KTM ENDURO 640 LC4 Owner's Manual page 48

TROUBLE SHOOTING
TROUBLE
High oil consumption
Headlight and parking light fail
Flasher lights, brake light, fan and
horn fail
The NEUTRAL lamp is not on even
though the gear is in NEUTRAL
The battery is discharged
No values are visible in the
Tripmaster display
No speed display.
»
CAUSE
Buckling gear ventilation hose
Engine oil level too high
Engine oil too thin (viscosity)
Blown fuse
Blown fuse
Defect neutral switch.
Loose connections, defect cable.
The ignition (power consumer) has-
n't been switched off
The battery isn't charged by the gen-
erator because
Main fuse melted through
Defective sensor cable or oxidized
socket connector.
REMEDY
Readjust or replace ventilation hose
Check engine oil level when the engine is warm; correct if
necessary
Use thicker engine oil; see chapter „Engine oil"
Enduro: Replace fuse (5).
Supermoto: Replace fuse (4).
Enduro: Replace fuse (4).
Supermoto: Replace fuse (3).
Connect cable to ground; neutral switch must be replaced
if indicator lamp lights up.
Check connections and cables.
echarge the battery according to the relevant instructions.
Remove seat and check voltage regulator connections; volt-
age regulator and generator should be checked by a KTM
dealer.
Replace the main fuse under the seat
Check the sensor cable for damage and replace it if
necessary.
Remove the headlight mask and check the socket
connector.
Contact a KTM dealer.
47