Table of Contents
Advertisement
1-800-836-7432
Warning!
Improper installation,
adjustment. alteration, service
or maintenance can cause
injury or property damage.
Please read instructions before
installing, operating or
servicing the
TOPAZ
Ave rtissement !
Le fait de modifier ou de mal
g
installer. re
ler. reparer ou
entretenir cet appareil peut
entrainer des blessures ou des
dommages materiels. On doit
lire attentivement les directives
d' installation. (I' utilisation et
cl'entretien avant de manipuler
l'unite TOPAZ
This manual is the property of
the owner. Leave with the unit
when set-up and start-up are
complete. RUPP Industries
reserves the right to change
design and specifications
without prior notice.
141 kinclerkarnack Rd. Park Ridge. NJ 07655 Tel. 201-782-1782 Fax. 201-782-1783 Web: www.amgaircorn Email: info@amgaircom
OTomx
Unit Specifications
Rating Information ..................................................................
Inspection
General Description ..................................................................
General Requirements ..............................................................
Standard Features
Optional Features
Installation Instructions ............................................................
Unit Operation ..........................................................................
Preventative Maintenance ........................................................
Troubleshootin
g
Installin
Replacement Parts ....................................................
Accessories
Replacement-Parts List ............................................................
g
Wirin
Schematic. TZ-12A, TZ-24A and TZ-36A ..................
unit.
Wiring Schematic. TZ-18A ......................................................
Wiring Schematic, TZ-60A ......................................................
g
Wirin
Sc he in at ic TZ-60A4 ....................................................
Air Marketing Group LLC
Portable Air Conditioners
Owner's Manual
g
Guide ............................................................
3
3
4
4
4
4
5
6
6
7
8
10
11
12
15
16
17
18
Built Right First...
To Last!"
Advertisement
Table of Contents
Related Manuals for Topaz TZ-12A
Summary of Contents for Topaz TZ-12A
- Page 1 Accessories injury or property damage. Please read instructions before Replacement-Parts List ............installing, operating or Wirin Schematic. TZ-12A, TZ-24A and TZ-36A ....servicing the unit. TOPAZ Wiring Schematic. TZ-18A ............Wiring Schematic, TZ-60A ............Ave rtissement !
-
Page 2: Unit Specifications
Portable Jr i Conditioners Unit Specifications control thermostat condensate-tank full light evaporator-exhaust evaporator screen return-air screen evaporator coil with filter condensate-tank access door condensate tank heavy duly casters side view front view Rating Information 11111=TIMPIEM -6044 TZ-6 Cooling Capacity, BTU/fir' 14,000 17,600 29,600... -
Page 3: General Description
Freeze Protection Control operation and ru ed dependability. Follow installation The TZ-12A, 24A, 36A, 60A and 60A4 models are and maintenance instructions completely. Fill out and equipped with an automatic freeze protection control. return the warranty registration card within 30 days of This control turns the compressor off if moisture on the purchase to register the warranty. -
Page 4: Optional Features
A hose runs from the unit to a convenient drain or outdoor location. Filter Cord Kit (LCDI) (TZ-12A, 18A, 24A, 36A) All units are equipped with removable, washable. The LCDI cord set provides both personal shock as well aluminum-mesh air filters. Located behind the return-air as cord arcing and fire protection. -
Page 5: Installation Instructions
Filters Note: Extension cords may be used if rated at a minimum 120-V, 20-amp for models TZ-12A A clogged filter causes the unit to operate at reduced and TZ-18A or 230-V. 20-amp for model TZ- efficiencies. Inspect filter every six weeks, or more, if 24A. - Page 6 Do not allow water to enter condenser fan outlet or the thermostat. Belt Tension, (models TZ-604 TZ-60A4 only) Topaz models TZ-60A and TZ-60A4 are equipped with adjustable sheaves on the evaporator and condenser fans. Conditioned-air and condenser-air are controlled using double-inlet, forward-curved fans driven by belt and sheave combinations.
-
Page 7: Troubleshooting Guide
Check for defective condenser fan motor. Replace if necessary. Restricted duct. Wait 5 min for timer to allow compressor to restart, Short cycle timer not timed out (TZ-12A. 24A, 36A, and 60A only) Compressor contactor open or burned Replace. Refrigerant leak - no freon Locate leak and repair. - Page 8 Portable Air Conditioners Problem Cause Remedy Insufficient cooling Insufficient airflow through evaporator See Preventive Maintenance section of this manual. coil due to: -Dirty air filter in unit - Clean filter. -Dirty evaporator coil -Clean filter with a vacuum cleaner and hose. -Ice on evaporator coil - Defrost, Run on fan only.
