Installation Checklist - Kenmore Economizer 6 153.333832 Owner's Manual

Installation Instructions (cont'd)
Installation Checklist
BEFORE LIGHTING THE PILOT:
• Check the gas lines for leaks.
a. Use a soapy water solution. DO NOT test for gas leaks
usinga match or open flame.
b. Brush the soapy water solution on all gas pipes, joints and
fittings.
c. Chec'_ for bubbling soap. This means you have a leak.
Turn "OFF" gas andmake the necessary repairs.
d. Recheck for leaks.
e. Rinse off soapy solution and wipe dry.
• ls the new temperature-pressure relief valve properly installed
and piped to an adequate drain? See "Temperature-Pressure
Relief Valve ' sect'on.
• Are the cold and hot water lines connected to the water
heater correctly? See "Water Piping" instructions in the
"Installation Instructions" section.
• Is the water heater completely filled with water? See "Filling"
mstrucnons m the Installat on Instruct ons sect on.
• Will a water leak damage anything? See the "Facts to
Consider About the Location" section.
-.IF---
HOT
GAS
SUPPLY
SHUTOFF
VALVE
TEE
VENT PIPE TO UL
LISTED ROOF JACK
TEMPERATURE.PRES.
SURE RELIEF VALVE
SHUTOFF
VALVE
COLD COLD
• Is there proper clearance
between the water heater and any-
thing that might catch fire? See the "Facts to Consider About
the Location" section.
• Do you have adequate ventilation so that the water heater
will operate properly? See "Combustion Air and Ventilation"
in the "Facts to Consider About the Location" section.
•
Is the draft hood vent piping properly secured? See "Venting"
instructions in the "Installation Instructions" section.
DRIP LEG
(Sediment trap)
PIPE CAP
I VALVE
PIPE
(Do not cap or plug.
Must terminate
beneath
Mobile Home.)
• Is there proper clearance between the vent pipe and anything
that might catch on fire. See Venting mstrucnons m the
"Installation Instructions" section.
• Is the vent pipe, properlysloped and does the vent terminate
outdoors. See Ventmg mstructmns In the Installatmn
Instructions" section.
Do you need to call your gas company to check the gas pipe
and its hookup?
_ WA'P_ H_R
'= I I I
P_LI, W/_, W,C WC
MODEL RATING PLATE
18