Sony KP-44PX3 Service Manual
  1. Manuals
  2. Brands
  3. Sony Manuals
  4. Projection TV
  5. KP-44PX3
  6. Service manual

Sony KP-44PX3 Service Manual

Ae-6y chassis
Hide thumbs Also See for KP-44PX3:
Table of Contents

Advertisement

Quick Links

SERVICE MANUAL
MODEL
KP-44PX3
COMMANDER
DEST
CHASSIS NO.
RM-945
AEP
SCC-Q85K-A
MODEL
KP-44PX3U
KP-44PX3
- 1 -
KP-44PX3
AE-6Y
CHASSIS
COMMANDER
DEST
CHASSIS NO.
RM-945
UK
SCC-Q84U-A
RM-945
PROJECTION TV
RM-945

Advertisement

Table of Contents
loading

Related Manuals for Sony KP-44PX3

Summary of Contents for Sony KP-44PX3

  • Page 1 KP-44PX3 RM-945 SERVICE MANUAL AE-6Y CHASSIS MODEL MODEL COMMANDER DEST CHASSIS NO. COMMANDER DEST CHASSIS NO. KP-44PX3 KP-44PX3U RM-945 SCC-Q85K-A RM-945 SCC-Q84U-A KP-44PX3 RM-945 PROJECTION TV - 1 -...

  • Page 2: Table Of Contents

    THE SCHEMATIC DIAGRAMS, EXPLODED VIEWS AND IN THE PARTS LIST ARE CRITICAL FOR SAFE OPERATION. REPLACE AN ISOLATION TRANSFORMER SHOULD BE USED DURING THESE COMPONENTS WITH SONY PARTS WHOSE PART ANY SERVICE WORK TO AVOID POSSIBLE SHOCK HAZARD NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN DUE TO LIVE CHASSIS, THE CHASSIS OF THIS RECEIVER IS SUPPLEMENTS PUBLISHED BY SONY.

  • Page 3: Caution

    Due to the higher melting point of Lead Free Solder the soldering iron tip temperature needs to be set to 370 degrees centigrade. This requires soldering equipment capable of accurate temperature control coupled with a good heat recovery characteristics. For more information on the use of Lead Free Solder, please refer to http://www.sony-training.com - 3 -...

  • Page 4: Specifications

    KP-44PX3 RM-945 l l a . s l . s l . s l . s l . s l e i l i n i WARNING (UK Models only) The flexible mains lead is supplied connected to a B.S. 1363 fused plug having a fuse of 5 AMP rating.

  • Page 5: Connectors

    KP-44PX3 RM-945 21 pin connector Pin No Signal Signal level Audio output B Standard level : 0.5V rms (right) Output impedence : Less than 1kohm* Audio input B Standard level : 0.5V rms (right) Output impedence : More than 10kohm* Audio output A Standard level : 0.5V rms...

  • Page 6: Ae-6Y Self Diagnostic Software

    KP-44PX3 RM-945 SECTION 1 SELF DIAGNOSIS FUNCTION AE-6Y Self Diagnostic Software The identification of errors within the AE-6Y chassis is triggered in one of two ways :- 1: Busy or 2: Device failure to respond to IIC. In the event of one of these situations arising the software will first try to release the bus if busy (Failure to do so will report with a continuous flashing LED) and then communicate with each device in turn to establish if a device is faulty.

  • Page 7: General

    KP-44PX3 RM-945 SECTION 2 GENERAL – 7 –...
  • Page 8 KP-44PX3 RM-945 – 8 –...
  • Page 9 KP-44PX3 RM-945 – 9 –...
  • Page 10 KP-44PX3 RM-945 – 10 –...
  • Page 11 KP-44PX3 RM-945 – 11 –...
  • Page 12 KP-44PX3 RM-945 – 12 –...
  • Page 13 KP-44PX3 RM-945 – 13 –...
  • Page 14 KP-44PX3 RM-945 – 14 –...
  • Page 15 KP-44PX3 RM-945 – 15 –...

  • Page 16: Disassembly

    KP-44PX3 RM-945 SECTION 3 DISASSEMBLY 3-1. REAR COVER REMOVAL 3-2. SPEAKER BRACKET REMOVAL Rear cover Speaker bracket Six Screws Thirteen screws 3-3. MAIN BRACKET BLOCK REMOVAL 3-4. SERVICE POSITION Two screws Main bracket block Pull the main bracket out and remove each connector on main bracket block –...

  • Page 17: Front Panel Removal

    KP-44PX3 RM-945 3-5. FRONT PANEL REMOVAL 3-6. H1 BOARD REMOVAL Four screws H1 Board 3-7. F1 BOARD REMOVAL 3-8. FRONT SPEAKERS REMOVAL 1 Speakers 1 Three Screws (+BVTP 4x16) F1 Board – 17 –...

  • Page 18: Beznet Block Removal

    KP-44PX3 RM-945 3-9. BEZNET BLOCK REMOVAL Beznet assembly Thirteen screws (+BVTP 4x16) Four screws 3-10. TERMINAL BOARD REMOVAL 1 Terminal board – 18 –...

