Honda HRX537HYEA Owner's Manual

Honda HRX537HYEA Owner's Manual

Hrx537hyea; hrx537hzea
Hide thumbs Also See for HRX537HYEA:

Advertisement

INTRODUCTION

Thank you for purchasing a Honda lawn mower.
This manual covers the operation and maintenance of the Honda
HRX537HYEA and HRX537HZEA lawn mowers.
We want to help you get the best results from your new mower and to
operate it safely. This manual contains the information on how to do
that; please read it carefully.
This manual should be considered a permanent part of the lawn
mower and should remain with it if it is resold.
If you have a problem or questions concerning the mower, contact
your supplying dealer.
We recommend that you read the warranty policy to fully understand
your rights and responsibilities. The warranty policy is a separate
document provided by your dealer.
Honda Power Equipment Mfg., Inc. reserves the right to make
changes at any time without notice and without incurring any
obligation.
No part of this publication may be reproduced without written
permission.

SAFETY MESSAGES

Pay special attention to statements preceded by the following words:
B
DANGER
B
WARNING
B
CAUTION
Each message tells you what the hazard is, what can happen, and
what you can do to avoid or reduce injury.
DAMAGE PREVENTION MESSAGES
You will also see other important messages that are preceded by the
following word:
Your lawn mower or other property can be
NOTICE
damaged if you don't follow instructions.
The purpose of these messages is to help prevent damage to your
lawn mower, other property, or the environment.
© 2004-2009 American Honda Motor Co., Inc.-All Rights Reserved
39VH7Y14
00X39-VH7-Y140
You WILL be KILLED or SERIOUSLY
HURT if you don't follow instructions.
You CAN be KILLED or SERIOUSLY
HURT if you don't follow instructions.
You CAN be HURT if you don't follow
instructions.
POM39VH7Y14
C2
IPC.xxx.2009.11
PRINTED IN U.S.A.
OWNER'S MANUAL
HRX537HYEA/HZEA
CONTENTS
INTRODUCTION . . . . . . . . . . . . 1
SAFETY MESSAGES . . . . . . . . 1
Safety Label Location . . . . . . . 3
IDENTIFICATION. . . . . . . . . . . . 3
SET-UP . . . . . . . . . . . . . . . . . . . 4
CONTROLS . . . . . . . . . . . . . . . . 4
Engine Oil Level. . . . . . . . . . . . 6
Petrol . . . . . . . . . . . . . . . . . . . . 6
OPERATION . . . . . . . . . . . . . . . 9
Mowing Precautions . . . . . . . . 9
Starting the Engine . . . . . . . . . 9
Mowing . . . . . . . . . . . . . . . . . 10
Stopping the Engine . . . . . . . 10
Mowing Tips. . . . . . . . . . . . . . 11
ENGLISH
(Original instructions)

LAWN MOWER

MAINTENANCE . . . . . . . . . . . . 12
The Importance of
Maintenance . . . . . . . . . . . . . 13
Engine Maintenance . . . . . . . 13
Control Cable
Adjustments. . . . . . . . . . . . . . 16
Installation . . . . . . . . . . . . . . . 16
Replacement . . . . . . . . . . . . . 16
TRANSPORTING/
STORAGE . . . . . . . . . . . . . . . . 19
TROUBLESHOOTING . . . . . . . 19
SPECIFICATIONS . . . . . . . . . . 20
Honda DistributorLocations
. . . . . . . . . . . . . . . . . . .Last page
1

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the HRX537HYEA and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Honda HRX537HYEA

  • Page 1: Table Of Contents

    INTRODUCTION Thank you for purchasing a Honda lawn mower. This manual covers the operation and maintenance of the Honda HRX537HYEA and HRX537HZEA lawn mowers. OWNER’S MANUAL We want to help you get the best results from your new mower and to (Original instructions) operate it safely.
  • Page 2: Safety Instructions

    To ensure safe operation – mowed. • Never operate the lawn mower with defective guards or • Honda lawn mowers are designed shields, or without safety devices (for example, deflectors to give safe and dependable service if and/or grass catchers in place).
  • Page 3: Safety Label Location

    SAFETY LABEL LOCATION COMPONENT IDENTIFICATION This label warns you of potential hazards that can cause serious injury. Carefully read meaning. If label comes off or becomes hard to read, contact your dealer for a replacement. Letter Meaning A [LABEL] [10] 1.
  • Page 4: Set-Up

    SET-UP ENGINE OIL The mower is shipped WITHOUT OIL in the engine. UNPACKING Remove all the cardboard from around the handlebar. Add enough SAE 10W-30 API service category SJ or later oil to HANDLEBAR SETUP bring the oil level between the upper limit [2] and lower limit [3] 1.
  • Page 5: Pre-Operation Checks

    ENGINE SWITCH [1] (HZEA TYPE) CUTTING HEIGHT ADJUSTMENT LEVERS There are seven adjustment settings. The Stops the engine. cutting height figures are approximate. The actual Running position (the 20 mm height of cut grass will vary key switch must be in with lawn and soil 32 mm the ON position to use...
  • Page 6: Engine Oil Level

