Page 1
ManUFactUring nUMberS: 9700464 9700466 9700469 9700474 9700476 9700479 Water filtration system UFL-420/440 Series System Tested and Certified by NSF International and WQA against NSF/ANSI Standard 42 and 53 for the reduction of: Standard No. 42: Aesthetic Effects Nominal Particulate Reduction Class I Standard No.
UFL-420/440 water FiLtration system A.J. Antunes & Co. table Of cOntents Owner Information .............2 Operation ..............11 General ..............2 Filtration Process .............11 Warranty Information ..........2 LED Display .............11 Service/Technical Assistance ........3 Starting the System ..........11 Important safety Information ........3 Programming Timer During Startup ......12 specifications .............4 Setting the Flush Interval (Fi) ........12 Electrical Ratings ............4...
UFL-420/440 water FiLtration system A.J. Antunes & Co. Owner InfOrmatIOn (continued) service/technical assistance Suggested replacement period for Cartridge is approxi- mately 3 years. If you experience any problems with the installation or operation of your unit, contact Antunes Filtration For sales in the state of Iowa: Technologies at 1-630-784-1000, or toll free in the Seller: Date:...
UFL-420/440 water FiLtration system A.J. Antunes & Co. perfOrmance Data sHeet filter cartridge capacities System Tested and Certified by NSF Maximum operating Pressure 100 psig (690 kPa) International against NSF/ANSI Minimum operating Pressure 8 psig (55 kPa) Standard 42 and 53 for the reduction of: Maximum operating Temperature 104°F (40°c) Minimum operating Temperature 40°F (4°c) Standard No. 42: Aesthetic Effects Maximum Trans Membrane Pressure 45 PSI (3.1 Bar) Nominal Particulate Reduction Class I pH Range...
UFL-420/440 water FiLtration system A.J. Antunes & Co. InstallatIOn equipment setup If soldered plumbing is used, do not apply heat to, or near, the filtration system. The use of union (o-ring General seal) connections is highly recommended for ease of installation and future servicing.
UFL-420/440 water FiLtration system A.J. Antunes & Co. InstallatIOn (continued) locating and mounting the system ImpOrtant Consider these points before mounting the system: commonwealth of massachusetts plumbing code 248 cmr shall be adhered to. the use of saddle • Note the location of the water supply, drain, and valves are not permitted, please consult your local an appropriate electrical outlet when choosing a plumber.
Page 9
UFL-420/440 water FiLtration system A.J. Antunes & Co. InstallatIOn (continued) DraIn lIne plUmbInG caUtIOn The drain line is used to flush away the particle buildup Ingesting the protective solution may cause irrita- when cleaning the filter. The drain line must be able tion of the gastrointestinal tract, colic, diarrhea, or to support the flow rate when the system flushes.
Page 10
UFL-420/440 water FiLtration system A.J. Antunes & Co. InstallatIOn (continued) 9. once again, press and hold the Program button 5. Press and hold the Program button to help drain for at least 60 seconds to flush out any remaining the system. air from the system.
UFL-420/440 water FiLtration system A.J. Antunes & Co. OperatIOn filtration process starting the system Water filtration in the UFL Series is accomplished using Power up the unit. two modes: The LED read-out displays the following for about two • Flush Interval (fi on the LED display) seconds each: • Flush Duration (fd on LED display).
UFL-420/440 water FiLtration system A.J. Antunes & Co. OperatIOn (continued) programming timer During startup nOte: Once the unit is powered up, the leD display cycles through the default or current settings: flush Duration (fd) and its setting will be followed by flush Interval (fi) and its settings. at any time during this sequence, which lasts approxi- mately 30 seconds the unit can be programmed.
UFL-420/440 water FiLtration system A.J. Antunes & Co. OperatIOn (continued) programming timer while Unit is in flush Interval (fi) mode tO set fi - flUsH InterVal mODe nOte: after power-up and cycling - fi time setting displays a flashing decimal point. PROGRAM 1.
UFL-420/440 water FiLtration system A.J. Antunes & Co. maIntenance The filtration system is designed to require very little 6. Unplug the system. maintenance. To ensure that the water is of the highest 7. make sure there is enough room below the quality, occasionally some service is required.
UFL-420/440 water FiLtration system A.J. Antunes & Co. trOUblesHOOtInG problem possible cause corrective action Unit does not have power. The power cord is not correctly Plug power cord in correctly. plugged in. The Control Display is blank. The power cord is not correctly Plug power cord in correctly.
UFL-420/440 water FiLtration system A.J. Antunes & Co. wIrInG DIaGram POWER CORD W/24V XFORMER NOTE: ALL WIRES TO BE 16 GA. AWM-105°C UNLESS OTHERWISE SPECIFIED. 14 GA. AWM-105°C 22 GA. AWM-105°C TERMINAL BLOCK CONTROL BOARD SOLENOID VALVE P/N 1010873 Rev. G 03/12...
Page 17
UFL-420/440 water FiLtration system A.J. Antunes & Co. replacement parts Ufl-420/440 (continued) replacement parts can be purchased from an authorized dealer. contact antunes filtration technologies at 1-630-754-1000 or toll free in the United states at 1-800-253-2991 NOTE: Item 12 is GREEN and rated at 5 GPM for UFL-420 units.
UFL-420/440 water FiLtration system A.J. Antunes & Co. replacement parts Ufl-420/440 replacement parts can be purchased from an authorized dealer. contact antunes filtration technologies at 1-630-754-1000 or toll free in the United states at 1-800-253-2991 Item part Description Qty. Item part Description Qty.
Page 19
UFL-420/440 water FiLtration system A.J. Antunes & Co. nOtes P/N 1010873 Rev. G 03/12...
lImIteD warranty Equipment manufactured by Antunes Filtration Technologies, a Division of A.J. Antunes & Co., has been con- structed of the finest materials available and manufactured to highest quality standards. These units are war- ranted to be free from defects in material and workmanship for a period of on year from date of purchase under normal use and service, and when installed in accordance with the manufacturer’s recommendations.* The ultra filtration membrane cartridge is warranted under the same terms and conditions on a pro rated basis for 24 months form date of purchase.