  • Page 19: Ad And D Board Removal

    KP-44PX3 RM-945 3-11. AD AND D BOARD REMOVAL 1 AD board Screw (+BVTP 3x12) D board 3 Three claws 3-12. G BOARD REMOVAL Five claws 2 G board – 19 –...

  • Page 20: A Board Removal

    KP-44PX3 RM-945 3-14. HIGH_VOLTAGE CABLE REMOVAL 3-13. A BOARD REMOVAL AND INSTALLATION (1) Removal 3 B board 2 A board Rubber cap HV cable turn 90 (2) Installation Rubber cap HV cable Four claws Hook Gutter 3-15. PICTURE TUBE REMOVAL Removing the arrow-marked screw is strictly inhibited.

  • Page 21: Set-Up Adjustments

    KP-44PX3 RM-945 SECTION 4 SET-UP ADJUSTMENTS 4-3. SCREEN (G2) ADJUSTMENT 4-1. SCREEN VOLTAGE ADJUSTMENT (ROUGH ALIGNMENT) Turn on the power of the set. Select VIDEO1 mode without signals. Receive the Monoscope signal. Supply DC 175 ±0.5 V from external power supply to Set 50% BRIGHTNESS and minimum PICTURE.

  • Page 22: 2-Pole Magnet Adjustment

    KP-44PX3 RM-945 4-5. 2-POLE MAGNET ADJUSTMENT 4-7. GREEN, RED AND BLUE FOCUS ADJUSTMENT Receive the Dot signal and set PICTURE to 80%, BRIGHTNESS to 50%. 4-7-1. Green, Red and Blue Lens Focus Place the caps on the red and blue lens so that only the Adjustment green color is shown.

  • Page 23: Safety Related Adjustment

    KP-44PX3 RM-945 SECTION 5 SAFETY RELATED ADJUSTMENT When replacing the following components marked with below D BOARD – CONDUCTOR SIDE – always check hold-down voltage and if necessary re-adjust. CN8015 Part Replaced ( R9901 CN8006 Part Replaced ( D Board C8129, D8038, D8013, Q8024, R8002, R8055, R8102, R8218, R8219, R8223 Fig.

  • Page 24: Electrical Adjustments

    KP-44PX3 RM-945 SECTION 6 ELECTRICAL ADJUSTMENTS 6-1. Adjustments with Commander 6-1-2. Programming the Remote Commander for Operation in Service Mode Service adjustments to this model can be performed using the supplied remote Commander RM-945. Press and hold the left Mode Select button until the VCR and DVD LED’s flash.
  • Page 25 KP-44PX3 RM-945 c t i t l i – 25 –...

  • Page 26: Service List (Projector Engine)

    KP-44PX3 RM-945 6-1-4. Service List (Projector Engine) : Fixed data. xxxx : Cannot change. Standard Data Item Name/Description Data Range NTSC Name Wide Zoom 14 : 9 Smart Wide Zoom 14 : 9 Smart FDIS 00, 01 Switch of display for fine adjustment data...
  • Page 27 KP-44PX3 RM-945 Standard Data Item Name/Description Data Range NTSC Name Wide Zoom 14 : 9 Smart Wide Zoom 14 : 9 Smart SOGV –128 ~ 127 GREEN vertical skew offset data for Auto Regi. SORV –128 ~ 127 RED vertical skew offset data for Auto Regi.

  • Page 28: Registration Adjustment

    KP-44PX3 RM-945 Adjust “V-Size” and “H-Size” so that the picture size is 6-2. Registration Adjustments within the specification. 6-2-1. Setup for Adjustment SPEC Overscan Spec. = 7.5% 1. Marking Input Signal H SIZE V SIZE PAL SPCB 16.7 ± 0.1 sq.

  • Page 29: Operation Method For Projector Engine Mode

    KP-44PX3 RM-945 6-2-3. Operation Method for Projector Engine Mode Commander Function Buttons Mode Description WRITE Writes data to NVM. TV STANDBY VIDEO STANDBY 7 + - READ Reads data from NVM. 5 + - Service data initialization. Not stored. SCREEN...

  • Page 30: Projector Engine Adjustment

    KP-44PX3 RM-945 6-2-4. Projector Engine Adjustment 3. Operation Method for Fine Adjustment (Sub Deflection Adjustment) (in GRN, BLU, or RED Mode) Select the Projector Engine mode. a a a a a : Yes Adjustment – : No Select FDIS so that the data at each position can be...
  • Page 31 KP-44PX3 RM-945 Select “GRN SIZE”, and adjust so that each distance from 12. Select “GRN MSIZ”, and correct the space intervals for center to left end and to right end is equal. Adjust so that the horizontal section of the screen are equal.

  • Page 32: Auto Convergence Offset

    KP-44PX3 RM-945 3. Red Adjustment 6-4. WHITE BALANCE ADJUSTMENT Place a cap on the blue lens so that green and red colors 1. Enter the monoscope signal. are displayed. 2. Press “MENU” button on the commander to enter the Press “3” button on the commander to select RED mode.

