DHT-500SD MODEL Please refer to the MODIFICATION NOTICE. HOME THEATER SYSTEM HOME THEATER SYSTEM (DHT-500SD) consists of DVD SURROUND RECEIVER (ADV-500SD) and SPEAKER SYSTEM (SYS-500SD). L 13942296513 For purposes of improvement, specifications and design are subject to change without notice.
Page 2
DHT-500SD 3 7 6 3 1 5 1 5 0 SAFETY PRECAUTIONS The following check should be performed for the continued protection of the customer and service technician. LEAKAGE CURRENT CHECK Before returning the unit to the customer, make sure you make either (1) a leakage current check or (2) a line to chassis resistance check.
Page 3
http://www.xiaoyu163.com 3 7 6 3 1 5 1 5 0 FRONT P.W.B. UNIT ASS'Y MAIN P.W.B. UNIT ASS'Y VFD P.W.B. MECHANISM(DVD LOADER:RL-874) P.W.B. UNIT ASS'Y ST92F150CVT1 HEAD PHONE P.W.B. CONNECTING P.W.B. FROM DVD LOADER (TO VFD P.W.B. and Main P.W.B. UNIT ASS'Y) L 1 3 9 4 2 2 9 6 5 1 3 AMP P.W.B.
Page 4
DHT-500SD LEVEL DIAGRAM 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 http://www.xiaoyu163.com...
Page 5
DHT-500SD SEMICONDUCTORS / 3 7 63 1515 0 Only major semiconductors are shown, general semiconductors etc. are omitted to list. IC's Note: Abbreviation ahead of IC No. indicates the name of P.W.B., etc. ): IC No. AMP: AMP P.W.B.
Page 9
DHT-500SD 3 7 63 1515 0 Pin No. Pin Name Type Description XSSBAD Sub-beam addition signal input Phase detector reference current generator. Connect a resistor between this pin and XSPDIREF ground to set reference current Frequency detector reference current generator. Connect a resistor between this pin and...
Page 10
DHT-500SD 3 7 63 1515 0 Pin No. Pin Name Type Description XHPDIAGJ This pin is used as the Passed Diagnostics signal, and may be an input or an open-drain output This pin is used as the Drive Active/Slave Present signal, and is an input or an open-drain XHDASPJ output.
Page 11
DHT-500SD 3 7 63 1515 0 SP3721A (ME: U2) DVDRFP SDEN DVDRFN SDATA SCLK TOP VIEW MEVO MLPF L 13942296513 SP3721A Terminal Function Pin No. Type Description Pin Name 1, 2 DVDREP , DVDREN RF Signal Inputs. Differential RF signal attenuator input pins CDRF RF Signal Inputs.
Page 12
DHT-500SD 3 7 63 1515 0 Pin No. Pin Name Type Description Center Error Signal Output. Center error output reference to VCI NEVO SIGO Bottom Envelope Output. Bottom envelope for mirror detection Defect Output. Pseudo CMOS output. When a defect is detected, the DFT output goes high. Also the servo AGC output can be monitored at this pin, when CAR bits 7-4 are ‘0011’...
Page 17
DHT-500SD AT49F001N-70JC(ME:U3) 3 7 63 1515 0 Pin Configurations Pin Name Function A0 - A16 Addresses Chip Enable Output Enable Write Enable RESET RESET I/O0 - I/O7 Data Inputs/Outputs I/O0 I/O7 No Connect Don’t Connect *Note: This pin is a DC on the AT49F001N(T).
Page 18
DHT-500SD FAN8423D3TF(ME:U7) 3 7 63 1515 0 Absolute Values Current Sense Output Current Limit Hall Amp Pin Definitions Pine Number Pin Name Pin Function Description No connection Output (A3) No connection Output (A2) No connection No connection Output (A1)
Page 19
DHT-500SD 3 7 63 1515 0 SN74HCU04PWR (ME: U8) AT24C02N(ME: U13) Block Diagram L 13942296513 V6309M(ME: Q5) NPC1117ST20T3(ME: Q4) LM117S-3V3 (DS:IC33) LM117S-2V5 (DS:IC32) ADJ/GND KA 78L08AZ (SM: IC93) KA 79L08AZ (MA: IC17) FRONT FRONT VIEW VIEW u163 http://www.xiaoyu163.com...
Page 35
PRINTED WIRING BOARD DHT-500SD 3 7 6 3 1 5 1 5 0 MAIN P.W.B. UNIT ASS’Y COMPONENT SIDE MAIN P.W.B. UNIT ASS’Y FOIL SIDE 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 http://www.xiaoyu163.com...
Page 36
DHT-500SD AMP P.W.B. UNIT ASS’Y FOIL SIDE AMP P.W.B. UNIT ASS’Y COMPONENT SIDE 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3...
Page 37
DHT-500SD DSP P.W.B. UNIT ASS’Y COMPONENT SIDE DSP P.W.B. UNIT ASS’Y FOIL SIDE 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3...
Page 38
DHT-500SD FRONT P.W.B. UNIT ASS’Y COMPONENT SIDE SMPS P.W.B. UNIT ASS’YCOMPONENT SIDE 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3...
Page 39
DHT-500SD MECHANISM P.W.B. UNIT ASS’Y COMPONENT SIDE MECHANISM P.W.B. UNIT ASS’Y FOIL SIDE 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3...
