Table of Contents
Advertisement
Quick Links
Coyote Power Burner
For Liquid Propane and Natural Gas Models
Conforms to ANSI
STD Z21.58a-2008
Certificated to CSA
STD 1.6a-2008
4006980
IMPORTANT: Read the lighting instruction on Page 11 before first time use!
To installer or person assembling power burner: Leave this manual with power burner
for future reference.
To consumer: Keep this manual for future reference.
COYOTE OUTDOOR LIVING, INC.
www.coyoteoutdoor.com
Use & Care Manual
Coyote Power Burner
CPBLP & CPBNG
PUT SERIES NO. LABEL HERE
For Outdoor Use Only
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Coyote CPBLP
Summary of Contents for Coyote CPBLP
- Page 1 Coyote Power Burner Use & Care Manual For Liquid Propane and Natural Gas Models Coyote Power Burner CPBLP & CPBNG Conforms to ANSI For Outdoor Use Only STD Z21.58a-2008 Certificated to CSA STD 1.6a-2008 PUT SERIES NO. LABEL HERE 4006980...
- Page 2 Welcome & Congratulations Congratulations on your purchase of a new power burner! We are very proud of our product and we are completely committed to providing you with the best service possible. Your satisfaction is our #1 priority. Please read this manual carefully to understand all the instructions about how to install, operate and maintain for optimum performance and longevity.
-
Page 3: Table Of Contents
Table of Contents Safety Instructions…..... 2 WARNING • Locating the Power burner ..4 Gas Requirements ......6 IF YOU SMELL GAS: Using Your Power Burner..…...11 1. Shut off gas to the appliance. Lighting Your Power Burner……..11 2. Extinguish any open flame. Care &... -
Page 4: Safety Instructions
Safety Instructions WARNING: Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Read the installation, operating and maintenance instructions thoroughly before installing or servicing this equipment. General Safety Instructions For Household Outdoor Use Only – DO NOT use indoors or in any type of enclosed area such as a garage, shed or breezeway. - Page 5 placed away from walkways to avoid tripping hazard. 17. Keep gas supply lines as short as possible. 18. Never move the power burner when hot. 19. DO NOT use while under the influence of drugs or alcohol. 20. DO NOT store a spare gas cylinder under or near your power burner. 21.
-
Page 6: Locating The Power Burner
The vents that are required to honor a Coyote warranty, not only ensure that any heat that is trapped inside your power burner from environmental factors (such as wind) escape but they also allow any gas that has leaked from a tank or connection, to escape before a buildup of such gas can occur and possibly ignite. - Page 7 combustible material without an approved ventilation system directly located above the unit. For Built-in Installations A built-in power burner is designed for easy installation into masonry enclosures. For non-combustible applications, the power burner drops into the opening (as shown in cut-out detail drawing - Fig. A) and hangs from the power burner body itself.
-
Page 8: Gas Requirements
Gas Requirements NOTE: Always have a qualified service technician perform difficult conversions or modifications. WARNING: Never attach an unregulated gas line to the appliance. Connection to an unregulated gas line can cause excessive heat or fire. IMPORTANT: Before connecting power burner to gas source, make sure BBQ Power burner control knobs are in the “OFF”... - Page 9 in a Type 1 L.P. A Type 1 compatible cylinder with a Type 1 cylinder valve has a back-check valve which does not permit gas flow, until a positive seal has been obtained. The cylinder must be arranged for vapor withdrawal. It must also include a collar to protect the cylinder valve.
- Page 10 Pre-Operation Leak Testing DANGER 3. Do not insert any tool into the valve outlet or safety relief valve. You may damage the valve and cause a leak. Leaking propane may result in explosion, fire, severe personal injury, or death. 3. If a leak is detected at any time or you cannot stop a gas leak, immediately close pipeline valve and call LP gas supplier or you fire department.
- Page 11 Meaning that if your entire house is plumbed for propane and you have an exterior connection for such use, then a standard LP power burner from Coyote will meet your needs, regardless of the size. Any appliance can be installed if installed properly.
- Page 12 Test all connections for leaks with a soap and water solution. High Elevation Installation and Use Coyote power burners are designed to operate most efficiently at 0-2000 feet above sea level. From 2000-4000 feet above sea level you will not notice any substantial decrease in your heat, although more gas is combusting within the burners due to less oxygen.
-
Page 13: Using Your Power Burner
Using Your Power Burner Your power burner is designed to reach a temperature that you set by adjusting a valve that in turns adjusts the amount of gas that goes through each burner. This Valve is located behind your knob and is the key to your heat and fuel consumption. -
Page 14: Lighting Instructions
5. If at this point the power burner will still not ignite, you can try the manual lighting process below with a long stem lighter and you can also contact Coyote Customer Service for further assistance to troubleshoot your power burner. -
Page 15: Care & Maintenance
Care & Maintenance CAUTION: All cleaning and maintenance should be done only when power burner is cool & with the fuel supply turned off at the cylinder. If your power burner is set up for use with Natural Gas, turn off gas supply at the system manual shut off valve. DRIP TRAY The drip tray located below the power burner should be cleaned periodically to prevent heavy buildup of debris. - Page 16 Ways to Avoid Rust on your Grill: 1) Always purchase a Coyote Grill cover for your unit. This will ensure that your cover is correct fit and breathable, while providing the protection needed to keep all other contaminants off of the surface.
- Page 17 ANNUAL CLEANING OF POWER BURNER HOUSING Burn-off the barbecue after every cookout will keep it ready for instant use, however, once a year you should give the entire power burner a thorough cleaning to keep it in top operating condition. Shut off gas supply at source and disconnect fuel line.
-
Page 18: Troubleshooting
Troubleshooting Your Power burner GENERAL TROUBLE SHOOTING You should inspect the burners at least once a year or immediately if any of the following conditions occur: • The smell of gas. • Flames appearing mostly yellow. (Some yellow at the tips is OK) •... - Page 19 gap between the electrode and contact point. • Check for a loose wire connection at the electrode box. • Check to see if debris is blocking the electrodes. • If the igniter is not working, can you light the power burner with a lighter? Flare-ups •...
-
Page 20: Limited Warranty
Limited Warranty Coyote Outdoor warrants to the original purchaser at the original site of delivery with proof of purchase of each Outdoor Gas power burner/Side burner that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below. This warranty excludes power burners used in rental and commercial applications. - Page 21 discoloration which is considered normal wear and tear. This warranty does not cover the cost of any inconvenience, personal injury, or property damage due to improper use or product failure. Deterioration or damage due to severe weather conditions such as hail, hurricanes, earthquakes, tsunamis, tornadoes, terrorism, discoloration due to exposure to chemicals either directly or in the atmosphere, Acts of God/forces of Nature are not covered by this limited warranty.
-
Page 22: Parts Listing
CPB LP/NG Parts List CPB Parts Listing Description Part Number Description Part Number Main Nozzle CPB001 Side Plate CPB011 Oil Net CPB002 Control Panel CPB012 Fire Box CPB003 Knob Base CPB013 Fire Box Holder CPB004 Knob CPB014 Gas Pipe CPB005 Drip Tray CPB015 Valve...
Need help?
Do you have a question about the CPBLP and is the answer not in the manual?
Questions and answers