  • Page 33: Auto Convergence Error Code List

    KP-44PX3 RM-945 6-7. AUTO CONVERGENCE ERROR CODE LIST If an error code is displayed after the set has been fully adjusted, correctly, plese check the following items : position, tilt and sizing. If either of these adjustments are off, even slightly, the auto registration pattern will not hit the four sensors properly. This occurs when the internal generator patterns is being flashed on the screen for the sensor to read.

  • Page 34: Test-Test Mode

    KP-44PX3 RM-945 6-8. TEST-TEST MODE Is available by pressing “OSD”, “5”, “Volume minus”, “TV” button in the standby mode, OSD “TT--” appears. The functions described below are available by pressing the two numbers. To release the Test-Test mode, Press “-” twice or switch the TV set into standby mode.

  • Page 35: Block Diagrams

    7-1. BLOCK DIAGRAMS (1) TUNER TU1100 AGC DEFEAT SWITCH IC2000 FROM B BOARD Q1100 SOUND PROCESSOR CONNECTOR IC2200 AUDIO AMP J2200 REAR-R POWER FM/AM SPEAKER REAR-L CN6400 CN6401 F6400 AC IN AC OUT CVBS ANALOG RF IC2500 X2000 TO G BOARD TO G BOARD AUDIO AMP CN2501...
  • Page 36 7-1. BLOCK DIAGRAMS (2) IC9407 D-A CONVERTOR B CLK IC9420 IC9401 B CLK DF FILTER DSP PJE W CLK 1 W CLK OUT C D FOCUS OUT C B CLK RV OUT 1 W CLK 1 GV OUT 1 DF-V RV OUT 1 BV OUT 1 GV OUT 1...
  • Page 37 7-1. BLOCK DIAGRAMS (3) CN3100 KEY 2 B 1/2 ( IC0001 B 2/2 ( BACKEND/SCANRATE/ BACKEND/SCANRATE/ IR-DATA OCP-OVP LVDS/A-INTERFACE P2.15 LVDS/A-INTERFACE LUMISPONDER OCP-FLAG P2.14 EPG MODE EPG-MODE P2.11 OCP-OVP IR DATA P2.9 OCP-FLAG SIRCS P2.8 MAIN-SW LUMISPONDER P5.3 XTAL 1 DG SW KEY 2 P5.0...
  • Page 38 7-1. BLOCK DIAGRAMS (4) CN3601 IC3600 RIGHT OUT AUDIO/VIDEO SWITCH BUFFER V-OUT-35 V-OUT-3B RIGHT IN V-OUT-15 LAST RF SC3-IN-R Q3656 AV3 IN R LEFT OUT V-OUT-25 AV2 OUT CVBS SC2-IN-R AV2 I R LEFT IN CVBS/Y MAIN BUFFER CVBS Y MAIN SC1-IN-R V-OUT-25 V-OUT-2B...
  • Page 39 7-1. BLOCK DIAGRAMS (5) TO FOCUS BLOCK TO FOCUS BLOCK TO FOCUS BLOCK CN9000 CN9300 CN9600 CR ( CG ( CB ( TO FBT TO FBT TO FBT RGB OUT RGB OUT RGB OUT CN9007 CN9307 CN9607 TO HV BLOCK TO HV BLOCK TO HV BLOCK IC9000...

  • Page 40: Circuit Boards Location

    7-1. BLOCK DIAGRAMS (6) 7-2. CIRCUIT BOARD LOCATION Reference Information RESISTOR : METAL FILM : SOLID CN8007 FPRD : NON FLAMMABLE CARBON V DEF- TO DY (R) V RET FUSE : NON FLAMMABLE FUSIBLE CN8025 IC8003 CN8008 V DRV+ : NON FLAMMABLE METAL OXIDE V DEF- TO A BOARD V DRV-...

  • Page 41: A Board Schematic Diagram

    B-#SSAE6Y<...>-A..-44PX3 TO WOOFER C2515 0.01 0.47 0.47 0.47 100000PF MSD601 100000PF MSB709-RT1 MMDL914T1 MSB709-RT1 MSD601 R5270 MSD601 100000PF 15000PF MMDL914T1 TO J BOARD CN3604 SWITCH AV LINK CONVERTER SWITCH ~ A Board Schematic Diagram [ Audio, Deflection, J_Interface ] Page 1/3 ~ - 41 -...
  • Page 42 B-#SSAE6Y<...>-A..-44PX3 COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL BTF-EF411 33pf 10UH Tab Contact BA033T 3.3V REGULATOR 6.8k 100k 1.8V REGULATOR 150K ~ A Board Schematic Diagram [ Modem, A_Tuner, Regulators ] Page 2/3 ~ - 42 -...
  • Page 43 TO D BOARD CN8029 TO F1 BOARD CN0982 TO D BOARD CN8025 3.3K 3.3K 0.01 5.6K TO D BOARD CN8031 B-#SSAE6Y<...>A..-44PX3 TO D BOARD CN8023 ~ A Board Schematic Diagram [ B_Interface, N_Interface, Dig_Tuner ] Page 3/3 ~ - 43 -...