Page 40
http://www.xiaoyu163.com DHT-F500SD NOTE FOR PARTS LIST 3 7 63 1515 0 • Part indicated with the mark "nsp" are not always in stock and possibly to take a long period of time for supplying, or in some case supplying of part may be refused.
Page 41
DHT-500SD PARTS LIST OF P.W.B. UNIT ASS'Y 3 7 63 1515 0 MAIN P.W.B. UNIT ASS’Y Ref.No. Part No. Part Name Remarks SEMICONDUCTORS GROUP IC10 00D 943 0038 300 IC ST92F124V1T6 HVIST92F124V1T6 IC11 00D 943 0020 004 IC ROHM (BH7862FS)
Page 42
DHT-500SD Ref.No. Part No. Part Name Remarks 3 7 63 1515 0 RESISTORS GROUP R588 00D 943 0035 303 FUSE 0.47 OHM , 1W , J KRQ1CJR47 CAPACITORS GROUP C001 00D 943 0043 706 CHIP 0.022uF , 50V , KC...
DHT-500SD EXPLODED VIEW 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 11-3 11-1 11-2 w w w WARNING: u 1 6 3 Parts marked with this symbol have critical characteristics.
Page 62
DHT-500SD PARTS LIST OF EXPLODED VIEW 3 7 63 1515 0 Safe. Part No. Part Name Remarks Q'ty 11-1 943 0033 703 PCB, POWER COP11674B 11-2 943 0033 703 PCB, FRONT COP11674B 11-3 943 0033 703 GUIDE PCB ASS'Y...
Page 64
DHT-500SD EXPLODED VIEW OF DVD MECHANISM UNIT 3 7 63 1515 0 L 13942296513 PARTS LIST OF DVD MECHANISM UNIT Ref. No. Part No. Part Name Remarks Q'TY 943 0010 302 COVER,TOP LABEL,MODEL 943 0010 409 CLAMP,TOP 943 0010 603...
Page 65
DHT-500SD ADV-500SD PACKING VIEW 3 7 63 1515 0 PARTS LIST OF PACKING & ACCESSORIES L 13942296513 Ref. No. Part No. Part Name Remarks Q'ty 943 0030 007 BOX, OUT CARTON CPG1A753Z 943 0022 303 BAG, POLY CPB1A160Y 943 0030 104...
Page 66
DHT-500SD SYS-500SD SPEAKER PACKING VIEW 3 7 63 1515 0 PARTAS LIST OF PACKING & ACCESSORIES(SPEAKER) L 13942296513 Ref. No. Part No. Part Name Remarks Q'ty 00D 9H3 0001 470 SUB-WF S/S 395558 00D 9H3 0001 471 PROTECT SHEET...
Page 67
DHT-500SD SC-A500SD EXPLODED VIEW 3 7 63 1515 0 SC-A500SD PARTS LIST OF EXPLODED VIEW Ref.No. Part No. Part Name Remarks Q'ty 00D 9H3 0001 472 SC-A500SD 395560 00D 9H3 0001 373 GRILLE ASS'Y(S) 387801 SC-C500SD EXPLODED VIE L 13942296513 SC-C500SD PARTS LIST OF EXPLODED VIEW Ref.No.
Page 69
DHT-500SD NOTE FOR SCHEMATIC DIAGRAM 3 7 63 1515 0 1. WARNING: Parts marked with this symbol have critical charac- teristics. Use ONLY replacement parts recommended by the manufacturer. 2. CAUTION: µ Before returning the unit to the customer, make sure you make either (1) a leakage current check or (2) a line to chassis resistance check.
Page 70
DHT-500SD SCHEMATIC DIAGRAMS (1/12) 3 7 6 3 1 5 1 5 0 FRONT BOARD 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 SCHEMATIC DIAGRAMS (1/12) FRONT UNIT http://www.xiaoyu163.com...
Page 71
DHT-500SD SCHEMATIC DIAGRAMS (2/12) 3 7 6 3 1 5 1 5 0 ST92F150CVT1 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 SCHEMATIC DIAGRAMS (2/12) MAIN UNIT OPEN OPEN...
Page 72
DHT-500SD SCHEMATIC DIAGRAMS (3/12) 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 MX29LV400 w w w u 1 6 3 SCHEMATIC DIAGRAMS (3/12) DSP UNIT http://www.xiaoyu163.com...
Page 73
DHT-500SD SCHEMATIC DIAGRAMS (4/12) 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w SIGNAL(SP OUT) u 1 6 3 SCHEMATIC DIAGRAMS (4/12) AMP UNIT (1/2)
Page 74
DHT-500SD SCHEMATIC DIAGRAMS (5/12) 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w SIGNAL(SP OUT) u 1 6 3 SCHEMATIC DIAGRAMS (5/12) AMP UNIT (2/2)
Page 75
DHT-500SD SCHEMATIC DIAGRAMS (6/12) 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 SCHEMATIC DIAGRAMS (6/12) SMPS UNIT http://www.xiaoyu163.com...
Page 76
DHT-500SD SCHEMATIC DIAGRAMS (7/12) 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 SCHEMATIC DIAGRAMS (7/12) MECHANISUM BOARD (1/6) ES6028 RC1117-285T Open 4.7Kohm...
Page 77
http://www.xiaoyu163.com DVD-770SD SCHEMATIC DIAGRAMS (8/12) 3 7 6 3 1 5 1 5 0 CS4392 DVD-310 : OPEN 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 SCHEMATIC DIAGRAMS (8/12) MECHANISM BOARD (2/6) AUDIO_DAC http://www.xiaoyu163.com...