St. Croix Prescott Series Operation & Maintenance Manual
Hide thumbs
Also See for Prescott Series:
- Operation & maintenance manual (28 pages) ,
- Installation & operation manual (51 pages)
Table of Contents
Advertisement
Operation & Maintenance
ST. CROIX FEATURES .......................................................................................2
INSTALLATION.................................................................................................. 3
PREVENTING CHIMNEY FIRES .....................................................................3
SATISFACTORY PERFORMANCE................................................................. 3
APPROVED FUELS .............................................................................................3
Pellets, Cherry Pits & Pellet /Corn mix ...................................................3
OPERATING INSTRUCTIONS......................................................................... 4
Control Board Features.............................................................................4
Thermostat Function - How does it work? .............................................5
Pre-Lighting Instructions..........................................................................6
Lighting Your Stove ................................................................................. 6
Shutting the Stove off ............................................................................... 6
Diagnostic Features....................................................................................6
Safety Features ...........................................................................................7
Combustion Air Damper ...................................................................... 7-8
Flame Pattern Characteristics ..................................................................8
MAINTAINING THE STOVE ............................................................................9
Daily Maintenance ........................................................................... 10-11
Periodic Maintenance ...................................................................... 11-13
Yearly Maintenance ......................................................................... 13-14
SAFE OPERATION ........................................................................................... 14
TROUBLESHOOTING AND FAQ ............................................................ 15-19
PARTS LAYOUT .......................................................................................... 20-21
WARRANTY....................................................................................................... 22
Prescott Series
Manual
Table of Contents
208
Advertisement
Table of Contents
Related Manuals for St. Croix Prescott Series
Summary of Contents for St. Croix Prescott Series
-
Page 1: Table Of Contents
Prescott Series Operation & Maintenance Manual Table of Contents ST. CROIX FEATURES ..................2 INSTALLATION....................3 PREVENTING CHIMNEY FIRES ..............3 SATISFACTORY PERFORMANCE..............3 APPROVED FUELS .....................3 Pellets, Cherry Pits & Pellet /Corn mix ...........3 OPERATING INSTRUCTIONS................. 4 Control Board Features................4 Thermostat Function – How does it work? ..........5 Pre-Lighting Instructions................6... - Page 2 This owner's manual is designed to help you obtain maximum benefit from your St. Croix wood pellet stove. Please read this manual in its entirety BEFORE operating your pellet stove. During the manufacturing process every effort has been expended to ensure that each St.
-
Page 3: St. Croix Features
Prescott Series SAVE THIS OPERATIONS AND MAINTENANCE MANUAL Figure 1 Prescott Series Operations Manual Page 2... -
Page 4: Installation
Operation and Maintenance Prescott Series Wood Pellet Stove CAUTION: Operate this unit only with the fuel hopper lid closed. Failure to do so may result in emission of products of combustion from the hopper under certain conditions. Maintain hopper seal in good condition. -
Page 5: Operating Instructions
Diagnostic code. 9. An outside source of combustion air is required on all mobile home installations. If room air is used to supply combustion air, room air Prescott Series Operations Manual Page 4... -
Page 6: Thermostat Function - How Does It Work
SmartStat Mode – How does it work? The SmartStat Function on a St. Croix Pellet stove is the way a St. Croix operates as a Fully Automatic stove. A stove operating as a Fully Automatic stove works great when constant heat isn’t needed. -
Page 7: Pre-Lighting Instructions
This is where the “SmartStat” sure the Vacuum switch locks in. (See puts the St. Croix in a different category. The Diagnostic features in column to the right.) stove operates on a Thermostat and once the heat... -
Page 8: Safety Features
Daily Maintenance unresponsive you must unplug the stove, wait 10 seconds and plug the stove back in to reset the The St. Croix Pellet Stove has been Safety Tested board. by an accredited, independent laboratory. “Internal Alarm”. When the control board becomes unresponsive, the control board is in Internal Alarm. -
Page 9: Combustion Air Damper
(not the burn pot reacts to the change. Adjusting the enough combustion air) and should not be damper during the break in period is very overlooked. At the other end of the spectrum; an Prescott Series Operations Manual Page 8... -
Page 10: Maintaining The Stove
Required maintenance depends content. Every St. Croix Pellet stove model will largely upon the quality of pellet fuel burned and have the same system as shown in figure 5 below. the rate of burn. The amount of daily There is a 2-piece burnpot. -
Page 11: Daily Maintenance
CAUTION: Do not slam the door. Do not CLEANOUT operate the stove with a broken or cracked ROD PULL TOOL ASH PAN glass. Replace only with heat resistant ceramic glass supplied by the manufacturer. Figure 6 Prescott Series Operations Manual Page 10... -
Page 12: Periodic Maintenance
ASH CLEAN-OUT COVER (LEFT SIDE SHOWN) REMOVE SHIPPING SCREW & DISCARD THE LOCATION OF THE THIRD CLEAN-OUT/ASH REMOVE DECORATIVE TRAP BEHIND THE ASH PAN IN A PRESCOTT EXL GRILL (LEFT SIDE SHOWN) Figure 7 Prescott Series Operations Manual Page 11... - Page 13 Replace as needed. inner back. Figure 8 Prescott Series Operations Manual Page 12...