  • Page 44: A Printed Wiring Board

    ~ A Printed Wiring Board Conductor Side A ~ ~ A Board Location Table (B Side) ~ - 44 -...
  • Page 45 ~ A Printed Wiring Board Conductor Side B ~ ~ A Board Location Table (B Side) ~ ~ A Board Semiconductor Voltage Table ~ ~ A Board IC Voltage Table ~ - 45 -...

  • Page 46: Ad Board Schematic Diagram

    B-#SSAE6Y<...>-AD.-44PX3 TP 2 TP 1 TP 3 TP 4 TP 6 TP •7 TP 8 TP 10 TP 9 TP 11 TP 5 ~ AD Board Schematic Diagram [ PJED, REGI Correction ] Page 1/2 ~ - 46 -...
  • Page 47 B-#SSAE6Y<...>-AD.-44PX3 COMPARATOR COMPARATOR ~ AD Board Schematic Diagram [ PJED, REGI Correction ] Page 2/2 ~ - 47 -...

  • Page 48: Ad Printed Wiring Board

    ~ AD Printed Wiring Board Conductor side A ~ ~ AD Board Location Table (A Side) ~ ~ AD Board Waveforms ~ 4.9 Vp-p (500 kHz) 0.9 Vp-p (V) 4.9 Vp-p (8.9 MHz) 1.3 Vp-p (V) 4.9 Vp-p (H) 1.9 Vp-p (V) TP10 ~ AD Printed Wiring Board Conductor side B ~ 4.9 Vp-p (V)
  • Page 49 AD Board IC Voltage Table ~ D Board Waveforms ~ 1.0 Vp-p (V) 56.0 Vp-p (V) 0.8 Vp-p (V) 5.4 Vp-p (H) 221.5 Vp-p (H) TP10 9.0 Vp-p (H) 1245 Vp-p (H) 22.8 Vp-p (V) 17.8 Vp-p (V) 38.3 Vp-p (V) TP11 TP12 TP13...

  • Page 50: D Board Schematic Diagram

    TO VMB BOARD - CN9701 TP 2 TP 3 TP 1 TO A BOARD CN3011 TP 10 TP 9 TP 8 +210V TO CB BOARD CN9601 TP 13 TP12• TP 11 TO A BOARD CN3013 EL1Z TO A BOARD CN3012 TP 7 TP 6 TP 4...

  • Page 51: D Printed Wiring Board

    ~ D Board Location Table ~ ~ D Printed Wiring Board Conductor side ~ - 51 -...

  • Page 52: G Board Schematic Diagram

    B-#SSAE6Y<...>-G..-44PX3 POWER SUPPLY S1VB40 MAIN_STBY R6081 5.6k R6082 4.7k R6080 Q6007 MSB709-RT1 R6079 R6083 D6047 MMDL914T1 Q6008 R6084 MSD601-RST1 COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL ~ G Board Schematic Diagram [ Power Supply ] ~ - 52 -...

  • Page 53: G Printed Wiring Board

    ~ G Printed Wiring Board Conductor side ~ ~ G Board Location Table ~ Note : Portions of the circuit contained within the marked areas as shown have high voltages present. Use care to prevent electric shock during inspection or repair. An Isolation Transformer must be used during any Service work to avoid possible shock hazard due to live chassis.

  • Page 54: B Board Schematic Diagram

    TO CR BOARD CN9003 TO VMR BOARD - CN9102 TO VMG BOARD - CN9402 TO VMB BOARD - CN9702 B-#SSAE6Y<...>-B..-44PX3 BACKEND, SCANRATE, LVDS, A_INTERFACE 0.047 4.7K 5.6K 6.8K 100K 100K MSB709-RT1 4.7K MMDL914T1 0.22 ~ B Board Schematic Diagram [ Backend, Scanrate, LVDS, A_Interface ] Page 1/2 ~ - 54 -...
  • Page 55 B-#SSAE6Y<...>-B..-44PX3 M24C32-WMN6T(A) UDZSTE-173.6B 100000PF M27V160-100K1-6BA001 ~ B Board Schematic Diagram [ Backend, Scanrate, LVDS, A_Interface ] Page 2/2 ~ - 55 -...

  • Page 56: B Printed Wiring Board

    ~ B Printed Wiring Board Conductor Side A ~ ~ J Printed Wiring Board Conductor Side ~ 1-723-216-12 1-689-676-12 ~ B Printed Wiring Board Conductor Side B ~ 1-689-677-12 (1-723-217-12) 1-689-676-12 (1-723-216-12) - 56 -...

  • Page 57: J Board Schematic Diagram

    J..-44PX3 SC1-OUT-R C3642 C3645 L3614 R3653 R2608 R2600 C2604 R2604 C2610 D2600 1/10W 0.022 470k UDZS-TE17-9.1B C3643 1/10W 1/10W 1/10W R3654 Q3656 SC1-IN-R MSD601-RST1 1/10W R3657 C2601 R2601 C2605 R2605 R2609 C2608 D2601 Q3657 470k 1000p UDZS-TE17-9.1B 1/10W MSD601-RST1 R3652 1/10W CHIP 1/10W...

