Installation Checklist - Kenmore POWER MISER 153.335862 Owner's Manual

Installation Instructions (cont'd)
Installation Checklist
BEFORE LIGHTING THE PILOT:
VENT PIPETO
OUTDOORS
Check the gas lines for leaks.
a. Use a soapy water solution• DO NOT test for gas leaks
usinga match or open flame.
b. Brush the soapy water solution on all gas pipes, joints and
fittings.
c. Check for bubbling soap. This means you have a leak.
Turn "OFF" gas and make the necessary repairs.
d. Recheck for leaks.
e. Rinse off soapy solution and wipe dry.
• Is the new temperature-pressure relief valve properly installed
and piped to an adequate dram. See Temperature-Pressure
Relief Valve" section.
• Are the cold and hot water lines connected to the water
heater correctly? See "Water Piping" instructions in the
"Installing the New Water Heater" section•
• Is the water heater completely filled w'th water? See "Filling'
instructions in the "Installing the New Water Heater" sec-
tion.
• Will a water leak damage anything? See the "Locating the
New Water Heater" section.
• is there proper clearance between the water heater and any-
thing that might catch fire? See the "Locating the New water
Heater" section.
• Do you have adequate ventilation so that the water heater
will operate properly? See "Combustion Air and Ventilation"
in the "Locat'ng the New Water Heater' section•
• Is the draft hood vent piping properly secured? See "Venting"
"nstructions "n the "Installing the New Water Heater sec-
tion.
• Is there proper clearance between the vent pipe and anything
that might catch on fire? See "Venting" instructions in the
"Installing the New Water Heater" section.
• Is the vent pipe properly sloped and does the vent terminate
outdoors? See "Venting" instructions in the "Installing the
New Water Heater" section.
• Do you need to call your gas company to check the gas pipe
and its hookup?
HOT
SHUTOFF
VALVE
COLD
TEMPERATURE-
PRESSURE RELIEF
VALVE
GASSUPPLY
SHUTOFFVALVE -
DISCHARGE PIPE
(Do not cap or plug)
(Sediment trap)
PIPECAI
_0 ANS _1.10 --
I I I
MA;_,I_4 _IllGSTATIC G_r_ p_ESBURE _ W.C
mm I;,xx. t_UT WN. O_T m
I_$_i_ W_C_ W_O_ W_C_
MODEL RATING PLATE
2O