    When a blade needs sharpening or replacement, take the lawn Petrol is highly flammable and explosive. mower to an authorized Honda dealer. Or, if you have a torque You can be burned or seriously injured when handling fuel. wrench, you can remove and install the blades yourself.
  • Page 7 Grass Bag NOTICE A lawn mower works like a vacuum cleaner; it blows air through the Fuel can damage paint and plastic. Be careful not to spill fuel when bag, which traps the grass clippings. Always empty the grass bag filling your fuel tank.
  • Page 8 If the rear shield is excessively worn, have it replaced by your authorized Honda servicing dealer. Clip Director Clip Director Knob Adjustment Adjust the Clip Director knob [1] in any one of the ten positions to achieve the desired mowing results.
  • Page 9: Operation

    High altitude performance can be improved by specific modifications to the carburetor. If you always operate your mower at altitudes above 1,500 meters, have a Honda dealer perform this carburetor modification. Even with carburetor modification, engine power will decrease about 3.5% for each 300 meter increase in altitude.
  • Page 10: Operating The Controls For Mowing

    Do not use the throttle lever to the engine to overheat and result in serious engine damage. For use adjust your forward speed. The at low altitudes, have your authorized Honda dealer return the throttle lever must remain in the carburetor to original factory specifications.
  • Page 11: Safe Mowing Practices

    SAFE MOWING PRACTICES MOWING TIPS For your safety, keep all four wheels on the ground, and be careful to When to Mow avoid losing your footing and your control of the mower. Keep a firm Most grasses should be mowed when they have grown 12 ~ 25 mm grip on the handlebar, and walk, never run, with the mower.
  • Page 12: Maintenance

    Mowing Patterns Remember that your Honda dealer knows your mower best and is Your Honda mower will work most efficiently if you use the following fully equipped to maintain and repair it. mowing patterns as much as possible. Mower deck and equipment...
  • Page 13: Maintenance

    Remove the filler cap/dipstick [1]. 1. Service more frequently when used in dusty areas. 2. These items should be serviced by an authorized Honda servicing b. Wipe the dipstick clean. dealer, unless you have the proper tools and are mechanically proficient.
  • Page 14 Air Cleaner Service 3. Inspect the spark plug. Replace it if the electrodes are worn or if the A dirty air filter will restrict air flow to the carburetor, reducing engine 0.7 ~ 0.8 mm insulator is cracked or chipped. performance.
  • Page 15: Adjustments

    5. If the mower does operate as outlined above, adjustment is BLADE SHARPENING: To avoid weakening the blades, or causing not required. imbalance or poor cutting, the blades should be sharpened by trained staff at an authorized Honda dealer. BLADE REPLACEMENT: Use Honda Genuine replacement blades or their equivalent. ENGLISH...
  • Page 16: Blade Removal And Installation

    Wash the bag with a garden hose, and allow it to dry completely before use; a wet bag will clog quickly. Replacement Replace a worn or damaged bag with a Honda replacement bag or its equivalent. Removal 1. Unclip the plastic 3.
  • Page 17 If a frequent fuse failure occurs, it usually indicates a short circuit or an overload in the electrical system. Take the mower to an authorized Honda servicing dealer for repair. TRANSPORTING/STORAGE 3. Connect the battery connector [3] to the charger [6] supplied with the mower.
  • Page 18: Storage

    Loading and Unloading Charging the Battery (HZEA type) Position the mower so all four wheels are on the bed of the transport To assure maximum reliability, the battery should be recharged (boost vehicle. Tie the mower down with rope or straps, and block the charged) both before and after prolonged storage (see page 16).
  • Page 19: Troubleshooting

    Fuel filter clogged, carburetor Take the mower to an authorized cover will trap moisture around the mower, promoting rust and malfunction, ignition malfunction, Honda servicing dealer or refer to the valves stuck, etc. shop manual for repair. corrosion. Removing from Storage VIBRATION Check your mower as described in PRE-OPERATION CHECKS.
  • Page 20: Specifications

    * Actual amount will vary due to residual oil in the engine. Always use the dipstick to confirm the actual level (see page 4). DRIVE Type Hydrostatic Engine to transmission V-belt Main clutch Fluid type Mower speed 0 ~ 1.61 m/s (engine @ 2,850 rpm) Recommended fluid Honda hydrostatic ENGLISH...
  • Page 21: Honda Warranty Conditions

    Felicidades por la compra de su cortacésped Honda. Honda le garantiza cualquier defecto de material y la mano de obra por un período de 2 años a partir de la fecha de compra (3 meses para uso profesional). Esta garantía no afecta sus derechos establecidos por ley, sinó que se añade a ellos.
  • Page 22: Ec Declaration Of Conformity

    “EC Declaration of Conformity” CONTENT OUTLINE “CE-Déclaration de conformité” DESCRIPTION DE TABLE DES MATIERES “EU-Konformitätserklärung” INHALTSÜBERSICHT DESCRIPCIÓN GENERAL DEL CONTENIDO DE LA “Declaración de Conformidad CE” DESCRIZIONE DEL CONTENUTO DELLA “Dichiarazione CE di Conformità” EG-Verklaring van Overeenstemming” CONTENT SCHEMA...
  • Page 24 FRANCE NETHERLANDS SLOVAK REPUBLIC (SLOVAKIA) Honda Motor Europe (North) Honda Relations Clientèle Honda Motor Europe (North) Honda Slovakia, spol. s r.o. Hondastraße 1 TSA 80627 Afd. Power Equipment-Capronilaan 1 Prievozská 6 - 821 09 Bratislava 2351 Wiener Neudorf 45146 St Jean de la Ruelle Cedex...

This manual is also suitable for:

Hrx537hzea

Table of Contents

Save PDF