  • Page 58: Cb, Vmb, H1 And F1Board Schematic Diagrams

    ~ CB Board Schematic Diagram [ RGB Out ] ~ ~ H1 Board Schematic Diagram [ AV Input, HP Out ] ~ CB.-44PX3 TO J BOARD TO A BOARD CN2300 CN3600 R,G,B OUT CN9600 CN2909 CN2912 H1.-44PX3 R9610 TO F. BLOCK 560k 1/2W COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL...

  • Page 59: Cb, Vmb, H1And F1 Printed Wiring Boards

    ~ CB Printed Wiring Board Conductor side ~ ~ VMB Printed Wiring Board Conductor side ~ ~ F1 Printed Wiring Board Conductor side ~ ~ H1 Printed Wiring Board Conductor side ~ - 59 -...

  • Page 60: Cg, Vmg, Cr And Vmr Board Schematic Diagrams

    ~ CG Board Schematic Diagram [ RGB Out ] ~ ~ VMR Board Schematic Diagram [ Velocity Modulation ] ~ CG.-44PX3 VMR-44PX3 CN9300 CN9101 R9101 VELOCITY MODULATION TO FBT R9310 R,G,B OUT 560k TO F. BLOCK 1/4W L9101 +135V FPRD 1/2W C9319 +135V...

  • Page 61: Cg, Vmg, Cr And Vmr Printed Wiring Boards

    ~ CG Printed Wiring Board Conductor side ~ ~ VMG Printed Wiring Board Conductor side ~ ~ CR Printed Wiring Board Conductor side ~ ~ VMR Printed Wiring Board Conductor side ~ - 61 -...

  • Page 62: Semiconductors

    7-5. SEMICONDUCTORS DS90LV017ATMX BA033T BA05T MSP3411G-QA-B11 DS90LV018ATMX ( TOP VIEW ) DS90LV031ATMX NJM082M CXA1855Q NJM2903M CXA1875AM-T4 LA6500-FA LM358D NJM3403AM TDA2822D013TR TOP VIEW CXA2149AQ-TL LA6510 NJM2904M TOP VIEW CXD2088Q-T4 LM1876TF PQ1CG2032FZ CXD9761Q MCZ3001D SBX3081-51(30) MCZ3001DA - 62 -...
  • Page 63 SE135N-LF4 TDA7482 3 GND SN65LVDS32DR TDA8601T SN74CBTLV1G125DCKR TL1431CZ-AP STR-L474-LF429 TLV431AIDBV TDA6120Q/N2/S1 UPC1898CT-A - 63 -...

  • Page 64: Ic Block Diagrams

    7-6 IC BLOCK DIAGRAMS A BOARD IC2500 TDA7265 A BOARD IC6201/IC6210 BA033T REFERENCE VOLTAGE A BOARD IC6202 PQ1CG2032FZ Vout ON/OFF PWM COMP ON/OFF ERROR AMP Oadj Vref - 64 -...
  • Page 65 A BOARD IC2000 MSP3411G SBUS Interface I2C Interface DEMODULATOR IDENT SCART Switching Facilities D BOARD IC8003 STV9379 FLYBACK GENERATOR POWER AMPLIFIER THERMAL PROTECTION G BOARD IC6004 SE135N-LF4 D BOARD IC8006/IC8007 NJM2903M - 65 -...
  • Page 66 G BOARD IC6002 MCZ3001D Remote DVLD Internal Driver ref 5v Sel=34v 15v/8v Reg. 10v Level Shift Vsense Control Logic Latch Centre Timer CR BOARD IC9000 CG BOARD IC9300 CB BOARD IC9600 TDA6118JF BIAS CIRCUIT AND THERMAL PROTECTION - 66 -...

  • Page 67: Exploded Views

    KP-44PX3 SECTION 8 RM-945 EXPLODED VIEWS NOTE : Items with no part number and no description are not Items marked “*” are not stocked stocked because they are seldom required for routine since they are seldom required for The components identified by shading £...

  • Page 68: Cabinet Block

    KP-44PX3 RM-945 8-2. CABINET BLOCK The components identified by shading £ and mark are critical for safety. Replace only with part number specified. 7-685-648-79 +BVTP 3X12 TYPE 2 IT3 7-685-663-79 +BVTP 4X16 TYPE 2 IT3 REF.NO. PART.NO DESCRIPTION REMARK REF.NO.

  • Page 69: Main Bracket Block

    KP-44PX3 RM-945 8-3. MAIN BRACKET BLOCK The components identified by shading £ and mark are critical for safety. Replace only with part number specified. 7-685-648-79 +BVTP 3X12 TYPE 2 IT3 7-685-663-79 +BVTP 4X16 TYPE 2 IT3 REF.NO. PART.NO DESCRIPTION REMARK REF.NO.

  • Page 70: Picture Tube Block

    KP-44PX3 RM-945 8-4. PICTURE TUBE BLOCK The components identified by shading £ and mark are critical for safety. Replace only with part number specified. 7-685-663-71 +BVTP 4X16 TYPE 2 IT3 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK *A-1405-595-A CR BOARD, COMPLETE *A-1405-597-A CG BOARD, COMPLETE £...

