Table of Contents
Advertisement
CAUTION: Log appliances
installed in this firebox create
warm air currents. These currents
move heat to wall surfaces next
to firebox. Installing firebox next
to vinyl or cloth wall coverings or
operating firebox where impuri-
ties (such as, but not limited to, to-
bacco smoke, aromatic candles,
cleaning fluids, oil or kerosene
lamps, etc.) in the air exist, may
discolor walls or cause odors.
IMPORTANT: Vent-free gas log appliances
add moisture to the air. Although this is benefi-
cial, installing firebox in rooms without enough
ventilation air may cause mildew to form from
too much moisture. See Air for Combustion
and Ventilation, page 6.
IMPORTANT: Make sure the firebox is level.
If firebox is not level, log set will not work
properly.
Note: Your Vanguard firebox is designed to
be used in zero clearance installations. Wall
or framing material can be placed against any
exterior surface on the rear, sides or top of
your firebox, except where standoff spacers
are integrally attached. If standoff spacers
are attached to your firebox, these spacers
can be placed directly against wall or fram-
ing materials.
Use dimensions shown for rough openings to
create the easiest installation (see Built-In or
Internal Wall Firebox Installation, page 9).
INSTALLATION CLEARANCES
WARNING: Maintain the
minimum clearances. If you can,
provide greater clearances from
floor, ceiling and adjoining wall.
Carefully follow the instructions below. This
will ensure safe installation.
Minimum Wall and Ceiling Clearances
A. Clearances from edge of liner to any
combustible wall should not be less than
8" (see Figure 5).
B. Clearances from top of firebox opening to
the ceiling should not be less than 42".
126706-01A
INSTALLATION
Continued
www.SuperiorFireplaces.US.com
C. When the firebox is installed on carpet-
ing or other combustible material, other
than wood flooring, the firebox should be
installed on a metal or wood panel extend-
ing the full width and depth of enclosure.
D. Clearances from the bottom of firebox to
the floor is 0".
E. Clearances from open end of firebox to fac-
ing wall shall should not be less than 36".
CAUTION: Do not install fire-
box directly on carpet or vinyl.
CAUTION: Use only the clear-
ances specified in this manual or
on the firebox rating plate.
Minimum clearances to combustibles are:
• Sides of outer casing
• Drywall to sides and top of
front face
• Ceiling to opening
• Floor (see Minimum Wall
and Ceiling Clearances, note C)
• Perpendicular walls
Right and Left
• Distance to Facing Walls
on Sides and End of Firebox
0" Min. Clearance to Upper Frame/Wallboard
8" Min.
4"
Min.
Figure 5 - Minimum Clearance Front View
1/2" Min. Clearance
to Combustibles
43
/
3
4
4" Min. from the Perpendicular
Side Wall to the Edge of Facia
Figure 6 - Minimum Clearance - Top View
42' min.
36" min.
Ceiling
42" Min.
Edge of
Brick Liner
0" to Wood
24"
36" Minimum
from Edge of
Facial to
Facing Wall
on Open End
of Firebox
"
0" min.
0" min.
0" min.
4' min.
Floor
9
Advertisement
Table of Contents
