Table of Contents
Advertisement
ROTATE
Figure 6
3
Figure 7
Refractory Replacement
The intense heat of the fire will normally cause
hairline cracks in the refractory. These cracks
can be minimized by proper curing as described
in "First Fires". They will not normally dimin-
ish the effectiveness of the refractory. If large
cracks develop, then the refractory should be
replaced. To replace the refractory bricks, follow
these steps (see Figure 7):
ROTATE
ROTATE
1. Front Refractory
2. Bottom Refractory
3. Left Side Refractory
4. Right Side Refractory
5. Back Refractory
5
4
2
1. Remove the front refractory
2. Remove the bottom refractory
3. Remove the left side refractory
4. Remove the right side refractory
5. Remove the back refractory
To install the new refractories, follow the above
steps in reverse.
NOTE: DIAGRAMS & IllUSTRATIONS ARE NOT TO SCAlE.
Cleaning Procedure (see Figure 6):
1.
2.
3.
4.
Door Frame Care
Use a glass cleaner and a soft cloth to polish
the frame. Do not use abrasives such as steel
wool or steel pads for they may scratch the
door frame finish.
Ashes
Remove ashes only when the fire is out and the
ashes are cold (24 to 48 hours after the fire is
out) Open the bottom louver and the doors,
lift the door trap lever, remove the plug on the
door trap of the ashtray using gloves or a poker.
Sweep the ashes in the opening with a brush
or any similar tool. Reinstall the plug on the
door trap and pull down the lever.
Do not leave the ashes in the house as they give
off carbon monoxide and other toxic gases.
1
Rotate the retainers to release the
combustor support plate while holding
it to make sure it does not drop.
Rotate the support plate and remove
the combustor.
Remove fly ashes on the combustor
using a soft brush.
Put the combustor back in place.
WARNING
Disposal of Ashes: Ashes should
be placed in a steel container
with a tight fitting lid and moved
outdoors immediately.
closed container of ashes should
be placed on a non-combustible
floor or on the ground well away
from all combustible materials,
pending final disposal. If the
ashes are disposed of by burial
in soil or otherwise locally dis-
persed, they should be retained
in the closed container until all
cinders have thoroughly cooled.
The
7
Advertisement
Table of Contents
