.
The refrigerator is not
plugged into a power
outlet.
The refrigerator is in OFF
state.
The air door cable is not
connected properly.
The fan does not work
The fridge storage
compartment is turned
off
The indoor or outdoor
temperature is high
The refrigerator has been
powered off for a period
of time.
The automatic icemaker
is operating.
The door is opened too
frequently or for long
periods.
The door of the fridge /
freezer storage
compartment is not
tightly closed.
The temperature setting
for the freezer storage
compartment is too low
The door gasket of the
28
Issue 201003
Rev. Ref11003S006V0
Solutions
Accumulation of frost
accelerate in such climate.
Make sure the refrigerator is level and there
is no food or container interfering with the
door
Do not open the door so frequently
It is normal in damp climate. The moisture
will decrease when the humidity drops.
Make sure the refrigerator is level and there
is no food or container interfering with the
door
It is normal for an automatic defrosting
refrigerator.
Verify the plug is plugged in the socket
firmly.
Press the "Power" button for 3 second or
more to restart the refrigerator or turn the
knob from OFF to temperature selection
position.
Check if the air door cable is not connected
properly and install it correctly if not so.
Verify that the air door acts normally with
the Fridge ON/OFF key on the display
panel
The fan does not work
refrigeration air door is open. Please check
if the door on-off behind the front decoration
strip is installed properly. Reinstall it
correctly if not so.
Turn on the fridge storage compartment
manually
In this case, it is normal for the refrigerator
to run longer.
Normally, it takes 8 to 12 hours for the
refrigerator to totally cool down.
Icemaking process makes the refrigerator
to run longer.
Warm air enters the refrigerator and causes
it to start frequently. Please do not open the
door so frequently.
Make sure the refrigerator is level place and
there is no food or container interfering with
the door.
Set the temperature higher until satisfactory
refrigerator temperature is obtained. It takes
24 hours for the refrigerator temperature to
become stable.
Clean or replace the door gasket. Leakage
gap of door gasket can cause longer
28
and moisture
while the