-
Page 9: Installing Replacement Parts
5. Install hose from drain pan to the pump inlet. 6. Remove plu from hole in side of unit. TOPAZ' Owner Manual Air Marketing Group LLC 141 kinrierkarnack Rd. Park Ridge, NJ 07656 Tel: 201-782-1782 Fax: 201-782-1783 Web: vwvw.amgair.corn Email: info@amgaircom... - Page 10 Portable Jr i Conditioners Accessories ceiling discharge kit condensate pump kit Part Clasc ript.i on NK-1 two, 4-in nozzles with attachment kit, TZ-12 NK-2 two, 6-in nozzles with attachment kit. TZ-1 TZ-24 and TZ-36 NK-3 two, 8-in nozzles with attachment kit, TZ-60 CK-1 10-in ceiling discharge kit, TZ-12 CK-2 14-in ceiling discharge kit, TZ-24...
-
Page 11: Replacement Parts List
85601.713 • evaporator-motor capacitor 85601.724 85601.714 85601.723 85601.727 85601.724 • condenser-motor capacitor 85601.021 • • two 85601.713 • TOPAZ" Owner's Manual Air Marketing Group LLC 141 kinrierkarnack Rd. Park Ridge, NJ 07656 Tel: 201-782-1782 Fax: 201-782-1783 Web: vwvw.amgair.corn Email: info@amgaircom... - Page 12 Portable Air Conditioners tilFtE Part TZ• 1 TZ•B OA TZ• BOA4 Oascript.ion compressor-motor capacitor 8560 1.728 • • 8560 1.722 • 8560 1.715 • 8560 1.716 • 8560 1.732 • • • 82900.254 supply cordset 82900.255 • 82900.256 • 88000.043 •...
- Page 13 Replacement Parts continued Description Part No. TZ-12A TX. 1 BA 1Z-24A 1T-.3B UTZ-BCIA TZ.130A. • high pressure switch 87500.143 • 87500.109 manual thermostat • • • • • • 87800.102 condensate tank 99900.299 • • • • • • condensate pan adjusting spring •...
- Page 14 Portable, Industrial Jr i Conditioners Wiring Schematic, TZ-12A,17-24A and TZ-36A Voltage Phase JniTt 12-12A 60 5-15P Es imperial or 12-24A 208/230 1 BO B-20P Ste fie r Start Coal:Kik:sr 17-35A 2133/230 1 BO 6-30P 1—° @ AL l< Plug# Locations...
- Page 15 Condon sate Puma J1-5 R eqired when PC-1 is not instal 11 n1 Overflow Switch J1-8 BR <-0 TOPAZ' Owner Manual Air Marketing Group LLC 141 kinrierkarnack Rd. Park Ridge, NJ 07656 Tel: 201-782-1782 Fax: 201-782-1783 Web: vwvw.amgair.corn Email: info@amgaircom...
-
Page 16: Wiring Schematic, Tz-60A
Portab]e, Industrial Jr i Conditioners Wiring Schematic, TZ-60A 20B/220V 1 Phone 50 Hertz — Locations Evaporator Compartment J2 Co nde mote Comport rne nt Evoponotor Blower Motor l'oc Cm den ste;tf prinioear Overload Contact Fre, rtOF Control J1- Jumper Plug A AZ8)0.1 GS Optional Condendate Pump P/N PC J -5... -
Page 17: Wiring Schematic, Tz-60A4
J1 3 ' M r Nqined when PC-1 in not installel Oa ridonsots Pump Overf I r.. Sectch TOPAZ Owner's Manual Air Marketing Group LLC 141 kinrierkarnack Rd. Park Ridge. NJ 07656 Tel: 201-782-1782 Fax: 201-782-1783 Web: vwvw.amgair.corn Email: info@amgaircom... - Page 18 One Rupp Plaza 3700 West Preserve Boulevard Burnsville. Minnesota 55337-7746 1-800-836-7432 Air Marketing Group LLC 141 kinclerkarnack Rd. Park Ridge. NJ 07655 Tel. 201-782-1782 Fax. 201-782-1783 Web: vwvw.amgaircom Email: info@amgaircom...
Need help?
Do you have a question about the TZ-12A and is the answer not in the manual?
Questions and answers