  • Page 71: Electrical Parts List

    SECTION 9 ELECTRICAL PARTS LIST PARTS LISTING TABLE OF CONTENTS Page CR BOARD COMPLETE Parts List : ....................72 CB BOARD COMPLETE Parts List : ....................72 CG BOARD COMPLETE Parts List : ....................73 VMG BOARD COMPLETE Parts List : ....................
  • Page 72 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK * A-1405-595-A CR Board Complete R9002 1-216-814-11 METAL CHIP 1/10W R9003 1-216-813-11 METAL CHIP 1/10W * 4-102-022-01 PIN(30), WIRE R9004 1-216-864-11 SHORT CHIP R9006 1-216-864-11 SHORT CHIP 4-382-854-01 SCREW (M3X8), P, SW (+) R9007 1-247-807-31 CARBON...
  • Page 73 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < IC > C9301 1-107-652-11 ELECT 10UF 20.00% 250V C9302 1-165-176-11 CERAMIC CHIP 0.047UF 10.00% 16V IC9600 6-704-806-01 IC TDA6118JF C9303 1-126-947-11 ELECT 47UF 20.00% 35V C9304 1-117-216-51 CERAMIC 0.0022UF 10.00% 3KV <...
  • Page 74 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R9313 1-260-328-11 CARBON 1/2W Q9411 8-729-045-05 TRANSISTOR 2SA2005 R9321 1-216-826-11 METAL CHIP 2.7K 5% 1/10W Q9412 8-729-045-04 TRANSISTOR 2SC5511 R9323 1-249-409-11 CARBON 1/4W Q9413 8-729-010-29 TRANSISTOR MSD601-RST1 Q9414 8-729-010-05 TRANSISTOR MSB709-RT1 < SPARK GAP > <...
  • Page 75 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C9109 1-107-636-11 ELECT 10UF 20.00% 160V R9118 1-249-393-11 CARBON 1/4W R9119 1-216-839-11 METAL CHIP 1/10W C9110 1-137-528-11 MYLAR 0.1UF 10.00% 250V C9111 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V R9120 1-216-821-11 METAL CHIP 1/10W R9121 1-216-801-11...
  • Page 76 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK Q9707 8-729-010-29 TRANSISTOR MSD601-RST1 C9406 1-164-156-11 CERAMIC CHIP 0.1UF Q9708 8-729-010-05 TRANSISTOR MSB709-RT1 C9407 1-164-156-11 CERAMIC CHIP 0.1UF Q9709 8-729-010-29 TRANSISTOR MSD601-RST1 C9408 1-162-919-11 CERAMIC CHIP 22PF 5.00% 50V Q9710 8-729-010-05 TRANSISTOR MSB709-RT1 C9409 1-126-933-11 ELECT...
  • Page 77 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C9472 1-115-412-11 CERAMIC CHIP 680PF 5.00% 25V C9552 1-162-974-11 CERAMIC CHIP 0.01UF C9474 1-164-156-11 CERAMIC CHIP 0.1UF C9553 1-126-947-11 ELECT 47UF 20.00% 35V C9475 1-164-156-11 CERAMIC CHIP 0.1UF C9554 1-126-947-11 ELECT 47UF 20.00% 35V C9476 1-164-156-11...
  • Page 78 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK IC9401 8-759-683-55 IC CM0017AF R9415 1-216-821-11 METAL CHIP 1/10W IC9402 8-759-682-41 IC M24C32-WMN6T(A) R9416 1-216-825-11 METAL CHIP 2.2K 5% 1/10W IC9403 8-759-352-91 IC PST9143NL R9417 1-216-809-11 METAL CHIP 1/10W IC9405 8-759-830-08 IC NJM2068V-TE2 R9418 1-216-809-11 METAL CHIP...
  • Page 79 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R9466 1-218-871-11 METAL CHIP 0.5% 1/10W R9559 1-216-821-11 METAL CHIP 1/10W R9467 1-218-855-11 METAL CHIP 2.2K 0.5% 1/10W R9561 1-216-864-11 SHORT CHIP R9468 1-218-855-11 METAL CHIP 2.2K 0.5% 1/10W R9562 1-216-864-11 SHORT CHIP R9469 1-218-855-11 METAL CHIP...
  • Page 80 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C8014 1-104-665-11 ELECT 100UF 20.00% 25V C8072 1-126-964-11 ELECT 10UF 20.00% 50V C8015 1-126-969-11 ELECT 220UF 20.00% 50V C8073 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V C8016 1-104-665-11 ELECT 100UF 20.00% 25V C8074 1-104-665-11 ELECT 100UF...
  • Page 81 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C8125 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V CN8018 * 1-580-689-11 PIN, CONNECTOR (PC BOARD) 4P C8126 1-106-357-00 MYLAR 0.0039UF 200V CN8019 * 1-580-689-11 PIN, CONNECTOR (PC BOARD) 4P C8127 1-126-942-61 ELECT 1000UF 20.00% 25V CN8020 * 1-580-689-11...
