Camera Recording - Sony CCD-TRV15 Service Manual

Color temperature
Auto
Minimum illumination
CCD-TRV15/TRV15PK : 0.4 lux (F 1.4)
CCD-TRV15E/TRV15EP : 0.4 lux (F
1.4)(Visible minimum low light 0.2 lux)
CCD-TRV25/TRV25PK/TRV35/
TRV35E/TRV65/TRV65PK/TRV85/
TRV93/TRV215/TRV615/TRV815 :
0.7 lux (F 1.4)
CCD-TRV35/TRV35E/TRV65/
TRV65PK/TRV85/TRV93/TRV615/
TRV815 :
0 lux (in NightShot mode)*
* Object invisible for the dark can be
shot with infrared lighting.
Illumination range
CCD-TRV15/TRV15PK/TRV15E/
TRV15EP : 0.4 lux to 100,000 lux
CCD-TRV25/TRV25PK/TRV35/
TRV35E/TRV65/TRV65PK/TRV85/
TRV93/TRV215/TRV615/TRV815 :
0.7 lux to 100,000 lux
Recommended illumination
More than 100 lux
LCD screen
Picture
CCD-TRV15/TRV15PK/TRV15E/
TRV15EP/TRV25/TRV25PK/TRV35/
TRV35E/TRV65/TRV65PK/TRV215/
TRV615 :
2.5 inches measured diagonally
2 x 1 1/2 in.(50.3 x 37.4 mm)
CCD-TRV85/TRV815 :
3.5 inches measured diagonally
2 7/8 x 2 in.(72.4 x 50.4 mm)
CCD-TRV93 :
3 inches measured diagonally
2 3/8 x 1 3/4 in.(59.5 x 43.2 mm)
On-screen display
TN LCD/TFT active matrix method
Total dot number
CCD-TRV15/TRV15PK/TRV15E/
TRV15EP/TRV25/TRV25PK/TRV35/
TRV35E/TRV65/TRV65PK/TRV215/
TRV615 : 61,380 (279 x 220)
CCD-TRV85/TRV815 :
105,380 (479 x 220)
CCD-TRV93 : 89,622 (383 x 234)
1. Check the area of your repair for unsoldered or poorly-soldered
connections. Check the entire board surface for solder splashes
and bridges.
2. Check the interboard wiring to ensure that no wires are "pinched"
or contact high-wattage resistors.
3. Look for unauthorized replacement parts, particularly transistors,
that were installed during a previous repair. Point them out to
the customer and recommend their replacement.
4. Look for parts which, though functioning, show obvious signs
of deterioration. Point them out to the customer and recommend
their replacement.
SAFETY-RELATED COMPONENT WARNING !!
COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH
MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.
Input and output connectors
S video input/output(CCD-TRV65/
TRV65PK/TRV85/TRV93/TRV615/
TRV815 only)
4-pin mini DIN
Luminance signal : 1 Vp-p, 75 ohms,
unbalanced
Chrominance signal : 0.286 Vp-p, 75
ohms, unbalanced
Video input(CCD-TRV65/TRV65PK/
TRV85/TRV93/TRV615/TRV815
only)/output
Phono jack, 1 Vp-p, 75 ohms, unbalanced
Audio input (CCD-TRV65/TRV65PK/
TRV85/TRV93/TRV615/TRV815
only)/output
CCD-TRV15/TRV15PK/TRV15E/
TRV15EP/TRV25/TRV25PK/TRV35/
TRV35E/TRV215 :
Monaural, Phone jack, 327 mV
CCD-TRV65/TRV65PK/TRV85/
TRV93/TRV615/TRV815 : Phono jacks
(2: stereo L and R) 327 mV, (at output
impedance 47 kilohms) impedance less
than 2.2 kilohms
RFU DC OUT
Special minijack, DC 5V
Headphone jack(CCD-TRV65/
TRV65PK/TRV85/TRV93/TRV615/
TRV815 only)
Stereo minijack (ø 3.5 mm)
Earphone jack(CCD-TRV15/
TRV15PK/TRV15E/TRV15EP/
TRV25/TRV25PK/TRV35/TRV35E/
TRV215 only)
Monaural minijack (ø 3.5 mm)
LANC control jack
Stereo minijack (ø 2.5 mm)
MIC jack
Mini jack, 0.388mV low impedance
with 2.5 to 3.0 V DC, output impedance
6.8 kilohms (ø 3.5 mm)
CCD-TRV15/TRV15PK/TRV15E/
TRV15EP/TRV25/TRV25PK/TRV35/
