Glass Door Removal; Glass Door Cleaning And Repair - Lennox FIRESTAR MERIT GC3 Installation And Operation Manual

Glass Door
• Do not attempt to substitute the materials used
on these doors, or replace cracked or broken
glass.
• Handle this glass with extreme care! Glass is
susceptible to damage – Do not scratch or handle
roughly while reinstalling the glass door frame.
• The glass door(s) of this appliance must only be
replaced as a complete unit as provided by the
manufacturer. Do not attempt to replace broken,
cracked or chipped glass separately.
• Do not attempt to touch the front enclosure glass
with your hands while the appliance is in use.
Do not operate appliance with the glass front
removed, cracked or broken.
Ne pas utiliser l'appareil si le panneau frontal en
verre n'est pas en place, est craqué ou brisé.
Only doors certified with the appliance shall be used.
Seules des portes certifiées pour cet appareil doivent être
utilisées.
CAUTION: DO NOT abuse glass door by striking or slamming
shut.
Do not remove glass door while the appliance is hot.
Glass Door Removal (refer to Figures 20a and 20b)
Open both latches on the right and left side of the door (they are centered
on the sides of the front door - see Figure 20a). With the latches released,
rotate the catch part of each latch outward away from the front door.
The door will pivot toward you from the top (hinging from the bottom
as shown in Figure 20b). On the bottom of the door there are tabs that
slide into slots on the firebox. Disengage the tabs on the door from the
slots on the firebox by lifting up on the door until it stops and slide the
door all the way to the left. You can then remove the door straight out
from the slots. To reinstall door reverse the steps above.
Glass Door Cleaning And Maintenance
Cleaning:
When cool, the glass may be cleaned with a clean, soft cloth
and a household glass cleaner. For cleaning white condensation from
the interior glass, use a gas fireplace glass cleaner available from your
insert dealer. Use of caustic or abrasive cleaners may damage the glass.
DO NOT operate the insert with broken glass. DO NOT clean door or glass
when hot. DO NOT abuse the glass door by striking or slamming it shut.
DO NOT use substitute materials if replacing the glass. DO NOT spray
commercial glass cleaner with ammonia on the door and glass gasket
as it may dissolve the gasket glue.
20
WARNING
WARNING
AVERTISSEMENT
Glass Door Cleaning And Maintenance
Cleaning:
Do not remove or clean the glass door when hot. When cool,
the glass may be cleaned with a clean, soft cloth and a household glass
cleaner. For cleaning white condensation from the interior glass, use
a gas fireplace glass cleaner available from your dealer. Use of caustic
or abrasive cleaners may damage the glass. DO NOT spray commercial
glass cleaner with ammonia on the door and glass gasket as it may dis-
solve the gasket glue.
Repair: If the glass is broken in the glass door, the entire door (metal
frame, gasket and glass) should be replaced as a unit. This replacement
unit is available from your Lennox Hearth Products dealer. Do not use
substitute parts or materials. The glass is neo-ceramic and alternative
types must not be used.
NOTE: BE CAREFUL NOT TO SPRAY COMMERCIAL GLASS
CLEANER WITH AMMONIA ON GASKET AREA OF DOOR. AM-
MONIA WILL DISSOLVE GASKET GLUE.
NOTE: GOLD PLATED SURFACE MUST BE CLEANED WITH GLASS
CLEANER AND SOFT RAG BEFORE FIRING THE FIRST TIME OR
FINGER PRINTS AND STAINS WILL REMAIN PERMANENTLY.
NEVER USE BRASS POLISH TO CLEAN GOLD, THIS WILL RE-
MOVE GOLD PLATING!
Open the top door latches by pulling them forward and up.
Figure 20a
Lower Front Door Tabs
Lift the glass door up and off the lower spring latch
Figure 20b
Side Door Latches
Door