  • Page 82 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK D8050 8-719-988-61 DIODE 1SS355TE-17 L8016 1-412-537-31 INDUCTOR 100UH D8051 8-719-988-61 DIODE 1SS355TE-17 L8017 1-414-856-11 INDUCTOR 10UH D8052 8-719-988-61 DIODE 1SS355TE-17 L8018 1-406-667-11 INDUCTOR 220UH D8201 8-719-081-97 DIODE MMDL914T1 L8019 1-456-109-11 COIL,HORIZONTAL LINEARITY(HLC) D8202 8-719-081-97 DIODE MMDL914T1...
  • Page 83 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK Q8029 8-729-010-29 TRANSISTOR MSD601-RST1 R8042 1-216-826-11 METAL CHIP 2.7K 5% 1/10W Q8030 8-729-010-05 TRANSISTOR MSB709-RT1 R8043 1-218-895-11 METAL CHIP 100K 0.5% 1/10W Q8031 8-729-010-29 TRANSISTOR MSD601-RST1 R8044 1-218-863-11 METAL CHIP 4.7K 0.5% 1/10W Q8035 6-550-153-01 TRANSISTOR FQPF12P20XDTU...
  • Page 84 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R8097 1-214-808-11 METAL 1/2W R8151 1-218-847-11 METAL CHIP 0.5% 1/10W R8098 1-214-808-11 METAL 1/2W R8152 1-218-871-11 METAL CHIP 0.5% 1/10W R8100 1-216-475-21 METAL OXIDE R8153 1-218-847-11 METAL CHIP 0.5% 1/10W R8101 1-216-475-21 METAL OXIDE R8154 1-218-883-11...
  • Page 85 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R8218 1-260-123-11 CARBON 100K 5% 1/2W C2606 1-164-227-11 CERAMIC CHIP 0.022UF 10.00% 25V R8219 1-249-377-11 CARBON 0.47 5% 1/4W C2607 1-162-964-11 CERAMIC CHIP 0.001UF 10.00% 50V R8220 1-216-821-11 METAL CHIP 1/10W C2608 1-165-908-11 CERAMIC CHIP 1UF R8222...
  • Page 86 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C3636 1-126-947-11 ELECT 47UF 20.00% 35V D3634 8-719-069-60 DIODE UDZSTE-179.1B C3641 1-164-156-11 CERAMIC CHIP 0.1UF D3635 8-719-069-60 DIODE UDZSTE-179.1B C3642 1-164-156-11 CERAMIC CHIP 0.1UF C3643 1-164-156-11 CERAMIC CHIP 0.1UF < FERRITE BEAD > C3644 1-164-156-11 CERAMIC CHIP 0.1UF...
  • Page 87 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R2617 1-216-821-11 METAL CHIP 1/10W R3622 1-216-025-11 RES-CHIP 1/10W R2618 1-216-864-11 SHORT CHIP R3623 1-216-025-11 RES-CHIP 1/10W R2619 1-216-821-11 METAL CHIP 1/10W R3624 1-216-022-00 RES-CHIP 1/10W R2620 1-216-837-11 METAL CHIP 1/10W R3625 1-216-025-11 RES-CHIP 1/10W...
  • Page 88 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C2000 1-126-947-11 ELECT 47UF 20.00% 35V C2505 1-107-888-11 ELECT 47UF 20.00% 25V C2001 1-164-156-11 CERAMIC CHIP 0.1UF C2506 1-107-888-11 ELECT 47UF 20.00% 25V C2002 1-126-947-11 ELECT 47UF 20.00% 35V C2507 1-126-959-11 ELECT 0.47UF 20.00% 50V C2004...
  • Page 89 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C6247 1-104-665-11 ELECT 100UF 20.00% 25V D6208 8-719-081-97 DIODE MMDL914T1 D6209 8-719-081-97 DIODE MMDL914T1 C6248 1-164-156-11 CERAMIC CHIP 0.1UF D6210 8-719-110-41 DIODE RD15ESB2 C6249 1-164-156-11 CERAMIC CHIP 0.1UF D6211 8-719-080-59 DIODE EK19-V0 C6250 1-104-665-11 ELECT...
  • Page 90 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < TRANSISTOR > JR6011 1-216-864-11 SHORT CHIP JR6012 1-216-864-11 SHORT CHIP Q0100 8-729-028-28 TRANSISTOR 2SK2036(TE85L) JR6014 1-216-864-11 SHORT CHIP Q0200 8-729-028-28 TRANSISTOR 2SK2036(TE85L) JR6015 1-216-864-11 SHORT CHIP Q0201 8-729-028-28 TRANSISTOR 2SK2036(TE85L) JR6016 1-216-864-11 SHORT CHIP Q1100...
  • Page 91 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R2026 1-216-809-11 METAL CHIP 1/10W R2512 1-216-835-11 METAL CHIP 1/10W R2029 1-216-864-11 SHORT CHIP R2514 1-216-826-11 METAL CHIP 2.7K 5% 1/10W R2030 1-216-864-11 SHORT CHIP R2515 1-216-833-11 METAL CHIP 1/10W R2200 1-216-837-11 METAL CHIP 1/10W R2516...