TRV35E/TRV215 : Monaural type
CCD-TRV65/TRV65PK/TRV85/
TRV93/TRV615/TRV815 : Stereo type
Speaker
Dynamic speaker
SAFETY CHECK-OUT
After correcting the original service problem, perform the following
safety checks before releasing the set to the customer:
Intelligent accessory shoe(CCD-
TRV65/TRV65PK/TRV85/TRV93/
TRV615/TRV815 only)
8-pin connector
General
Power requirements
7.2 V (battery pack)
8.4 V (AC power adaptor)
Averege power
consumption(when using the
battery pack)
During camera recording using
LCD
CCD-TRV15/TRV15PK/TRV15E/
TRV15EP : 3.1 W
CCD-TRV25/TRV25PK/TRV35/
TRV35E/TRV215 : 3.2 W
CCD-TRV65/TRV65PK/TRV615 :
3.3 W
CCD-TRV85/RV815 : 3.6 W
CCD-TRV93 : 3.4 W
Viewfinder
CCD-TRV15/TRV15PK/TRV15E/
TRV15EP : 2.5 W
CCD-TRV25/TRV25PK/TRV35/
TRV35E/TRV215 : 2.6 W
CCD-TRV65/TRV65PK/TRV85/
TRV615/TRV815 : 2.7 W
CCD-TRV93 : 2.6 W
Operating temperature
32°F to 104°F(0°C to 40°C)
Storage temperature
-4°F to +140°F(-20°C to +60°C)
Dimentions (Approx.)
CCD-TRV15/TRV15PK/TRV15E/
TRV15EP/TRV25/TRV25PK/TRV35/
TRV35E/TRV65/TRV65PK/TRV215/
TRV615 :
4 1/4 x 4 1/4 x 8 1/4 in.
(107 x 107 x 209 mm)(w/h/d)
CCD-TRV85/TRV815 :
4 1/2 x 4 3/8 x 8 1/2 in.
(114 x 111 x 214 mm)(w/h/d)
CCD-TRV93 :
4 1/2 x 4 3/8 x 8 1/2 in.
(114 x 109 x 214 mm)(w/h/d)
Mass (Approx.)
CCD-TRV15/TRV15PK/TRV15E/
TRV15EP/TRV25/TRV25PK/TRV215 :
1 lb 15 oz (890 g)
5. Check the B+ voltage to see it is at the values specified.
6. Flexible Circuit board Repairing
• Keep the temperature of the soldering iron around 270°C during
repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
ATTENTION AU COMPOSANT AYANT RAPPORT
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE ! SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE
REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY
DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU
DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
– 2 –
CCD-TRV35/TRV35E/TRV65/
TRV65PK/TRV615 : 1 lb 15 oz (900 g)
CCD-TRV85/TRV815 : 2 lb 1 oz (950 g)
CCD-TRV93 : 2 lb (930 g)
excluding the battery pack, lithium
battery, cassette and shoulder strap
2 lb 3 oz (1 kg)
including the battery pack NP-F330,
lithium battery CR2025, cassette and
shoulder strap
Microphone
CCD-TRV15/TRV15PK/TRV15E/
TRV15EP/TRV25/TRV25PK/TRV35/
TRV35E/TRV215 : Monaural type
CCD-TRV65/TRV65PK/TRV85/TRV93/
TRV615/TRV815 : Stereo type
Supplied accessories
See page 4.
AC power adaptor
Power requirements
100 -240 V AC, 50/60 Hz
Power consumption
23 W
Output voltage
DC OUT: 8.4 V, 1.5 A in operating mode
Operating temperature
32°F to 104°F(0°C to 40°C)
Storage temperature
-4°F to +140°F(-20°C to +60°C)
Dimentions (Approx.)
5 x 1 9/16 x 2 1/2 in. (125 x 39 x 62
mm)(w/h/d) excluding projecting parts
Mass (Approx.)
9.8 oz (280 g) excluding power cord
(Main lead)
Design and specifications are subject to
change without notice.
• Abbreviation
CND : Canadian Model
EE : East European Model
NE : North European Model
RU : Russian Model
HK : Hong Kong Model
AUS : Australian Model
JE : Tourist Model
CN : Chinese Model
BR : Brazilian Model
À LA SÉCURITÉ!!