Related Manuals for Vizion UF-216 series
Summary of Contents for Vizion UF-216 series
- Page 1 Manufacturing nuMbers: 9700435 Water filtration system Uf-216 series P/N 1011078 Rev. B 03/12 owner s manual ’...
-
Page 2: Table Of Contents
Information General Please read the full text of the Limited Warranty in this VIZION, a division of A.J. Antunes & Co., has partnered manual. with companies from around the globe to produce the UF-216 Series water filtration system. The UF-216... -
Page 3: Service/Technical Assistance
UF-216 water Filtration system A.J. Antunes & Co. Owner InfOrmatIOn (continued) service/technical assistance Suggested replacement period for Ultra Filter Cartridge is approximately 3 years. If you experience any problems with the installation or operation of your unit, contact us at 1-630-784-1000, or For sales in the state of Iowa: toll free in the United States at 1-800-253-2991. -
Page 4: Important Safety Information
UF-216 water Filtration system A.J. Antunes & Co. ImpOrtant safety InfOrmatIOn In addition to the warnings and cautions in this manual, • If the supply cord is damaged, it must be replaced use the following guidelines for safe operation of the unit: by the manufacturer or its service agent or a simi- larly qualified person. -
Page 5: Specifications
UF-216 water Filtration system A.J. Antunes & Co. specIfIcatIOns Dimensions electrical ratings model & Voltage watts amps Hertz mfg. no. UF-216 100‒240 50/60 9700435 electrical cord & plug configurations Kit model Description configuration number DC Power Supply 100 - 240 VAC 0012146 Includes the 4 plug adaptors below... - Page 6 UF-216 water Filtration system A.J. Antunes & Co. specIfIcatIOns (continued) permeate Drain Outlet pulse controller mounting bracket filter Housing flush button Inlet figure 1. components P/N 1011078 Rev. B 03/12...
-
Page 7: Overview
UF-216 water Filtration system A.J. Antunes & Co. OVerVIew Overview The UF-216 system operates in two modes: • Normal Operation Mode • Flush Mode During Normal Operation Mode, water enters the Inlet and flows through the Ultra Filter before exiting the Permeate Outlet as usable product water. During Flush Mode, the Drain Valve opens and water entering the Inlet flushes and cleans the Ultra Filter membrane by removing any debris collecting on the membrane wall. -
Page 8: Installation
UF-216 water Filtration system A.J. Antunes & Co. InstallatIOn unpacking plumbInG nOte: this unit is designed to use tap water not to 1. Remove the system and all packing materials exceed 100°f (38°c) or 100 psig (690 kpa). from the shipping carton. 2. -
Page 9: Mounting The System
UF-216 water Filtration system A.J. Antunes & Co. InstallatIOn (continued) mounting the system Inlet water plumbing The UF-216 system comes with a Mounting Bracket to The Inlet water plumbing line should be 3/4” NPT or mount the system securely. When mounting the system, larger. A shutoff valve (not supplied) should be installed pay attention to the following guidelines: in the line leading to the system. -
Page 10: Permeate Line Plumbing
UF-216 water Filtration system A.J. Antunes & Co. InstallatIOn (continued) permeate line plumbing Drain line secure To ensure the highest quality and safest water, it is from system recommended that a check valve (to prevent backflow) 2” (5.1 cm) be installed in the water line after the permeate connec- minimum tion. -
Page 11: Rinsing The Ultra Filter Cartridge
UF-216 water Filtration system A.J. Antunes & Co. InstallatIOn (continued) rinsing the ultra filter cartridge sanitizing the system and lines The Ultra Filter Cartridge must be rinsed before the sys- The plumbing must be sanitized to eliminate possible tem is used to remove any air and protective solution. contamination that may have occurred during the instal- lation process. -
Page 12: Maintenance
UF-216 water Filtration system A.J. Antunes & Co. maIntenance replacing the ultra filter cartridge 1. Open the faucet or tap closest downstream to the end cap filtration system. 2. Close the Inlet Water Valve and allow the system to depressurize. 3. -
Page 13: Changing The Interval Setting
UF-216 water Filtration system A.J. Antunes & Co. maIntenance (continued) changing the Interval setting cautIOn changing the flush interval can cause the ultra filter to plug prematurely and may void the war- ranty. consult the factory for more information. Though not recommended, the Interval Setting on the controller can be changed. -
Page 14: Troubleshooting
UF-216 water Filtration system A.J. Antunes & Co. trOublesHOOtInG problem possible cause corrective action Unit does not have power. The power cord is not correctly Plug power cord in correctly. plugged in. The Control Display is blank. The power cord is not correctly Plug power cord in correctly. plugged in. -
Page 15: Replacement Parts
UF-216 water Filtration system A.J. Antunes & Co. replacement parts replacement parts can be purchased from an authorized dealer. contact a.J. antunes & co. at 1-630-754-1000 or toll free in the united states at 1-800-253-2991. Item part Description Qty. 2190133 Strainer, Tee 1/2”... -
Page 16: Limited Warranty
lImIteD warranty Equipment manufactured by A.J. Antunes & Co. has been constructed of the finest materials avail- able and manufactured to high quality standards. These units are warranted to be free from defects in materials and workmanship for a period of one year from date of purchase under normal use and service, and when installed in accordance with manufacturer’s recommendations*.