-
Page 14: Yearly Maintenance
Carefully clean or vacuum needed. (See fig. 8) any sawdust, cobwebs and household dust. Figure 9 Note: The Vacuum Switch may be removed to allow easier access to the combustion fan Prescott Series Operations Manual Page 13... - Page 15 “squealing” add some Anti-Seize to the Cam and Rod at both bushings. To gain access to the Versa Grate System in the Prescott Series open the right side panel when facing the stove. To locate the Rear Bushing assembly, follow the rod from the Shaft/Cage Weldment towards the front of the stove. The front bushing is located below the igniter in the front of the stove.
-
Page 16: Safe Operation
CAUTION: The Electrical Components of the stove are not Owner Serviceable. Call your dealer for proper diagnosis of electrical problems and service to those components. See Installations Manual for a copy of the Wiring Schematic. Prescott Series Operations Manual Page 5... - Page 17 If there is fuel in the hopper, check to see if there is an obstruction in the auger system or if the auger set screw is loose. Solution: Remove obstruction and re-light the stove or tighten the setscrew on the auger shaft. Prescott Series Operations Manual Page 15...
- Page 18 Check the fuse on the back of the control board. Replace with a 250 Volt, 5 Amp fuse. Part Number 80P20057-R Why is my glass dirty? Normal operation of your St. Croix stove will produce a white/tan build-up on the glass that wipes off with a dry paper towel. However, extended burning on the low setting only, will produce a darker tan color.
- Page 19 .25 seconds. This is the #1-Low setting, 1.25 seconds. The #1 Low setting will give less heat, but will also cause more build-up to form on the glass. Prescott Series Operations Manual Page 17...
- Page 20 9. Why is my glass dirty and how to use the Fan button to help correct it? Normal operation of your St. Croix stove will produce a build-up on the glass that should be wiped off on a daily basis.
- Page 21 Operations Manual and perform all the maintenance issues covered in the Daily and Periodic Maintenance section of the Manual. If the stove still does not operate correctly call your Dealer for Assistance. Prescott Series Operations Manual Page 19...
-
Page 22: Parts Layout
Prescott Series Parts Layout PART NUMBER DESCRIPTION 80P20003-R CONVECTION FAN 80P20038-R PROOF OF FIRE SWITCH 80P20001-R COMBUSTION FAN 80P52628-R VACUUM SWITCH 80P52629-R MANUAL RESET HIGH LIMIT 80P22348-R CONTROL BOARD 80P30045-R T-STAT WIRE TERMINAL 80P52630-R WIRING TERMINAL BLOCK 80P20278-R AUGER MOTOR... - Page 23 80P30191-R AUGER MOTOR RETAINER BRACKET 80P52658-R CONTROL BOARD COVER 80P53785-R CONTROL BOARD MOUNT BOX 80P53681-R SLIDE TOP STANDOFF PLATE 80P20183-R PLASTIC HOPPER HANDLE 80P52944-R HEAT EXCHANGE BAFFLE 80P20033-R GLASS FOR CAST DOOR 80P53707-R DOOR HANDLE 80P53694-R HANDLE MOUNT PLATE ASSEMBLY 80P20036-BN NICKEL COIL FOR DOOR HANDLE 80P20036-R...
-
Page 24: Warranty
ST. CROIX PRESCOTT SERIES WARRANTY The wood pellet stove and insert manufactured by Even Temp, Inc. is warranted for five (5) years, to the original owner, against defects and workmanship on all steel parts (excluding the burn grate) and two (2) year on electrical components from the date of sale to the original owner. - Page 25 Notes: After the break in period, please note any adjustments that were made to the Feed Trim and Draft Trim on the control board in the area below. In the event of a power failure or if the units gets unplugged, the trim settings will be lost. Draft Trim: Circle one (See point 4 on page 4) Default Draft Low Draft...