  • Page 92 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R5240 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R8014 1-216-809-11 METAL CHIP 1/10W R5257 1-216-809-11 METAL CHIP 1/10W R8015 1-216-809-11 METAL CHIP 1/10W R5258 1-216-833-11 METAL CHIP 1/10W R8016 1-216-809-11 METAL CHIP 1/10W R5259 1-216-833-11 METAL CHIP...
  • Page 93 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C0059 1-164-156-11 CERAMIC CHIP 0.1UF C3308 1-164-156-11 CERAMIC CHIP 0.1UF C0060 1-164-230-11 CERAMIC CHIP 220PF 5.00% 50V C3309 1-164-156-11 CERAMIC CHIP 0.1UF C0061 1-164-156-11 CERAMIC CHIP 0.1UF C3310 1-164-156-11 CERAMIC CHIP 0.1UF C0062 1-126-947-11 ELECT...
  • Page 94 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < CONNECTOR > < TRANSISTOR > CN3100 1-794-244-11 CONNECTOR, DIN (PLUG) 96P Q0001 8-729-010-05 TRANSISTOR MSB709-RT1 CN3400 * 1-564-524-11 PLUG, CONNECTOR 9P Q0002 8-729-010-05 TRANSISTOR MSB709-RT1 CN3402 * 1-564-519-11 PLUG, CONNECTOR 4P Q0003 8-729-010-05 TRANSISTOR MSB709-RT1...
  • Page 95 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R0014 1-216-805-11 METAL CHIP 1/10W R0072 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R0015 1-216-805-11 METAL CHIP 1/10W R0073 1-216-833-11 METAL CHIP 1/10W R0016 1-216-805-11 METAL CHIP 1/10W R0074 1-216-864-11 SHORT CHIP R0017 1-216-821-11 METAL CHIP 1/10W...
  • Page 96 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R3311 1-216-864-11 SHORT CHIP R5510 1-216-809-11 METAL CHIP 1/10W R3314 1-216-821-11 METAL CHIP 1/10W R5511 1-216-809-11 METAL CHIP 1/10W R3315 1-216-821-11 METAL CHIP 1/10W R5512 1-216-838-11 METAL CHIP 1/10W R3316 1-216-821-11 METAL CHIP 1/10W R5513 1-218-863-11...
  • Page 97 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK RB0036 1-233-576-11 RES, CHIP NETWORK 100 (3216) C6045 1-126-937-11 ELECT 4700UF 20.00% 16V RB0037 1-233-576-11 RES, CHIP NETWORK 100 (3216) C6046 1-128-549-11 ELECT 3300UF 20.00% 35V RB0038 1-233-576-11 RES, CHIP NETWORK 100 (3216) C6047 1-128-549-11...
  • Page 98 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK D6030 8-719-988-31 DIODE D10SC6MR < PROTECTOR MODULE > D6031 8-719-057-96 DIODE D10SC6M-4012 D6035 8-719-988-61 DIODE 1SS355TE-17 PS6000 £ 1-533-597-31 IC LINK D6036 8-719-988-61 DIODE 1SS355TE-17 PS6001 £ 1-533-597-31 IC LINK D6037 8-719-921-88 DIODE MTZJ-13B PS6004 £...
  • Page 99 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R6058 1-216-833-11 METAL CHIP 1/10W < SOCKET > R6060 1-249-405-11 CARBON 1/4W J2901 1-817-763-11 JACK R6061 1-245-494-21 METAL 2.2M 2% 1/4W R6062 1-245-494-21 METAL 2.2M 2% 1/4W < COIL > R6066 1-215-477-00 METAL 220K 1% 1/4W...
  • Page 100 *4-087-938-01 JOINT *4-102-596-01 CUSHION (44) LOWER ASSY 4-102-597-01 INDIVIDUAL CARTON (44) 4-102-598-01 TRAY (44) *4-102-599-01 CUSHION (44) UPPER ASSY 4-102-591-11 INSTRUCTION MANUAL(ENGLISH/BULGARIAN/CZECH/ HUNGARIAN/POLISH/RUSSIAN) (KP-44PX3) 4-102-591-21 INSTRUCTION MANUAL(DANISH/SPANISH/FINNISH/ NORWEGIAN/PORTUGUESE/SWEDISH) (KP-44PX3) 4-102-591-31 INSTRUCTION MANUAL(GERMAN/FRENCH/GREEK/ ITALIAN/DUTCH/TURKISH) (KP-44PX3) 4-102-591-41 INSTRUCTION MANUAL(ENGLISH) (KP-44PX3U) REMOTE COMMANDER...
  • Page 101 • User programmable Functional Check through Infrared • Fast and documented Test Mode setting of all Sony TV chassis Additional features such as Adjustments and Troubleshooting are available in chassis-dependent software modules. Please contact your local Sony Service organisation for the latest information.

This manual is also suitable for:

Kp-44px3u

Table of Contents