Table Of Contents - Monogram ZGG48N42 Installation Instructions Manual

Before you begin-Read these instructions completely and carefully.
IMPORTANT: Save these instructions for local inspector's use.
IMPORTANT: OBSERVE ALL GOVERNING CODES AND ORDINANCES.
NOTE TO INSTALLER: Be sure to leave these instructions with the Consumer.
NOTE TO CONSUMER: Keep these instructions with your Use and Care Book for
future reference.
If you received a damaged cooking center, you
should contact your dealer.
Installation of this cooking center requires basic
mechanical skills. Proper installation is the responsi-
bility of the installer.
For Monogram local service in your area,
1-800-444-1845.
For Monogram service in Canada, 1-888-880-3030.
For Monogram Parts and Accessories, call
1-800-626-2002.
CAUTION:
• For outdoor use only. Use this cooking center
• This outdoor cooking gas appliance is not
• Do not use the grill in an explosive atmosphere.
• Observe proper clearances to combustible
• Do not use a rusty or damaged LP tank.
• Never substitute gases (natural for LP or LP for
• When storing the grill indoors, disconnect the LP
• Do not store additional LP tanks in or near the gas
• Follow the guidelines on the LP tank for proper
• LP models are supplied with a 20 lb. LP tank
• The supplied LP tank is equipped with an overfill
Models Available .................................................. 3
Contents
Accessories ............................................................ 3
Product Dimensions & Clearances ..................... 4
Advance Planning ................................................ 5
Choosing the Location ........................................ 5
Tools & Materials Required ................................ 5
Step 1: Remove the Packaging ............................ 6
Step 2: Provide Support ....................................... 7
Step 3: Provide Gas & Electrical Supply ............. 9
2
FOR YOUR SAFETY:
Do not use cooking center in a space where
gasoline or other liquids having flammable
vapors are stored or used.
only in the manner intended by the manufacturer.
intended to be installed in or on recreational
vehicles and/or boats.
Keep the grill away from areas where gasoline or
other flammable liquids and vapors are stored or
being used.
materials at all times.
natural). These grills are factory set for LP or
natural gas. Order the model for your installation
situation.
tank. Store the tank outdoors in a well ventilated
area.
grill.
storage, transport and handling.
(shipped separately) equipped with a Type 1 Acme
connector. The supplied regulator has a mating
connector.
protection device. If you utilize a tank exchange
system, be sure to exchange this tank for a tank
with the same device.
Built-In Installations ..................................... 7, 8
In the Commonwealth of Massachusetts:
• This product must be installed by a licensed
plumber or gas fitter.
• When using ball type gas shut off valves, they
shall be T-handle type.
• A flexible gas connector, when used, must not
exceed 3 feet.
IF YOU SMELL GAS:
• Shut off gas to appliance.
• Extinguish any open flame.
• Open lid.
• If odor continues, immediately call your
gas supplier.
• Tested in accordance with ANSI Z21.58 latest
edition standard for outdoor cooking gas
appliances. This grill is for outdoor use only.
Check local building codes for the proper method
of installation in the absence of local codes, this
unit should be installed in accordance with the
National Fuel Gas Code No. Z223 latest edition
and the National Electrical Code ANSI/NFPA
no. 70, latest edition.
CALIFORNIA PROPOSITION 65 - WARNING
The burning of gas cooking fuel generates some by
products that are on the list of substances which
are known by the State of California to cause
cancer or reproductive harm. California law
requires businesses to warn customers of potential
exposure to such substances. To minimize expo-
sure to these substances, always operate this unit
according to the use and care manual, ensuring
you provide good ventilation when cooking with
gas.
INSECT WARNING!
Spiders and insects can nest in the burners of this
and any other grill, and cause the gas to flow from
the front of the burner. This is a very dangerous
condition which can cause a fire to occur behind
the valve panel, thereby damaging the grill and
making it unsafe to operate. Inspect the grill twice
a year or immediately if any symptoms appear.
LP Gas Models .................................................. 9
Natural Gas Models .......................................... 9
Electrical Supply ............................................. 10
Step 4: Test for Leaks ......................................... 10
Step 5: Check Burners,
Replace Drip Trays and Grates ..................... 11
Step 6: Lighting the Grill .................................. 12
Step 7: Adjusting the Burners ........................... 13
Install Rotisserie ................................................. 14
Install Access Doors ........................................... 15